Summary of T151eLS
Page 1
Operator’s manual t series advance.
Page 2: Operator’S Manual T151
T1ls 2 cab number . . . . . . . . . . . . . . . . . . . . . . . . Tractor serial number . . . . . . . . . . . . . . . . Engine number . . . . . . . . . . . . . . . . . . . . Type plate eec . . . . . . . . . . . . . . . . . . . . . Front axle number . . . . . . . . . . . . . . . . . . . . . Model = m...
Page 3: Main Table Of Contents
---2--- main table of contents the operator’s manual is divided into 12 main parts , using the letters a, b, c ... L . These are further sub divided into number sections. There are four levels of titles. E.G. On the marking d.1.3 the letter d tells that it is the main part d , instruments and contro...
Page 4: To The Operator
---3--- to the operator t series advance = t151 els , t161 ls , t171 ls , t191 ls (models sold may vary in different marketing areas) this operator’s manual is primarily intended for drivers of valtra power shuttle tractors. The manual contains detailed instructions for driving, operating and mainta...
Page 5
---4--- a. Detailed table of contents a. Detailed table of contents serial numbers of your tractors 1 . . . . . . . . . . . . . . . . . Main table of contents 2 . . . . . . . . . . . . . . . . . . . . . . . . . . To the operator 3 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . A. De...
Page 6
---5--- a. Detailed table of contents f 3.1. Lifting links 107 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . F 3.2. Check links 108 . . . . . . . . . . . . . . . . . . . . . . . . . . . . F 3.3. Quick couplings for lower links 108 . . . . . . . . . . . . F 4. Using the hydraulic lift 110...
Page 7
---6--- a. Detailed table of contents k 2.4.2. Fluid brake valve of the trailer 208 . . . . . . . . . . 1. Instructions for operating 208 . . . . . . . . . . . . . . . . 2. Specifications 208 . . . . . . . . . . . . . . . . . . . . . . . . . . K 2.4.3. Emergency brake 209 . . . . . . . . . . . . . ....
Page 8: B. Safety Precautions
---7--- b. Safety precautions b. Safety precautions b 1. Safety rules this section summarizes the regulations which must always be followed when working with the tractor. However, these regulations do not exempt the driver from statutory and other national regulations as regards traffic safety and o...
Page 9
---8--- b. Safety precautions 10 lights --- always make sure that the lights and reflectors are clean and in working order. Do not forget that the headlights must be correctly adjusted. T b3 11 carbon monoxide --- never start the engine, or run it indoors while the doors are closed as this may lead ...
Page 10
---9--- b. Safety precautions 25 damage --- the driver is responsible for seeing to the repair of any damage or wear which might endanger the safety of the tractor. Warning: if damage occurs to the cab, all parts affected should be replaced with new ones. No repair work (welding, drilling, cutting, ...
Page 11
---10--- b. Safety precautions n b4 35 auxiliary hydraulics, on/off---switch --- pressing the stop ---switch turns out all the functions of the auxiliary hydraulics, not the on/off valves and the linkage. 36 engine stop and restart --- if the engine has stalled eg. Due too heavy loading, turn the ig...
Page 12: C. General Description
---11--- c. General description c. General description c 1. Illustration, valtra t151els, t61ls, t171ls, t191ls t1 c1 the models dealt with here belong to the valtra’s medium---weight category of the series. The tractors have a power shuttle unit which operates at the same time as the clutch. The ge...
Page 13
---12--- c. General description 1 2 3 17 4 9 10 t1ls c1 13 12 11 18 14 15 16 7 6 19 8 5 left side of tractor: 1 dipstick for engine oil 2 engine oil filler cap 3 engine oil filter 4 airfilter housing 5 coolant pump 6 draining plug for coolant, cylinder block 7 engine heater 8 engine heater plug (not...
Page 14
---13--- c. General description 2 1 3 5 t1ls c3 4 6 right side of tractor : 1 thermostat housing 2 starter motor 3 alternator 4 turbocharger 5 expansion tank, coolant system 6 air compressor, extra equipment t1ch c7 7 9 8 7 battery 8 toolbox 9 common washer fluid reservoir (windscreen and rear windo...
Page 15
---14--- c. General description 8 1 2 t1ls c5 6 6 7 9 10 11 12 3 4 5 3 4 5 13 14 15 16 17 18 19 20 rear view of tractor: 1 oil dipstick, transmission and hydraulics 2 oil filling cap, transmission and hydraulics 3 auxiliary hydraulics, quick couplings for the on/off valve 4 auxiliary hydraulics, qui...
Page 16: Service
---15--- c. General description 3 2 1 4 t c36 4a 5 front view of tractor: 1 din---socket for current, max 8a (current on, when the parking lights are on) 2 auxiliary hydraulics quick couplings (with front linkage, extra equipment) 3 front power take---off (extra equipment) 4 front linkage (extra equ...
Page 17: Electronic Engine Manage-
---16--- c. General description three power ranges --- the model t191ls has also a larger transport boost power area, when the main gear is h2 or higher and powershift boost area, when quick---shift is 2 or 3. The trans boost and powershift boost power areas are equal. The largest sigma power area w...
Page 18: Power Transmission
---17--- c. General description c 4. Power transmission c 4.1. Hitech power shuttle t1ls c7 in tractors with the power shuttle unit the traditional forward/reverse gear lever is replaced with a shuttle lever beside the steering wheel. By moving the shuttle lever forwards or backwards (the middle pos...
Page 19: Rear Axle
---18--- c. General description system, preprogrammed/preprogramed automatic functions of powershift--- for different driving conditions and power shuttle. The digital display panel in the tractor keeps the driver informed by displaying the status of different operations, e.G. Driving direction, whi...
Page 20: Brakes
---19--- c. General description c 5. Brakes t1ls c8 the oil bath boosted multi---disc brakes are located on the rear axle between the differential and final drives. The brakes operate hydraulically from the brake pedals boosted by the low pressure hydraulic. There is no separate brake fluid in the b...
Page 21: Hydraulic System
---20--- c. General description steering movement is transmitted from the steering wheel by oil under pressure either to the front axle or to the centre pivot. This makes steering particularly easy. If the oil pressure in the steering system should fail for any reason, steering is still possible by ...
Page 22
---21--- c. General description c 7.1. Valves for auxiliary hydraulics t1ls c10 the tractor has as standard at the rear: --- two electrically controlled adjustable valves --- one electrically controlled on/off valve as extra equipment at the rear: --- three electrically controlled, adjustable valves...