A.O. Smith Fit it & Forget it HSE-SBS-006 User Manual
User Guide
User Guide
EXPERT COMPANY SERVICE
www.aosmithindia.com
Toll Free No.:
1800-103-2468
or
SMS us:
+91 99410 32468
or
E-mail us:
aosmithcs@aosmithindia.com
Monday to Friday: 9 am to 8 pm.
Saturday & Sunday: 9 am to 6 pm.
# For calls registered at A. O. Smith call centre before 4 pm only. Not available on public
holidays and under unavoidable circumstances. Available in select cities only.
T
S
E
A. O
. SMITH
A. O
. SMITH
S E RVICE
S E RVICE
POWER
OF
POWER
OF
HOUR
RESPONSE
#
DAY
RESOLUTION
TIME
FIX
HOUR
RESPONSE
#
DAY
RESOLUTION
TIME
FIX
Water Heater
HSE-SBS 6, 10, 15 and 25 Litres
Higher energy rating.
Handy remote control.
Higher energy rating
Summary of Fit it & Forget it HSE-SBS-006
Page 1
User guide user guide expert company service www.Aosmithindia.Com toll free no.: 1800-103-2468 or sms us: +91 99410 32468 or e-mail us: aosmithcs@aosmithindia.Com monday to friday: 9 am to 8 pm. Saturday & sunday: 9 am to 6 pm. # for calls registered at a. O. Smith call centre before 4 pm only. Not ...
Page 3: About A. O. Smith
Congratulations! And welcome to the a. O. Smith family. We would like to thank you for the trust you have shown in choosing an a. O. Smith water heater. You can be sure it will live up to your expectations. Thousands of delighted users all over the world trust a. O. Smith water heaters for their fam...
Page 4: Contents
Read before operation.............................................................. 1 general ...................................................................................... 2 specifications ............................................................................ 3 key features .............
Page 5: Read Before Operation
1 read before operation on receipt it is our policy to promote safe delivery of all orders. This product shipment has been thoroughly checked, packed and quality certified before leaving our factory. Visible loss or damage if any of the goods called for on the bill of lading or express receipt are d...
Page 6: General
2 general indicates a potentially hazardous situation, which if not avoided, could result in death or serious injury. Indicates a potentially hazardous situation which, if not avoided, may result in minor or moderate injury or property damage. This is the safety alert symbol. This symbol alerts you ...
Page 7: Specifications
3 specifications note: image may vary from the actual product. *dimension g is applicable only for hse-sbs-006 and hse-sbs-010 models. Figure 1 model hse-sbs hse-sbs hse-sbs hse-sbs -006 -010 -015 -025 volume [l] 6 10 15 25 power [w] 3000 2000 voltage/frequency [v/hz] 230~/50 actual stdg. Loss [kwh/...
Page 8: Caution
4 *safety valve has been factory fit with the water heater and set at 0.8 mpa (8 bar) rated pressure. Caution do not tamper or detach the safety valve from the water heater. Warning part description model no. 1 cold water inlet pipe with diffuser all models 2 hot water outlet pipe all models 3 safet...
Page 9: Key Features
5 key features blue diamond ® glass lining blue diamond ® technology increases the life of the inner tank. The lining is stronger and more corrosion resistant than any other in the industry. Temperature control knob the temperature control knob allows you to set the temperature precisely between 25º...
Page 10: Safety Precautions
Do not install the water heater where there is direct sunlight or rain. It is has to be installed indoor only. During installation 6 do not install the water heater where water splashes on the water heater. Figure 3 figure 4 safety precautions installation before installing, ensure that the followin...
Page 11
7 figure 6 mounting the water heater before locating the position for installation of the water heater, make sure that there is sufficient clearance between the ceiling and the side wall. select a place to mount water heater vertically with water connection at the bottom. :dwhukhdwhupxvwehorfd...
Page 12: Connecting to Water Supply
8 3odfhwkhzdwhukhdwhurqwkh+dqjlqj screws using the wall mount slots (fig. 10). Tug downwards on the water heater to ensure that the water heater is fixed steadily. Figure 10 connecting to water supply *flexible hoses to be procured by the customer, not part of standard product. **safety valve come...
