Bajaj Auto Avenger 150 Street Owner's Manual - page 17

Manual is about: DTS-i

Summary of Avenger 150 Street

  • Page 1

    Foreword dear customer, congratulations on becoming the proud owner of a “avenger 150 dts-i” motorcycle, one of the finest motorcycles in the country. Your safety and the safety of others is extremely important. Hence, before you ride the bike, please read this owner's manual carefully and familiari...

  • Page 2

    Description 1. Technical specifications 1 2. Identification data 3 3. Location of parts 4 4. Steering cum ignition lock 5 5. Fuel tank cap / fuel tap 6 6. Speedometer details 7 7. Control switches 8 8. Removal & fitment of side covers 10 9. Battery / tool kit 11 10. Daily safety checks 12 11. How to...

  • Page 3

    Brakes front brake : hydraulic disc brake. Rear brake : mechanical expanding shoe. Fuel tank capacity full : 13 liters reserve : 3.8 liters dimensions length : 2077 mm width : 801 mm height : 1070 mm wheel base : 1480 mm ground clearance : 169 mm tyre size front tubeless : 90/90 - 17, 49p rear tubel...

  • Page 4

    2 technical specifications tyre pressure 2 front : 1.5kg/cm (21psi) 2 rear (solo) : 1.5kg/cm (21psi) 2 rear (with pillion ) : 1.75kg/cm (25psi) vehicle kerb weight : 149 kg. Gross vehicle weight : 299 kg. Electrical system : 12 volts dc battery : 12v, 4ah vrla head lamp : 55/60w blue tinge pilot lam...

  • Page 5

    Identification data the frame and engine serial numbers are used to register the motorcycle. They are the unique alpha-numeric codes to identify your particular vehicle from others of the same model and type. Frame number location on side of steering tube (alpha-numeric - 17 digits) engine number lo...

  • Page 6

    Location of parts 4 fuel tank cap rear shock absorber grab handle speedometer brake lever steering lock pillion foot rest ignition switch brake pedal front fork with bellow.

  • Page 7

    Steering cum ignition lock 5 ignition lock : it is located at right side of the frame below ‘fuel tank’. It has three positions. The key can be removed from switch only in ‘off’ position. Key position function off engine off. All electrical circuits off on engine can be started in this position by s...

  • Page 8

    Fuel tank cap / fuel tap 6 to lock fuel tank cap : • to open fuel tank cap, insert ignition key into the lock and turn it clockwise & lift cap. • to close cap, push it down into place with key inserted. Key can be removed by turning it anti-clockwise to original position. Precaution : dont attach me...

  • Page 9

    Speedometer details 7 speedometer display will glow with ignition switch ‘on’ 1. Speedometer : the speedometer pointer shows the speed of the vehicle in km/hr. 2. Odometer : it shows the total distance that the vehicle has covered. 3. Trip meter : it shows the distance traveled since it was last res...

  • Page 10

    Speedometer setting 8 after power on speedometer pointer moves from 0 to 160 & returns back to zero. Odo meter (odo): • 6 digits with 'odo' & 'km' icons. • after 9, 99,999 km, the odometer display rolls over to 0 and continue updating. Trip meter (trip): • 4 digits with a decimal point after third d...

  • Page 11

    Control switches c. Horn button : ( ) press button for sounding horn. D. Pass switch : press the switch to flash the head light. It is used to give signal to vehicles coming from opposite side while overtaking. Left handle bar switches a. Dipper switch : when headlight is on, high or low beam can be...

  • Page 12: Aho  Feature

    10 control switches hi/low beam headlamp effect of switch status pass switch low beam low beam ‘on’ hi beam ‘on’ hi beam hi beam no change ‘on’ aho feature (automatic headlight ‘on’) there is no ‘light switch’ on rh control switch. Ignition switch ‘on’ speedometer illumination engine ‘off’ tail lamp...

  • Page 13

    Removal & fitment of side cover 11 removal of side cover rh • insert the key into the cover lock (a) and turn the key clockwise. • pull front side (b) first • slide side cover toward rear (c). • take out ‘side cover’. Fitment of side cover rh • match ‘side cover’ rear bullet (d) with bracket (e) loc...

