Summary of A75l
Page 1
Operator’s manual a75n, a85n, a95n a75 l , a85 l, a95 l.
Page 2: Operator’S Manual A75
A 1 ---1--- operator’s manual a75 n ---a95 n , a75 l ---a95 l serial numbers of your tractor engine number . . . . . . . . . . . . . . . . . . . . . . . Tractor number . . . . . . . . . . . . . . . . . . . . . . . Type plate eec . . . . . . . . . . . . . . . . . . Powered front axle number . . . . ....
Page 3: Main Table Of Contents
---2--- main table of contents the operator’s manual is divided into 12 main parts , using the letters a, b, c ... L . These are further sub divided into number sections. There are four levels of titles. E.G. On the marking d.1.3 the letter d tells that it is the main part d , instruments and contro...
Page 4: To The Operator
---3--- to the operator valtra a75n, a75 l , a85n, a85 l , a95n, a95 l , (models sold may vary in different marketing areas) this operator’s manual is primarily intended for the driver. The manual con- tains detailed instructions for driving and maintaining the tractor. Make sure that your new tract...
Page 5
---4--- a. Detailed table of contents a. Detailed table of contents serial numbers of your tractor 1 . . . . . . . . . . . . . . . . . . Main table of contents 2 . . . . . . . . . . . . . . . . . . . . . . . . . . To the operator 3 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . A. D...
Page 6
---5--- a. Detailed table of contents i 1.2. Air cleaner 88 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . I 1.3. Maintenance---cooling system 89 . . . . . . . . . . . . . I 2. Electrical system 90 . . . . . . . . . . . . . . . . . . . . . . . . . . . I 2.1. Checking and maintenance of ...
Page 7: B. Safety Precautions
---6--- b. Safety precautions b. Safety precautions b 1. Safety rules this section summarizes the regulations which must always be followed when working with the tractor. However, these regulations do not exempt the driver from following statutory and other national regulation as regards traffic saf...
Page 8
---7--- b. Safety precautions t b3 11 carbon monoxide --- never start the engine, or run it indoors while the doors are closed as this may lead to poisoning by carbon monoxide. 12 downhill --- never drive downhill with the gear lever in neutral or the clutch pedal pressed down. Check the brakes ofte...
Page 9
---8--- b. Safety precautions 24 attaching implements --- care must be taken when implements are being attached. There is a risk of an accident if the tractor or implement should move. It is only safe to enter the implement if the parking brake is applied or the wheels blocked in order to prevent th...
Page 10: Sun Protection Roof
---9--- b. Safety precautions b 1.1. Roll over protective structures a b1 fig. 5 a roll over protective structure (rops) and seat belt (extra equipment) is fitted as standard equipment to the footstep tractor at the time of factory assembly. If the rops was removed by the original purchaser or has b...
Page 11: C. General Description
---10--- c. General description c. General description c 1. Illustrations valtra a75n---a95n, a75 l ---a95 l a c9 the exterior features of the new a---series are remodelled similar to the other model series. The lift up engine cover makes serving easier. The models dealt with here belong to the valt...
Page 12
---11--- c. General description a c3 9 11 5 7 4 3 2 14 1 12 15 8 10 6 13 16 left side of tractor: 1. Preheating of engine induction air, electric 2. Windscreen washer container 3. Battery 4. Prefilter, fuel system, water trap in lower part 5. Fuel filter 6. Cylinder block coolant drain plug 7. Dipst...
Page 13
---12--- c. General description a c4 1 2 3 4 5 6 7 8 right side of tractor: 1. Turbocharger, behind the thermal protection 2. Thermostat housing 3. Alternator 4. Hydraulic pump 5. Suction strainer, hydraulic system 6. Starter motor 7. Fuel filling opening 8. Hand priming pump, fuel system.
Page 14
---13--- c. General description 69---5,3 1 2 3 4 4 5 5 6 6 7 7 8 9 12 13 14 15 16 17 18 18 11 10 rear view of tractor: 1. Quick---release couplings, auxiliary hydraulics 2. Trailer socket 3. Detent for disengaging draft control (not on electro hydraulically controlled hydraulic lift) 4. Lowering lin...
Page 15
---14--- c. General description 1 a c6 3 2 front view of tractor: not in open cab models. 1 din---socket for current, max 8a (current on, when the parking lights are on) 2 front linkage (extra equipment) 3 front power take---off (extra equipment).
Page 16: Service
---15--- c. General description c 2. Service in order to function satisfactorily the tractor must be properly maintained. The necessary daily lubrication and routine checks, can, of course, be carried out by the driver. Where adjustments and repairs are necessary which require the attention of a qua...
Page 17: Gearbox
---16--- c. General description c 4.2. Gearbox a3565---18 the speed gearbox has four synchronized gears which are controlled with a speed gear lever . In front of the gearbox there is fitted a shuttle unit. On models with the shuttle unit the gearbox has three range gears; ll=creeper range, m=medium...
Page 18: Power Take---Off
---17--- c. General description c 4.6. Power take---off a3565---21 the power take---off works fully independently of the gearbox. It has its own clutch disc in the twin clutch which is attached to the flywheel. Engagement and disengagement of the power take---off is via the pto clutch control lever ...
Page 19: Hydraulic System
---18--- c. General description c 7. Hydraulic system 65---8,3 on the hydraulic system there are two oil pumps, whose total capacity together is 52 l/min at an engine speed of 2270 r/min (max 55 l/min). The hydraulic circuit controls: --- steering system (prioritised) --- linkage hydraulics --- auxi...