- DL manuals
- C.T.M.
- Mobility Aid
- HS-2850
- User Manual
C.T.M. HS-2850 User Manual
Summary of HS-2850
Page 1
C.T.M. Mini power chair c.T.M. Mini power chair c.T.M. Mini power chair hs-2850 user's manual.
Page 2
User's manual hs-2850 table of contents introduction important precautions electromagnetic interference and warnings identification of parts operating your power chair disassembling / re-assembling your power chair charging the batteries care and maintenance troubleshooting technical specifications ...
Page 3: C.T.M.Homecare Product, Inc.
User's manual hs-2850 c.T.M.Homecare product, inc. 6191 schaefer ave suite b chino ca 91710 tel : +909-590-1388 fax : +909-590-3365 e-mail : ctm@ctmhomecare.Com http : //www.Ctmhomecare.Com if you have any question, please contact your local dealer or: or your local dealer: introduction 1 thank you ...
Page 4
User's manual hs-2850 important precautions 2 •only one person at a time can ride a c.T.M. Power chair. •maximum load is 136 kg/300 lbs. •turn off power before getting on or off your power chair. •always drive carefully with your feet on the footplate and be aware of others in your area. •always use...
Page 5
User's manual hs-2850 electromagnetic interference and warnings 3 caution: it is very important that you read this information regarding the possible effects of electromagnetic interference on your power chair. Powered wheelchairs and motorized scooters may be susceptible to electromagnetic interfer...
Page 6
User's manual hs-2850 4 3.Long-range transmitters and transceivers such as commercial broadcast transmitters (radio and tv broadcast antenna towers) and amateur (ham) radios. Because em energy rapidly becomes more intense as one moves closer to the transmitting antenna (source), the em fields from h...
Page 7
User's manual hs-2850 on/off button horn joystick speed control button self diagnostic warning lights & battery gauge rear bag armrest width adjustment thumbscrews armrest height adjustment thumbscrews rear reflectors figure 1 - hs-2850 power chair front view figure 2 - hs-2850 joystick figure 3 - h...
Page 8
User's manual hs-2850 6 joystick ： •self diagnostic warning lights flashing of lights indicates there is a problem within power chair. See page 17 for more information. •battery gauge there are eleven led lights on joystick. When all led lights are on, batteries are fully charged; the battery gauge ...
Page 9
User's manual hs-2850 7 footplate ： •footplate the footplate can be adjusted according to your specific needs. It can be width & adjusted vertically or horizontally. To adjust footplate, loosen screw and arrange height to desired position, then, tightened screw to secure plate in place. (d & e) figu...
Page 10
User's manual hs-2850 figure 9 figure 9 figure 10 figure 10 operating your scooter 8 before beginning your journey with your new power chair, make sure power chair is on a level surface and clear of any obstacle. Although your power chair is able to climb slopes, it is safer to practice on a leveled...
Page 11
User's manual hs-2850 figure 11 figure 11 figure 12 figure 12 9 headrest adjustment ： seat adjustment ： by pressing (k) to adjust the headrest (j) up & down to a comfortable position. By lifting up lever (l) to rotate seat (u) note: do not swivel seat angle over 90 degrees, to prevent wires twist. W...
Page 12
User's manual hs-2850 10 figure 14 figure 14 fixation screw fixation screw fixation screw fixation screw (b). Seat's depth adjustment by releasing fixation screws from back sides, and adjust to a comfortable position, then tighten with fixation screws. Figure 15 figure 15 fixation vel-cro fixation v...
Page 13
User's manual hs-2850 other operating information ： hill climbing : you may need to use a higher speed. For a higher speed, turn speed dial clockwise. Down slopes : proceed with dawnward slope slowly, and turn speed dial counterclockwise. This enables good control when speed is set in slower motion....
Page 14
User's manual hs-2850 12 disassembling / re-assembling your power chair joystick cable removal ： please follow instructions below to remove joystick cable (m) from armrest. 1.Unplug joystick cable (see fig. 20). 2.Press lock pins underneath front and along seat sides to unlock, then lift chair up to...
Page 15
User's manual hs-2850 be careful when carry the batteries as they are heavy. Do not connect the positive (+) to the negative (-) battery terminal by any conductive metals. Battery removal ： 1.Disconnect two battery plugs (q) (see fig. 23). 2.Unfasten velcro strap that hold batteries in place (see fi...
Page 16
User's manual hs-2850 14 charging the batteries your c.T.M. Power chair is equipped with two, service free 12v 36ah rechargeable batteries and one 24v/5a off-board charger. Batteries must be charged before using power chair for the first time and it is recommended to be charged up to 8 - 14 hours af...
Page 17
User's manual hs-2850 the time needed to recharge will vary depending on depletion of batteries. Charging for longer than necessary will not harm batteries. They cannot be overcharged. Keep in mind these rules ： •fully charge batteries at least once a month; more if you use power chair regularly. Ch...
Page 18
User's manual hs-2850 an authorized dealer should handle all maintenance and repair associating with electronics, batteries, motor parts, and tires. Here are the guidelines that can be followed by authorized dealer. 16 care and maintenance taking care of your power chair will keep it in top-notch co...
Page 19
User's manual hs-2850 17 tire pressure (for air-filled tires only): the condition of tires and maintenance of specified tire pressures not only influence tire life, but also effect road safety to a very considerable extent. Incorrect pressure is often a cause of tire problems and could result in an ...
Page 20
User's manual hs-2850 troubleshooting flash code description 1 2 3 4 5 6 7 8 9 10 11 user fault battery fault left motor fault right motor fault left park brake fault right park brake fault shark remote fault shark power module fault shark communications fault unknown fault incompatible remote possi...
Page 21
User's manual hs-2850 other problems ： 19 •power chair will not move when power is turned on : 1.Check battery gauge on joystick. All led lights should be on. 2.Check self-diagnostic warning light. It should be steady; if it is flashing, see the chart on page 17 for problem identification. 3.Check a...
Page 22
User's manual hs-2850 *subject to change without notice. (issue a) specification 20 overall length overall width overall height wheels: front wheels: middle wheels: rear weight w/ batteries max. Speed weight capacity ground clearance grade climbable curb climbing turning radius brake seat width driv...