  • Page 14

    Battery / tool kit 12 battery • it is located inside the ‘side cover’ rh. • always keep a watch on battery charge level indicating icon, if it flashes (indicates battery is in low charged condition), bring the vehicle to authorised bal dealer. Tool kit location • tool kit is located in tool kit comp...

  • Page 15

    Daily safety checks • brake pedal play - 20 to 30 mm. • wear lining indicator within usable range. No brake dragging. • brake fluid level above min mark provided on reservoir, applicable to disc brake vehicle. • drive chain slack of 25 to 35 mm adequately lubricated. • function of all lights & horn ...

  • Page 16

    How to ride your bike 14 note : when the engine is already warm on hot 0 days (higher than 35 c), open the throttle part away instead of using the choke, and then start the engine. Caution : do not operate the starter continuously for more than 5 seconds. Wait for 15 seconds before you recrank. Note...

  • Page 17

    Braking : • close the throttle completely, leaving the clutch engaged (except where shifting gears) so that the engine braking will help slow down the motorcycle. • shift down one gear at a time so that you are in neutral when you come to a complete stop. • when stopping, always apply both brakes at...

  • Page 18

    Stopping the vehicle : • close the throttle completely. • shift the transmission into neutral. • bring the vehicle to complete stop. • turn the ignition switch off. Parking the vehicle : • support the motorcycle on a firm level surface with the center or side stand. • lock the steering. Running in p...

  • Page 19

    How to ride your bike fuel saving tips : a well maintained vehicle and good driving can contribute a lot to the saving of petrol. Following are a few simple fuel saving tips. Good riding habits : • ride smoothly and steadily at an optimum driving speed of 40 to 50 km/h • avoid harsh braking. • chang...

  • Page 20

    Safe riding tips • drive cautiously. Start early & reach your destination safely. • always carry vehicle registration & insurance papers, and a valid driving licence with you. • avoid driving on loose sand or stones where vehicle is likely to skid. • properly wrap-up loose clothes while driving or r...

  • Page 21

    Engine oil engine oil level checking : • check engine oil level every day. Park vehicle on level surface. • check oil level through oil level gauge ‘b’. • always maintain engine oil level between upper (c) and lower (d) mark provided on cover rh. Top up with specified grade of oil if the oil level i...

  • Page 22

    Battery 20 battery : 12v - 4 ah vrla • battery is located inside side cover rh. Battery features : • no topping-up is required • reduced self discharge, enhance safety. • no vent tube open to atmosphere hence no discharge of electrolyte through vent tube. • it is always recommended to hand over the ...

  • Page 23

    Wheels - tyre tyre pressure : keep appropriate tyre pressure as mentioned below to increase life of the tyre & for better fuel consumption. Note : incase the motorcycle is fitted with imported tyres. Compliance to respective indian standard & central motor vehicle rules has been ensured. 21 avenger ...

  • Page 24

    Periodic maintenance information 22 a b min front brake fluid level • front brake fluid master cylinder reservoir is located near rh switch on handle bar. • to check oil level, keep the vehicle on centre stand with handle bar in straight position. • always ensure that brake fluid level is above ‘min...

  • Page 25

    Periodic maintenance information spark plug • remove spark plugs by using plug spanner. • clean the spark plugs. • adjust the gaps if incorrect by bending outer electrode carefully. Spark plug gap : 0.7 to 0.8 mm. Spark plug (2 nos.) : champion rg4hc bosch - ur6ce drive chain slackness • chain slack...

  • Page 26

    Periodic maintenance information drive chain must be cleaned & lubricated as per periodic maintenance schedule. Drive chain (o-ring type) • ‘o’ rings must always be kept wet for best performance hence lubricate every 500 km. • o-ring chain lubrication can easily be done by owners using bajaj ‘chain ...

  • Page 27

    25 customer id : instruction to avail free service through digitized free service coupon please follow following procedure : - • please provide your mobile number to dealer at the time of buying of new bajaj vehicle. • in case of change in mobile number, please update to dealer / asc. • you will rec...

