Garador Garage Door Opener Instruction Manual

Summary of Garage Door Opener

  • Page 1

    Instruction manual garador is a division of b&d australia pty ltd abn 25 010 473 971 www. Garador.Co.Nz 72941 p/n: 05xxxx.

  • Page 3

    Please read these important safety rules caution: if your garage has no pedestrian entrance door, an emergency access device should be installed. This accessory allows manual operation of the garage door from outside in case of power failure. These safety alert symbols mean caution – a personal safe...

  • Page 4

    System specifications maximum door size 3000mm high 5500mm wide (16.5m 2 ) residential rolling garage door or 2400mm high wind lock residential rolling garage maximum door load door that does not exceed 200n (20kgs) bottom rail load. Recommended load 70n (7kgs) supply voltage 220 - 240 v ac 50/60hz ...

  • Page 5

    ©copyright 2006 garador p/n: 05xxx - 5 - about your garador opener thank you for choosing a garador automatic garage door opener. The technically advanced construction of this garador opener ensures you enjoy the following benefits: warranty five (5) year/10,000 cycles full parts and labour warranty...

  • Page 6

    P/n: 05xxx - 6 - opener features 1 2 3 4 5 6 1. Fuse 2. Terminal block - gnd ir beam 30v pwr operate cls out aux out 3. Led light array 4. Antenna terminal 5. Service led indicator (yellow) 6. Operate button (blue) 7. Limit set button (black) 7 8 9 10 11 12 16 13 14 8. Code set led indicator (red) 9...

  • Page 7

    ©copyright 2006 garador p/n: 05xxx - 7 - tools you may need for installation q suitable door support q ladder q phillips screwdriver q suitable sockets and handle with a 150mm extension q 450mm pipe wrench (stillson) or similar q adjustable wrench or spanner set q marking pencil q tape measure q dri...

  • Page 8

    ©copyright 2006 garador p/n: 05xxx - 8 - section 1 - requirements important safety instructions for installation warning – incorrect installation can lead to severe injury follow all installation instructions as3350 1.1 - door operation the door must be in good operating condition and the maximum ef...

  • Page 9

    ©copyright 2006 garador p/n: 05xxx - 9 - section 2 - installation procedure the following is the preferred method for installing the opener. Step 1 - preparation a. Check the door operation: i. The door must travel smoothly and be easy to operate by hand. Ii. Operating force on the bottom rail shoul...

  • Page 10

    ©copyright 2006 b&d doors p/n: 05xxx - 10 - installation step 3 - pinning the door curtain pin the door curtain to the door drum at each end of the door to maintain security when the opener closes and locks. With the door fully closed: 1. Mark positions to drill in both end of the drum. ( fig. 7 ) 2...

  • Page 11

    ©copyright 2006 b&d doors p/n: 05xxx - 11 - installation step 5 - assembling the ring gear 1. Insert the two forks into the ring gear as per fig. 9. 2. Secure with m6x45 hex head screw and washer. Step 6 - mounting the opener 1. If the ring gear does not rotate freely switch the opener to manual by ...

  • Page 12

    For the garage door opener to function properly the door travel limits, door travel force settings and remote control transmitter codes will need to be programmed. For normal operation of the garage door opener there are 3 steps, for optional advanced features see programming optional remote control...

  • Page 13

    ©copyright 2006 garador p/n: 05xxx - 13 - programming the opener step 8 - remote control transmitter code setting the garage door opener can only operate from remote control transmitters that have been programmed into the opener’s receiver. The receiver needs to learn the codes of any remote control...

  • Page 14

    ©copyright 2006 garador p/n: 05xxx - 14 - step 9 - testing the safety system the opener automatically adjusts the force required to reverse when closing or to stop when opening when an obstruction is encountered. The operation of the safety system must be tested whenever there has been any change in...

  • Page 15

    ©copyright 2006 garador p/n: 05xxx - 15 - special features step 10 - programming special features 10.1 - programming optional remote control transmitter features. You can program each button of your multi channel remote control transmitter so that each button performs a different function. You can p...

