M Design DIAMOND Gas 1150V Instructions For Installation And Use Manual - page 5

Summary of DIAMOND Gas 1150V

  • Page 1

    Luna gas diamond gas 550v-550dv-850v-850dv-1150v 02-2017 instructions for installation and use diamond gas 550v-dv-850v-dv-1150v instructions for installation and use.

  • Page 2: F I R E P L A C E S

    Instructions for installation and use diamond gas 550v-dv-850v-dv-1150v v e r y i m p o r ta n t i n s ta l l at i o n i n s t r u c t i o n s f o r t h e m - d e s i g n g g a s f i r e p l a c e s t h e s u p p l i e r ta k e s n o r e s p o n s b i l i t y f o r a n y p o s s i b l e d a m a g e ...

  • Page 3

    3 instructions for installation and use diamond gas 550v-dv-850v-dv-1150v summary 1. General remarks ........................................................... 5 2. Connection ...................................................................... 5 3. Installing the fireplace .........................

  • Page 4: Open En Close The Door

    4 instructions for installation and use diamond gas 550v-dv-850v-dv-1150v open en close the door for initial setup, you need to clean the window and clear the fireplace of any dust and grease that is left behind. This is also the only maintenance action that may be performed on the device by the use...

  • Page 5

    5 instructions for installation and use diamond gas 550v-dv-850v-dv-1150v 1. General remarks this is an appliance using the closed combustion system, designed for the atmosphere and comfort of your living-room. It constitutes an efficient source of heat and gives the impression of a real fire. The b...

  • Page 6

    6 a min = 3,5 cm b = 19 cm c min = 22.5 cm instructions for installation and use diamond gas 550v-dv-850v-dv-1150v 3. Installing the fireplace after having checked the appliance, you are ready to install your appliance. This is done as follows 3.1.1 positioning the appliance place the appliance on a...

  • Page 7

    To second burner or side burner 7 instructions for installation and use diamond gas 550v-dv-850v-dv-1150v for safety reasons, the gasbattery or “nearbox” is fixed with screws at the rear of the unit during transport . The unit cannot be installed with this nearbox fixed at the rear, it is man- dator...

  • Page 8

    Gas supply to side burner or second burner (yellow) 220v nearbox connection gas 1/2” (provide tap) 8 instructions for installation and use diamond gas 550v-dv-850v-dv-1150v opening provided in wall for maintenance cable to ionistation pin gas supply to main burner ( red) flexible for gas true vision...

  • Page 9

    9 instructions for installation and use diamond gas 550v-dv-850v-dv-1150v 3.1.4 electrical connection these appliances are equipped with a radiographic remote control, making an earthened 220v socket necessary. You should bear in mind that the appliance must be connected to all electrical supplies f...

  • Page 10

    10 instructions for installation and use diamond gas 550v-dv-850v-dv-1150v picture 1: roof exit (c31) the concentric flue duct should not be reduced to 150/100 for all true vision. Picture 1 4. Installing the chimney install the concentric flue duct as indicated by ontop - metaloterm. The only autho...

  • Page 11

    * usdhc13 or usdhc10 * 11 instructions for installation and use diamond gas 550v-dv-850v-dv-1150v picture 2: roof exit via existing chimney (c91s) it is obligatory to use the termination set ussan with positioning. Flex 130mm or 100mm this ussan piece must be sealed at the roof! Picture 2 tab 2 Ø 15...

  • Page 12

    12 usvk13 reduction 200/130 to 150/100 instructions for installation and use diamond gas 550v-dv-850v-dv-1150v picture 3: wall exit (c11) important : be carefull every horizontal part does not have a negative in clination in direction of the outlet. It is even better, when possible to have a little ...

  • Page 13

    13 1 2 3 4 detail a position 1 = min position 4 = max a instructions for installation and use diamond gas 550v-dv-850v-dv-1150v picture 4: roof exit with bend appliance Ø 150/100 en/ et Ø 200/130 850v / 850dv / 1150v 550v / 550dv for each 90° bend subtract 1m horizontally or add 1m vertically 850v /...

  • Page 14

    14 b a min. 5 mm instructions for installation and use diamond gas 550v-dv-850v-dv-1150v 6. Insulation and finishing once installation is complete, the appliance can be fitted. Before doing so, check the tightness of the gas pipe one more time. Light the appliance and check that it is wor- king: che...

