WaterBoss 900CF Owner's Manual And Installation Manual

Manual is about: Water Filter

Summary of 900CF

  • Page 1

    M m o o d d e e l l s s 9 9 0 0 0 0 i i f f , , 9 9 0 0 0 0 c c f f , , a a n n d d 9 9 0 0 0 0 n n f f o o w w n n e e r r ’ ’ s s m m a a n n u u a a l l a a n n d d i i n n s s t t a a l l l l a a t t i i o o n n g g u u i i d d e e v v e e r r s s i i o o n n 7 7 . . 2 2.

  • Page 2: 10 Year Limited Warranty

    Waterboss filter owner’s manual 6/13/2012 2 10 year limited warranty to whom warranty is extended this warranty is issued to the original owner at the original location site and is not transferable to other sites or to subsequent owners of the system. To place the equipment under warranty, the warra...

  • Page 3: Contents

    Waterboss filter owner’s manual 6/13/2012 3 contents general information .......................................................................................................................................4 getting maximum efficiency from the appliance................................................

  • Page 4: General Information

    Waterboss filter owner’s manual 6/13/2012 4 general information congratulations on choosing a superior waterboss ® water treatment appliance! Soon you and your family will be enjoying clean, clear water. Use this guide to attain the maximum benefit from your appliance. Keep it handy for a reference ...

  • Page 5

    Waterboss filter owner’s manual 6/13/2012 5 getting maximum efficiency from the appliance to achieve the maximum benefit and performance from this appliance, familiarize yourself with this manual and the appliance. 1. Should your electricity be off for any reason, check your controller for the corre...

  • Page 6

    Waterboss filter owner’s manual 6/13/2012 6 checklist before installation refer to this checklist before installation. Water quality—if the water supply contains sand, sulfur, bacteria, iron bacteria, tannins, algae, oil, acid, or other unusual substances, consider pre-treating the water to remove t...

  • Page 7: Precautions

    Waterboss filter owner’s manual 6/13/2012 7 precautions do 1. Comply with all state and local, building, plumbing, and electrical codes. 2. Test your water quality with the strips, if provided. Optionally, obtain a report on your water’s quality. 3. Install the appliance before the water heater. 4. ...

  • Page 8

    Waterboss filter owner’s manual 6/13/2012 8 installation steps and start-up procedures the water filter is capable of treating a combination of undesirable constituents (such as iron, dirt, sediment, and chlorine) in water. See specifications for the capabilities of your appliance. Install, set up, ...

  • Page 9

    Waterboss filter owner’s manual 6/13/2012 9 installation steps and start-up procedures, cont. G. For most installations, install the appliance after the pressure tank or water meter and before the water heater unless otherwise recommended. When installing the 900cf carbon filter for well water, plac...

  • Page 10

    Waterboss filter owner’s manual 6/13/2012 10 installation steps and start-up procedures, cont. Step 4b: (optional) hard plumbing with copper fittings when preparing the male threaded fittings of the i/o adapter, use the following guidelines to avoid damage to the plastic pipe threads. A. Wrap the th...

  • Page 11: Installation Steps, Cont.

    Waterboss filter owner’s manual 6/13/2012 11 installation steps, cont. Plastic (pvc/cpvc) pipe joining procedure to ensure reliable joint integrity when using solvent cement for pvc/cpvc plumbing, follow these recommendations: a. Cutting—the pipe must be cut square to allow for the proper interfacin...

  • Page 12

    Waterboss filter owner’s manual 6/13/2012 12 installation steps and start-up procedures, cont. Step 5 connect gravity overflow connection the overflow line drains away excess water should the tank fill with too much water or the appliance malfunction. A. Attach the overflow connection and check that...

  • Page 13

    Waterboss filter owner’s manual 6/13/2012 13 installation steps and start-up procedures, cont. Step 7 flush lines a. Place the appliance in the bypass position. (see figure 7.) the bypass valve can isolate the appliance should the system malfunction or leak. The bypass valve enables you to use untre...

  • Page 14

    Waterboss filter owner’s manual 6/13/2012 14 installation steps and start-up procedures, cont. Step 9 complete the installation a. Connect the transformer power cord to the back of the controller. B. Ensure that the appliance is in the service position. See figure 8. C. Ensure the water supply is on...

  • Page 15

    Waterboss filter owner’s manual 6/13/2012 15 start-up procedures—900cf carbon filter important the waterboss ® 900cf carbon filter is capable of treating a combination of undesirable constituents (chlorine, taste, and odor) in water. Install, set up, and use the filter within the operating limits ou...

  • Page 16

    Waterboss filter owner’s manual 6/13/2012 16 start-up procedures—900nf acid neutralizing filter important the waterboss ® 900nf acid neutralizing filter is capable of elevating a low ph condition (acid) in your water. Install, set up, and use the filter within the operating limits outlined in this m...

  • Page 17

    Waterboss filter owner’s manual 6/13/2012 17 start-up procedures—900if iron filter important the waterboss ® 900if iron filter is capable of treating a combination of undesirable constituents (iron, manganese,and/or hydrogen sulfide) in water. Install, set up, and use the filter within the operating...

  • Page 18

    Waterboss filter owner’s manual 6/13/2012 18 start-up procedures—900if iron filter, cont. Step 4 start the regeneration cycle a. Press and hold the regenerate button until the controller indicates 01 (flashing). The regeneration cycle begins. During regeneration, water bypasses the appliance to allo...

  • Page 19: Setting The Controller

    Waterboss filter owner’s manual 6/13/2012 19 setting the controller this appliance features a four-button controller with an lcd display. The controller can be used to view the appliance’s status, perform regenerations, and change settings. The controller must be set up correctly for the appliance t...

