For outdoor use only tools required: adjustable wrench fish fry set assembly, use and care model 03101400 to installer or person assembling this appliance: leave this manual with this appliance for future reference. This instruction manual contains important information necessary for the proper asse...
2 • zebco fish fry set danger if you smell gas: 1. Shut off gas to the appliance. 2. Extinguish any open flame. 3. If odor continues, keep away from the appliance and immediately call your fire department. Failure to follow these instructions could result in fire or explosion which could cause prope...
Safety symbols the symbols and boxes shown below explain what each heading means. Read and follow all of the messages found throughout the manual. Danger caution caution: indicates a potentially hazardous situation which, if not avoided, may result in minor or moderate injury. Warning warning: be al...
Warning 1. Never leave the appliance unattended. Keep children and pets away from the appliance at all times. 2. The use of alcohol, prescription or non-prescription drugs may impair the consumer’s ability to properly assemble or safely operate the appliance. 3. This appliance is for outdoor use onl...
• use appliance at least 10 ft. From any wall or surface. Maintain 10 ft. Clearance to objects that can catch fire or sources of ignition such as pilot lights on water heaters, live electrical appliances, etc. Never use under balconies made of wood or any overhead construction. • apartment dwellers:...
6 • zebco fish fry set • never use a cooking vessel larger than 30 qts. And taller than 15½ inches. • never fill pot above upper fill line. Oil can splatter causing staining or discoloration to ground surface. • never leave the appliance unattended. Keep children and pets away from the appliance at ...
Danger • the safety relief valve on the lp tank could activate releasing gas and cause an intense fire with risk of death or serious injury. • never store a spare lp tank under or near appliance or in enclosed areas. • never fill the cylinder beyond 80% full. An overfilled spare lp tank is hazardous...
Lp tank valve must have: lp (liquefied petroleum gas) lp tank filling lp tank exchange • type 1 outlet compatible with regulator or appliance. • safety relief valve. • ul listed overfill protection device (opd). This opd safety feature is identified by a unique triangular hand wheel. Use only tanks ...
Lp tank leak test for your safety use mild soap and water. Do not use household cleaning agents. • leak test must be repeated each time lp tank is exchanged or refilled. • do not smoke during leak test. • do not use an open flame to check for gas leaks. • appliance must be leak checked outdoors in w...
5. Hold regulator, insert nipple (b) into lp tank valve. Hand tighten coupling nut, holding regulator in a straight line (c) with lp tank valve so as not to cross thread the connection. 6. Turn the coupling nut clockwise to tighten to a full solid stop. The regulator will seal on the back-check feat...
Leak testing valves, hoses and regulator 1. Turn all control knob(s) to off. 2. Be sure regulator is tightly connected to lp tank. 3. Completely open lp tank valve by turning hand wheel counterclockwise. If you hear a rushing sound, turn gas off immediately. There is a major leak at the connection. ...
Lighting instructions do not lean over lp cooker while lighting. 1. Turn regulator control valve to off position. 2. Fully open lp tank valve. 3. Light match and place it over burner. Slowly turn on the regulator control valve. Do not stand with head or arms over cooker. 4. If ignition does not occu...
Warning spiders’ nests or wasps’ mud inside the burner may cause fire at the air damper. If a fire occurs, turn off gas supply at lp tank valve. (see representative illustration in fig. 1) immediately cleaning the burner note: spiders and small insects can spin webs and build nests inside the burner...
Cleaning and maintenance caution all cleaning and maintenance should only be done when the appliance is cool and with the fuel supply turned off at the lp tank. Do not clean any part in a self-cleaning oven. The extreme heat will damage the finish. Correct care and maintenance will keep your applian...
Zebco • 15 fish fry set burner alignment pin threaded pin heat shield nut assembly instructions 1. Insert the burner into the cooker stand and through the cut-out opening in the side of the stand. 2. Insert the threaded pin on the bottom of the burner into the center hole in the burner bracket. Make...
5. Thread wire hook through hole on side of regulator. 6. When transporting or storing lp cooker without tank attached, hook regulator onto burner or cooker stand to prevent damage to regulator. 16 • zebco fish fry set using your thermometer check the thermometer before each use 212°f +/– 20°f by in...
Zebco • 17 fish fry set if a larger cooking utensil or turkey frying kit is purchased for use, follow these instructions prior to using the appliance: 1. 2. 3. 4. 5. 6. In any case, do not fill past the maximum fill line on the utensil. Place the food product on the holder. Place the food product an...
18 • zebco fish fry set limited warranty manufacturer warrants this fish fry set for replacement or repair of parts and/or workmanship for a period of 3 months. Paint is not warranted and may require touch-up. Items considered to be consumable such as batteries are not covered under these warranties...
Zebco • 19 fish fry set.
Manufactured and sold by char-broil® under license from zebco®, inc. © w.C. Bradley company columbus, ga 31902 all rights reserved should you encounter any problem do not return this product to the store. 24 hours a day, 7 days a week call us first. We can help. 1-800-232-3398.