Page 13: Caution
9 0dnhvxuhdvxlwdeoh7hiorqwdshlvxvhgirudoosoxpelqjfrqqhfwlrqvwrsuhyhqwohdndjh 'lvfkdujhwxehvkrxogehlqvwdoohggrzqzdugvzlwkrxwdq\orrsvirogvrunqrwv(qvxuh that the free end of the discharge tube is placed over a suitable drain and away from the users. 'lvfkdujhwxehlvsurylghgwruhohdvhwkhglvfkdujhiur...
Page 14: Caution
10 caution do not install the wired remote control where water splashes on the wired remote control. it is recommended that the wired remote control should be installed on the remote bracket. do not use wet hands while operating the remote. make sure to install the wired remote control close...
Page 15: Operation
11 filling the tank operation 1. Open a hot water faucet to permit air to escape. 2. Open the cold water inlet valve fully, filling the water heater and the piping. 3. Close hot water faucet when water flows. 4. Check all the connections to see if there is any leakage. In case of a leakage, drain th...
Page 16
12 figure 16 temperaute conrol knob (for hse-sbs-006 and hse-sbs-010 models) switch on the water heater’s power supply. The power indicator lamp glows. When the temperature of the water drops by 5°c from the set temperature due to usage of water, the water heater again enters into the heating mode. ...
Page 17: Notice
13 figure 19 wired remote control (for hse-sbs-015 and hse-sbs-025 models) the wired remote control for the water heater allow the customer to control the functions of the water heater and to diagnose certain fault conditions. 2kw c kwh heating set on/off energy meter backlight led indicators indica...
Page 18: Notice
14 there are two types of modes depending on the actual water temperature inside the inner tank of the water heater: modes when the temperature of the water drops by 5°c from the set temperature due to usage of water, the water heater again enters into the heating mode. Figure 23 heating mode standb...
Page 19: Caution
15 draining the tank figure 27 discharge tube discharge lever safety valve port whenever the water heater is not used for an extended period, unplug the unit and drain. If it is below freezing temperature, you will need to unplug the unit and drain it. switch off the electric supply to the water h...
Page 20: Warning
16 changing the decorative front panel please follow the instructions as shown in (fig. 28). For hse-sbs-006 and hse-sbs-010 models figure 28 1. Pull out the knob. 2. Unscrew the screw on the decorative front panel. 3. Remove the decorative front panel to change. Please follow the instructions as sh...
Page 21: Troubleshooting
17 troubleshooting the water heater may not operate as desired if used incorrectly or there is a minor cause, even though the product has no fault. In these cases, check the following issues to solve simple problems without the help from the customer care centre. If the problem does not solve after ...
Page 22: Circuit Diagram
18 error messages and actions error code reason self-diagnostic / action e0 electrical leakage in the unit. Call customer care centre. E1 temperature sensor circuit call customer care centre. Short or open. E3 exceeds maximum operating call customer care centre. Temperature. E4 malfunction of leakag...
Page 23: Warranty
19 your a. O. Smith water heater is warranted against defects arising from faulty design, workmanship and materials for a period of 24 months from the date of the invoice, subject to the following conditions: 1. The customer will notify the company promptly about defects noticed and give the company...
Page 24: Jurisdiction
20 general terms of warranty 1. The “goods” shall mean the goods described in the purchase agreement. 2. “the customer” shall mean the original purchaser under the purchase agreement. 3. “the company” shall mean a. O. Smith india water products private limited. 4. The “purchase agreement” shall mean...
Page 25
21 customer copy to be retained by the customer dealer’s stamp and signature invoice number: ___________________________ dated: _________________________ unit serial number: __________________________________ model: _________________________ capacity: ______________________ customer's name and addre...
Page 26: Registered Office
19 22 registered office a. O. Smith india water products private limited (formerly known as a. O. Smith india water heating private limited) plot 300, phase - ii, kiadb industrial area, harohalli, kanakapura taluk, ramanagara district, karnataka – 562 112, india. toll free no.: 1800-103-2468 web...
Page 28
Manufactured by a. O. Smith india water products private limited (formerly known as a. O. Smith india water heating private limited) plot 300, phase - ii, kiadb industrial area, harohalli, kanakapura taluk, ramanagara district, karnataka – 562 112, india. Toll free: 1800-103-2468 n website: www.Aosm...