  • Page 15

    15 instructions for installation and use diamond gas 550v-dv-850v-dv-1150v 7. Convenction current it is mandatory to equip the fireplace with a convection kit consisting of inlets and outlets which are connected to stretchable hoses from 3m to 5m. In this way is created a circualtion and evacuation ...

  • Page 16

    16 2xØ150 13 126 126 200 200 550 350 1223 82 64 72 268 114 44 488 484 82 2 2 484 488 484 82 92 92 44 115 70 82 269 28 1 465 2xØ150 64 13 495 ext. 82 489 82 2xØ150 13 64 82 115 44 70 269 92 92 28 1 499 479 int. 473 int. 499 2 2 488 499 465 481 3,5 3,5 489 5 5 489 instructions for installation and use...

  • Page 17

    17 mirror masonry masonry mirror main outlet mirror masonry masonry mirror 1 2 1 82 484 82 481 488 drl 2 (488x82) instructions for installation and use diamond gas 550v-dv-850v-dv-1150v design grid (outlet) with 2 connections for frontal installation.

  • Page 18

    18 instructions for installation and use diamond gas 550v-dv-850v-dv-1150v you have to connect at least two appertures situated at the top of the appliance. The appliance may not be placed directly on the floor, without the feet. This is to allow natural convection. The appertures for the air supply...

  • Page 19

    19 instructions for installation and use diamond gas 550v-dv-850v-dv-1150v picture 1 3 sided frame 2,5 cm 3,5 cm 4 sided frame side frame upper frame picture 2 picture 3 picture 4 picture 5 picture 6 8. Mounting a 3 sided frame fireplace is delivered standard with 4sided frame 3,5cm, an upper and 2 ...

  • Page 20

    20 instructions for installation and use diamond gas 550v-dv-850v-dv-1150v 9. Positioning the logs, diamond, sapphire and white pebbles put the little imitation coal pieces on the burner and here and there between the put the big imitation coal pieces around the burner. Please check that the pilot l...

  • Page 21

    21 1 2 3 4 5 6 7 8 9 10 11 12 13 14 1 2 11 10 12 3 4 5 8 6 7 9 14 13 lu na 8 50 d v ga s instructions for installation and use diamond gas 550v-dv-850v-dv-1150v.

  • Page 22

    Lu na 8 50 d v ga s instructions for installation and use diamond gas 550v-dv-850v-dv-1150v 22.

  • Page 23

    Lu na 8 50 v ga s instructions for installation and use diamond gas 550v-dv-850v-dv-1150v 23 for appl ianc e with 2 burner i n ‘st ai rs’.

  • Page 24

    1 2 3 4 5 6 7 8 1 2 3 4 5 6 7 8 lu na 5 50 v / 5 50 d v ga s instructions for installation and use diamond gas 550v-dv-850v-dv-1150v 24.

  • Page 25

    1 2 3 4 5 6 7 8 lu na 5 50 v / 5 50 d v ga s instructions for installation and use diamond gas 550v-dv-850v-dv-1150v 25.

  • Page 26

    26 instructions for installation and use diamond gas 550v-dv-850v-dv-1150v 10. First-time user the masonry and plaster surrounding a recently installed appliance holds a great deal of moisture, which must first evaporate before commissioning the appliance. If not, the plaster may crack or split. Ask...

  • Page 27

    Identification board 27 instructions for installation and use diamond gas 550v-dv-850v-dv-1150v 12. Guarantee this page is your warranty card. The guarantee is only valid for faults caused by construction defects or defects in the parts used to build the appliance. M-design offers a 12 month guarant...

  • Page 28

    1 2 28 1 3. Manual control (single line burner) from the moment the burner is on, you can start with the flame height control. The screen will automatically show manual control ( flame heigt control ) press on until you see number 15. This is the maximum flame height. Choose a flame height from 1 to...

  • Page 29

    29 1 2 3 4 1 2 3 only for: 1150dh, 1300h-dh-cl-cr-dc, 1600h-dh-cl-cr-dc, 1900h 5. Manual control (double line burner) start the first burner as in the manual control of single line burner to light up the 2nd burner, press first you see the wave settings (page 33). Or press a second time and you will...

  • Page 30

    30 : each model is standard delivered with eco-wave eco-wave is an automatic cycle of fluctuating flames. At each start-up of the fire, the system starts in eco-wave mode ! 6. Eco wave 3 1 2 passion for fire 4 symbol that indicates that wave is enabled press 1x short on the menu button and “1” appea...