  • Page 16

    ©copyright 2006 garador p/n: 05xxx - 16 - special features 10.5 - code setting “pet mode” the opener can be programmed into a “pet mode” where the door opens approximately 200mm to allow pet to enter/ exit the garage: 1. Press code set button five times, the code set led will illuminate and the cour...

  • Page 17

    ©copyright 2006 garador p/n: 05xxx - 17 - section 3 - acessories 3.1 - remote aerial – part no 062177 some sites can cause poor radio reception, ie wherever there is a large mass of metal like all steel garages or underground car parks (large masses of steel reinforced concrete). Metal mass can caus...

  • Page 18

    ©copyright 2006 garador p/n: 05xxx - 18 - acessories 3.3 - safety infra-red beam - part no 062153 for additional safety protection we strongly recommend the fitting of a safety infra-red beam. In most countries safety beams are mandatory on all garage doors fitted with automatic openers. For a small...

  • Page 19

    ©copyright 2006 garador p/n: 05xxx - 19 - section 4 - how to use your opener for maximum efficiency of your opener, your garage door must be in good operating condition. An annual service of your garage door by an authorised dealer is recommended. (refer to warranty conditions in section 8). 4.1 - r...

  • Page 20

    ©copyright 2006 garador p/n: 05xxx - 20 - how to use your opener 4.2 - inbuilt locking facility do not lock your door with the locking bars when your opener is engaged. This opener has an inbuilt locking facility. With the opener engaged your door will be locked whether the power is on or off. 4.3 -...

  • Page 21

    ©copyright 2006 garador p/n: 05xxx - 21 - how to use your opener 4.5 - safety infra red beam option a safety infra red beam kit (part no 62153) may be fitted to this opener. • when this option is fitted, the operation of this device is such that if an object (i.E. Car, child, etc) blocks the infra r...

  • Page 22

    ©copyright 2006 garador p/n: 05xxx - 22 - 5.3 - yearly we suggest that you contact your nearest authorised dealer to perform an annual door service. 5.4 - warranty expired indicator when the opener reaches the number of cycles covered by warranty the courtesy light will flash 10 times after each ope...

  • Page 23

    ©copyright 2006 garador p/n: 05xxx - 23 - symptom possible cause remedy the opener does not work from either the button on the light cover or the hand remote control transmitter garage door in poor condition e.G. Springs may be broken manual door lock engaged the opener does not have power check the...

  • Page 24

    ©copyright 2006 garador p/n: 05xxx - 24 - section 7 - parts list item order no. Description code 1 drive chassis vr1 2 clutch geared mot or assy 13 ws 3 hex serra tion head screw m6x16 4 transformer tdb-100-143 kit 5 cord grip grommet sb5p-2 6 power cord a.S 1.5m w2p+1r 7 emc fil ter board emc-2.01 ...

  • Page 25

    ©copyright 2006 garador p/n: 05xxx - 25 - 1. Definitions ‘ garador ’ means ( a ) in new zealand - b&d doors nz ltd of 70 allens road east tamaki auckland, which is a subsidiary of b&d australia pty ltd. ‘purchaser’ means the purchaser of the opener. ‘opener’ means the ‘controll-a-door automatic gara...

  • Page 26

    ©copyright 2006 garador p/n: 05xxx - 26 - 9. Subject to paragraph 12 hereof; (i) the obligations of garador under this warranty are limited to those contained herein and such warranties are expressly in lieu of all other warranties, express or implied, including any implied warranty of merchantabili...

  • Page 27

    ©copyright 2006 garador p/n: 05xxx - 27 - there is a range of additional accessories for your added convenience and security. • safety infra red beams - part n o 062153. Gives additional protection if the door is closing onto your property or person. Simply breaking the beam “stops” the door! Must b...

  • Page 28

    Nz office : 70 allens road, east tamaki, auckland. Ph: (09) 273 8600 www.Bnd.Co.Nz garador is a division of b&d australia pty limited - abn 25 010 473 971 www. Garador.Co.Nz ©copyright 2006 garador . All rights reserved. ® and ™ are registered trademarks of garador pty ltd. In an ongoing commitment ...