  • Page 20: Tools and Materials Needed

    Waterboss filter owner’s manual 6/13/2012 20 900nf acid neutralizing filter replenishment procedure the neutralizing media that adjusts the ph level of the water must be refilled periodically (annually). Typically, this media is calcite and is available from waterboss ® . To refill the neutralizing ...

  • Page 21

    Waterboss filter owner’s manual 6/13/2012 21 900nf acid neutralizing filter replenishment procedure, cont. Step 4 add replenishment media a. Weigh the replenishment media on the analog scale. B. Place the funnel into the tank. C. Pour the media into the funnel to fill the tank with the measured amou...

  • Page 22: Assembly and Parts

    Waterboss filter owner’s manual 6/13/2012 22 assembly and parts cabinet/cover/salt lid assemblies figure 11: cabinet and cover assemblies figure 12: controller tab lock detail part # description quantity 1 54306 salt port lid 1 2 54324 valve cover assembly 1 3 54540-if computer control assembly—mode...

  • Page 23: Assembly and Parts, Cont.

    Waterboss filter owner’s manual 6/13/2012 23 assembly and parts, cont. Cabinet and assemblies figure 13: cabinet and assemblies part # description quantity 1 c0700a overflow elbow 1 2 54523 bypass assembly 1 3 93838 o-ring 2 4 93281 fill plug 1 5 93272 o-ring 1 6 90819 o-ring 2 7 90828 o-ring 1 8 54...

  • Page 24: Assembly and Parts, Cont.

    Waterboss filter owner’s manual 6/13/2012 24 assembly and parts, cont. Injector assembly figure 14: injector assembly part # description quantity 1 93223 injector throat—model 900cf 1 93223-red injector throat—models 900if and 900nf 2 53224 injector nozzle with over-mold gasket—model 900cf 1 53224-r...

  • Page 25: Assembly and Parts, Cont.

    Waterboss filter owner’s manual 6/13/2012 25 assembly and parts, cont. Bypass assembly (available as assembly only.) figure 15: bypass assembly part # description quantity 1 54523 bypass assembly 1 2 93838 o-ring 2.

  • Page 26: Assembly and Parts, Cont.

    Waterboss filter owner’s manual 6/13/2012 26 assembly and parts, cont. Drive end cap assembly figure 16: drive end cap assembly* part # description quantity 1 90802 screw, self-tapping 2 2 90217 drive motor 1 3 93891 1/4-inch hex nut 2 4 93238 drive gear 1 5 90809 screw, self-tapping 2 6 93219 pisto...

  • Page 27: Assembly and Parts, Cont.

    Waterboss filter owner’s manual 6/13/2012 27 assembly and parts, cont. Drive end cap assembly cont. 90217 drive motor the motor is held in place by two, 1/2-inch self-tapping screws. The screws should be “snug.” the brass pinion gear on the motor should engage the plastic drive gear (93238). The wir...

  • Page 28: Assembly and Parts, Cont.

    Waterboss filter owner’s manual 6/13/2012 28 assembly and parts, cont. Top fill plug assembly figure 17: fill plug assembly part # description quantity 1 93281 fill plug 1 2 93272 fill plug o-ring 1 93281 fill plug the fill plug (93281) seals the media access ports in the media tank. Care should be ...

  • Page 29: Assembly and Parts, Cont.

    Waterboss filter owner’s manual 6/13/2012 29 assembly and parts, cont. Brine valve housing assembly (900if iron filter only) figure 18: brine valve housing assembly part # description quantity 1 53511 brine piston assembly (includes o-ring & spring) 1 2 90821 o-ring 1 3 53510 housing 1 4 90843 0.5 g...

  • Page 30: Assembly and Parts, Cont.

    Waterboss filter owner’s manual 6/13/2012 30 assembly and parts, cont. Safety shutoff assembly (iron filter only) figure 19: safety shutoff assembly part # description quantity 1 54226 safety shutoff valve 1 2 * 3/8" retainer sleeve 1 3 * 3/8" plastic gripper 1 4 * 3/8" nut 1 5 * wrist pin 1 6 10700...

  • Page 31: Assembly and Parts, Cont.

    Waterboss filter owner’s manual 6/13/2012 31 assembly and parts, cont. Safety shutoff valve elbow installation figure 20: safety shutoff valve elbow installation part # description quantity 1 h4656 1/2-inch (13-mm) x 3/8-inch (10-mm) sleeve gripper set 1 2 54138 3/8-inch (10-mm) compression assembly...

  • Page 32: Troubleshooting

    Waterboss filter owner’s manual 6/13/2012 32 troubleshooting problem possible cause solution electric cord is unplugged plug in the transformer no electric power at outlet check power source. Make sure outlet is not controlled by a switch defective transformer test with volt meter for 12 vac at cont...

  • Page 33: Troubleshooting, Cont.

    Waterboss filter owner’s manual 6/13/2012 33 troubleshooting, cont. Problem possible cause solution plugged injector replace injector screen, nozzle, and throat low water pressure maintain minimum pressure of 20 psi drain line or flow control is restricted remove restriction regenerant line restrict...

  • Page 34: Filter Specifications

    Waterboss filter owner’s manual 6/13/2012 34 filter specifications 900if 900cf 900nf capacity (gallons) 700/regen 75,000 20,000 max compensated hardness (ppm) [iron, manganese, and hydrogen sulfide] 15 na na minimum ph (standard units) 7 na 6.3 media type and amounts greensand—0.7 cu.Ft. Carbon—0.7 ...

  • Page 35: Notes

    Notes.

  • Page 36: Waterboss

    Litho usa ©2012 f93966fil2 rv0612b waterboss ® has these third-party listings: in business since 1956 www.Waterboss.Com 4343 south hamilton road, groveport, oh 43125.