  • Page 28

    Periodic maintenance & lubrication chart 26 recommended frequency servicing sr. No. Operation st 1 free 500 ~ 750 nd 2 free 4500 ~ 5000 rd 3 free 9500 ~ 10000 kms subsequent every 5000 km after previous service 1. Water wash & dry the vehicle ensure to prevent water completely entry in petrol tank, ...

  • Page 29

    Periodic maintenance & lubrication chart 27 recommended frequency servicing sr. No. Operation st 1 free 500 ~ 750 nd 2 free 4500 ~ 5000 rd 3 free 9500 ~ 10000 kms subsequent every 5000 km after previous service  tick in the box after replacing the periodic parts. 9. Air filter cover ‘o’ ring cl,r c...

  • Page 30

    Periodic maintenance & lubrication chart 28 recommended frequency servicing sr. No. Operation st 1 free 500 ~ 750 nd 2 free 4500 ~ 5000 rd 3 free 9500 ~ 10000 kms subsequent every 5000 km after previous service 20. Silencer tail pipe cleaning** cl cl cl cl cl cl cl 21. Brake cam & brake pedal pivot ...

  • Page 31

    Periodic maintenance & lubrication chart 29 recommended frequency servicing sr. No. Operation st 1 free 500 ~ 750 nd 2 free 4500 ~ 5000 rd 3 free 9500 ~ 10000 kms subsequent every 5000 km after previous service 29. Handle bar control switches c,cl c,cl c,cl c,cl c,cl c,cl c,cl c,cl use wd40 spray co...

  • Page 32

    30 periodic maintenance & lubrication chart 38. Coolant level in expansion tank** c,a c,a c,a c,a c,a c,a c,a c,a use recommended 'ready to use coolant'. 39. Coolant hose damage/clamps/leakage** c c c c c c c 40. Radiator fins** c c c c c c c 41. Spoke tightening**-front & rear c,t c,t c,t c,t c,t c...

  • Page 33

    Non-use maintenance non-use maintenance is necessary if a vehicle remains off road for a longer duration (more than 15 days**). The correct and careful non- use maintenance carried out before storing the vehicle will prevent the vehicle from rusting and from such other non-operational damages like f...

  • Page 34

    32.

  • Page 35

    Delivery certificate 33 frame no. : engine no. : sold on.: customer’s name mr/mrs/miss : address : contact no. : i have taken possesion of motorcycle along with the following items. 1. Owner's manual 5. Standard accessories 2. 2 nos of key 6. Battery make ___________ sr. No. ____________ 3. Set of t...

  • Page 36

    Warranty : scope & limit bajaj auto limited gives the following warranty in respect of the “avenger 150 dts-i motorcycle manufactured by them. Every possible care and precaution has been taken to ensure quality in respect of the material & workmanship in the vehicles manufactured by us. Bajaj auto l...

  • Page 37

    To remove and despatch the part / parts attributing to the manufacturing defect to the company. B. Produces the owner's manual, in original, to enable that dealer to verify the details. It must be expressly understood that claims forwarded directly to us by the owner / customers will not be entertai...

  • Page 38

    7. All chrome plated parts are prone to rust or corrosion in coastal area or in acidic environment or due to neglected cleaning etc. However chrome film peeling is covered under warranty in general atmospheric conditions. Blue/ yellow colouration of silencer near exhaust port is permissible and henc...

  • Page 39: Battery  Warranty  Card

    Service record sr. No. Date age mths. Specific gravity voltage remarks dealer’s stamp & signature * code 1 2 3 4 5 6 battery warranty card make of battery : ........................ Mfg. Code of battery : sr.No.: type of battery : date of sale : name of owner and address : type of vehicle : reg. No....

  • Page 40: In  Case  Of  Claim

    Details of repair, if any____________________________________________________________________________ note: please contact nearest respective authorised battery dealer for details immediately after purchase of vehicle. Name of dealer & code :__________________________________________________________...