User manual motorcycle operating manual model:wy250t-3 preface thanks for your purchasing the motorcycle wy250t-3, and sincerely welcome you to be our motorcycle user. To enjoy a more safe and pleasurable driving, at first please familiarity with the manual must carry on before driving. Your persona...
The important points to attention Ÿ the driver and passenger this motorcycle was limited to one driver and one passenger (except children younger than 12 years old). Never exceed the max load capacity of motorcycle. Ÿ for the safety, avoid driving the motorcycle in atrocious weather or cold weather ...
- 1 - Ⅰ. Motorcycle safe drive rules for safe drive 1. The motorcycle happen the many accident, all reasons are that the car drivers didn’t look at the motorcycle drivers. So the motorcycle drivers must: l put up the coat in bright color l avoid to the driving at night .You must drive on guard and c...
- 3 - Ⅲ. Main technique parameter table 2 item data item data l×w×h mm 2015×680×1210 front tyre t 130/160-13 wheelbase mm 1350 rear tyre 110/180-10 ground clearance mm 101 air pressure of fr tyre 200 kpa dry weight kg 160kg air pressure of rr tyre 250 kpa max load kg 150kg transmission system cvt tu...
- 5 - 四、 the parts&subassemblies and manual the parts&subassemblies(fig2 fig3) meter and indicator fig 2 battery main stand seat box fr brake lever ignition switch vin number nameplate - 6 - dashed（……）indicate the not see parts directly。 meter and indicator （fig4） fig3 fuel tank side stand air filte...
- 7 - ⑴ speedo meter ⑵ odometer ⑶main beam indicator ⑷left turning signal light ⑸right turning signal light ⑹water temperature meter ⑺ fuel meter (8)time meter (9)parking light ignition switch （fig5） (1) on ( )-when the switch turn to this position, start engine and do not pull out the key. 1 ⑵ (2) ...
- 9 - • ： when it on the position, the front head light, tail light, position lighted instrument turn off. Starting switch（2） （fig8） press this button to start engine （p16） main beam switch（1） （fig9） press“ ”button，is high beam；press“ ”button is low beam。 turning signal light switch (2)（fig9） when t...
- 11 - Ⅴ. Operation instruction checking before driving: checking before riding, for safety and prevent trouble or accident, pre-check up is necessary. Gasoline when the pointer or fuel meter is close to red section, replenish fuel. Gasoline tank container: 7l clock –wise to open the tank cover 2. (...
- 13 - tire check the tire pressure regularly and adjust. Check before the tire cooled check if there any metal trash or gravel in the groove of tires warning: if the tire pressure dose not accord with the standard, it will properly cause the traffic accident. • it is dangerous that use the worn tir...
- 15 - driving motorcycle: warning: wear the trousers to avoid touching with exhaust pipe and was burnt. The entire device must be installed according to requirement of the traffic rule. Take the license to riding. Notice: control the speed and load during 1000kmof running in period. Load should be ...
- 17 - engine power off operation (fig 20, fig 21) close oil: revolve to the lowest place according to picture. (normal situation is loose the throttle grip, and the engine is idling speed) • put the key to “off stopping operation: when the motorcycle stop, put the key to “ ” position .Put down stan...
- 19 - table 4 speedometer（x1000km） 1 4 8 12 cycle item every month 6 12 18 ref page ﹡ fuel pipe i i i i ﹡ throttle grip i i i i 18 ﹡ core of the air filter note1 c/1000km, if need: r 25 ﹡ spark plug c/2000km,if need: r 29 ﹡ valve i i i i ﹡ engine oil （300km）r r (300km) r 27 ﹡ engine oil filter when...
- 21 - table 5 trouble phenomenon trouble reason solution the octane value of the fuel is too low change fuel oil path stop up clean oil path ignition time is too early or too late check wire and change cdi spark too weak or flameout check ignition and clear out mixed air too dense or race clean adj...
- 23 - adjusting idling speed(fig 24, fig 25) the carburetor is in the best situation before sold, if the carburetor is still influence riding please adjust it under the instruction of professional man. Warm up few minutes before start。 idle to adjust screw (1) is it is it improve idle speed slightl...
- 25 - replacing gearbox oil (fig 28) suggestion engine oil : sae 80w/90 oil container resolving capacity ：0.18l changing capacity ：0.16l take apart the immiting bolt (2), and the spilling bolt (1). Notice: the engine must be warmer when spilling, and the vehcile must be steady by main stand! • rein...
- 27 - radiator maintenance suggestion cooled liquid type: anti-freeze liquid it’s only using no rust no freeze liquid for this engine。 inspecting open the bolt, take the cover off, you can see the liquid lever is staying1/5，if less than1/5，please immit it. Immiting the cooled liquid Ÿ open the gas ...
- 29 - Ⅷ.Circuit diagram - 30 - Ⅸ. Vehicle storage storage for the motorcycle not to be used for a long period of time, for example, in wintertime, some steps should be taken to prevent malfunction of and damage to its components, which might be caused by long storage. Besides, before the long stora...
- 31 - reuse motorcycle. Clean the motorcycle, if the storage time beyond 4 months, must change gasoline. Must charging if need, and then install battery. Must check all of terms before drive (page 10), for the safety must try the motorcycle with lower speed for some time in a not busy rode. - 32 - ...
- 33 - owner’s manual; (ii). Give notice to dealer approved by wangye usa co., llc or other qualified service facility of any and all apparent defects immediately upon discovery, and make the entire motorcycle available at the time for inspection and repair at the dealer’s place of business; (iii). ...