  • Page 31

    31 35 70 105 x masonry type x 35mm 30 70mm 65 1105mm 100 type a b c d 850 v 781 674 773 666 550 v 481 914 473 906 1150 v 1081 706 1073 698 a c 4 c d 5 appliance is standard delivered with lower lath 35 mm (4th side frame). The lower lath retracts 5mm into the covering of the fireplace (see x values ...

  • Page 32

    32 x min.(y-4mm) min. 15cm mi n.(y - 4m m) 2mm min. 16mm 5 25 y lower lath 3,5cm/4mm 2mm 2mm masonry bench in natural stone finishing at side appliance type x y 850 v/dv 773 666 550 v/dv 473 906 1150 v 1073 698 x = inside frame measurment (visible dimension) y = measured from side down of the lower ...

  • Page 33

    33 connection flexibles (2 x mandatory) x (int.) y(ext.) l min. 15cm h y x 2 h l type x l y h 850 v/dv 773 783 666 668 550 v/dv 473 483 906 908 1150 v 1073 1083 706 708 instructions for installation and use diamond gas 550v-dv-850v-dv-1150v 14.2. Finishing with 4-sided frame inlet convection air : m...

  • Page 34

    34 b c e a d b c e a d 0 kader/cadre frame/rahme 3.5 cm kader/cadre frame/rahme 7 cm kader/cadre frame/rahme 10.5 cm kader/cadre frame/rahme luna diamond 850 v gas/gaz 32 28 102 98 66 6 66 6 66 6 5 99 1 23 864 48 4 176 455 min. 35 mm max. 450 mm 773 int. Ø130 Ø200 4 x Ø150 131 11 9 20 8 66 6 ex t. 1...

  • Page 35

    35 luna 850 dv gold gas/gaz b d c h a b d c h a 0 kader/cadre frame/rahme 3.5 cm kader/cadre frame/rahme 7 cm kader/cadre frame/rahme 10.5 cm kader/cadre frame/rahme luna diamond 850 dv gas/gaz 67 63 102 98 32 28 5 468 522 662 592 27 5 32 36 3 786 10 16 23 min. 35 mm max. 450 mm 909 229 458 16 2 66 ...

  • Page 36

    36 luna 550 v gold gas/gaz b c e a d b c e a d 0 kader/cadre frame/rahme 3.5 cm kader/cadre frame/rahme 7 cm kader/cadre frame/rahme 10.5 cm kader/cadre frame/rahme luna diamond 550 v gas/gaz 32 28 102 98 473 int. 89 6 in t. 90 6 ex t. 32 12 52 23 15 8 18 8 455 176 48 4 Ø130 Ø200 137 33 0 565 min. 3...

  • Page 37

    37 luna 550 dv gold gas/gaz b d c h a b d c h a 0 kader/cadre frame/rahme 3.5 cm kader/cadre frame/rahme 7 cm kader/cadre frame/rahme 10.5 cm kader/cadre frame/rahme luna diamond 550 dv gas/gaz 90 6 90 6 32 28 5 67 63 102 98 468 522 592 662 229 458 52 2 Ø130 Ø200 119 10 9 24 0 4 x Ø150 609 12 56 23 ...

  • Page 38

    38 luna 1150 v gold gas/gaz b c e a d b c e a d 0 kader/cadre frame/rahme 3.5 cm kader/cadre frame/rahme 7 cm kader/cadre frame/rahme 10.5 cm kader/cadre frame/rahme luna diamond 1150 v gas/gaz 32 28 102 98 70 6 70 6 70 6 5 48 4 Ø130 Ø200 176 455 1073 int. 69 6 in t. 70 6 ex t. 13 7 13 8 27 32 33 0 ...

  • Page 39

    39 instructions for installation and use diamond gas 550v-dv-850v-dv-1150v 16. Identification boards.

  • Page 40

    40 instructions for installation and use diamond gas 550v-dv-850v-dv-1150v.

  • Page 41

    41 instructions for installation and use diamond gas 550v-dv-850v-dv-1150v 17. Ce certification.

  • Page 42

    42 instructions for installation and use diamond gas 550v-dv-850v-dv-1150v.

  • Page 43

    43 instructions for installation and use diamond gas 550v-dv-850v-dv-1150v.