- DL manuals
- A.O. Smith
- Water Heater
- GAS WATER HEATER
- User Manual
A.O. Smith GAS WATER HEATER User Manual
Summary of GAS WATER HEATER
Page 1
Water heater hse-hns 50, 60, 80 litres user guide * conditions apply the safest gas water heater hig-vns-006 dual solenoid valve carbon monoxide detector (optional) three burners ignition pin corrosion resistant (oxygen free copper exchanger) warranty*.
Page 2: About A. O. Smith
About a. O. Smith a. O. Smith india water heating private limited was established in 2006. Since this time, the a. O. Smith team has conducted numerous focus group studies and spent an endless number of research hours determining what india wanted in a water heater. Backed by 75 years of proven tech...
Page 3: What'S In The Box?
What's in the box? Gas water heater box 1: main box box 2: accessory box mounting screws & accessories swivel connector user guide corrugated tube straight pipe outlet vent pipe elbow vent pipe contents user instructions ..................................................................................
Page 4: User Instructions
User instructions please read the instructions carefully before the installation or operation of the water heater. This user guide is meant for your future reference and is applicable for the instant gas water heater model hig-vns-006 . • only a. O. Smith recommended professional installers will ins...
Page 5: Safety Information
Warning: • carefully plan where you install the heater. If the gas water heater is not installed properly, fatal accidents can result from lack of air, carbon monoxide poisoning or fire. • place the water heater in a location where water leaks will do no damage to adjacent areas. Safety information ...
Page 6
Caution: *relief valve has been factory fit with the water heater and set at 0.8 mpa (8 bar) rated pressure. Warning: do not tamper or detach the safety valve from the water heater. 3 read and follow water heater warnings and instructions. Vapors from flammable liquids will explode and catch fire ca...
Page 7: Specifications
Caution: *relief valve has been factory fit with the water heater and set at 0.8 mpa (8 bar) rated pressure. Warning: do not tamper or detach the safety valve from the water heater. Model hig-vns-006 † gas type piped natural gas voltage/ frequency (wattage) (v/hz[w]) 220~/50[45] temperature rise and...
Page 8
Dimensions model hig-vns-006 a [mm] 508 b [mm] 339 c [mm] 145 5 part descriptors 1. Water inlet 2. Hot water outlet 3. Gas inlet 4. Child lock 5. Connector (co detector) 6. Gas-flow control knob 7. Winter/summer setting knob 8. Straight pipe 9. Elbow vent pipe 10. Outlet vent pipe 11. Top mounting b...
Page 9: Key Features
Key features this gas water heater has three burners which results in optimum combustion of gas. This gas water heater is amongst one of the lowest gas consumption models available in the industry and is the most economical to operate. It also largely reduces carbon monoxide emissions. This gas wate...
Page 10: Safety Features
7 safety features the ignition device in largely available gas water heaters in the industry is battery powered with a single ignition pin. When the battery power diminishes, ignition may not happen and may lead to explosive build-up of natural gases in large quantities which may lead to dangerous c...
Page 11: Other Safety Features
8 other safety features this gas water heater has an in-built power stabilisation circuit to stabilise input voltage fluctuations. This gas water heater comes with an advanced water sensor which ensures that sufficient water is flowing through the heat exchanger during operation. This will avoid dry...
Page 12: Installation Instructions
9 installation instructions introduction please follow these instructions. Failure to follow instructions may result in: • damage or injury. • improper operation. Please contact a. O. Smith customer care for any queries. Proper location for installing your water heater carefully select the location ...
Page 13: Mounting Instructions
10 mounting instructions do’s • ensure that the flue terminal is clear of any combustible material. • install only on a main wall, as close as possible to the most frequently used hot tap. • install the vent under an overhang not less than 900 mm from its top. Warning: before starting installation: ...
Page 14: Venting Instructions
Warning: • improper venting of this appliance can result in excessive levels of carbon monoxide which can result in severe personal injury or loss of life. • improper installation can cause nausea or asphyxiation, severe injury or death from carbon monoxide and flue gases poisoning. Improper install...
Page 15: Operating Instructions
Operating instructions 12 warning: • if you do not follow these instructions exactly, a fire or explosion may result causing property damage, personal injury or loss of life. • the water heater must be installed by a professional installers recommended by a. O. Smith. • forbidden to install in enclo...
Page 16: Maintenance and Cleaning
Warning • keep the area around the water heater clear and free from combustible materials, petrol, diesel, kerosene, and other flammable vapors and liquids. • do not use this water heater if any part has been under water. • always check the water temperature before entering a shower or bath. Safety ...
Page 17: Error Codes
14 error codes fault code ignition failure heating led light flashes 1 time flame failure heating led light flashes 2 times co is out of limits* heating led light flashes 4 times fan fault heating led light flashes 5 times flame sensor fault heating led light flashes 8 times high temp. Limit fault h...
Page 18: Circuit Diagram
Circuit diagram 15 m flame sensor ignitor wire display board water flow sensor child lock switch pressure sense switch (black wire) gas valve (brown/pink wire) high temperature limit (white wire) grounding wire (yellow-green wire) terminal of power supply (red, black, green/yellow wire) fan (red wir...
Page 19: Warranty
Warranty product warranty 16 your a. O. Smith water heater is warranted against defects arising from faulty design, workmanship and materials for a period of 24 months from the date of the invoice, subject to the following conditions: 1. The customer will notify the company promptly about defects no...
Page 20: Jurisdiction
General terms of warranty 1. The “goods” shall mean the goods described in the purchase agreement. 2. “the customer” shall mean the original purchaser under the purchase agreement. 3. “the company” shall mean a. O. Smith india water heating pvt. Ltd. 4. The “purchase agreement” shall mean the genera...
Page 21: Warranty Card
Warranty card (company copy) (to be sent back to the company) unit serial number: dealer’s stamp and signature invoice number: dated: customer's name and address: model: capacity: warranty card warranty card (customer copy) (to be retained by the customer) unit serial number: dealer’s stamp and sign...
Page 22: Service and Maintenance
Service and maintenance toll free customer care centre helpline at 1.800.103.2468 e-mail id: aosmithcs@hotwater.Com registered office a. O. Smith india water heating private limited plot no. 300, phase-2, kiadb industrial area, harohalli, kanakapura taluk, ramanagara district - 562 112, karnataka, i...
Page 24
Manufactured by a. O. Smith india water heating private limited plot no. 300, phase-2, kiadb industrial area, harohalli, kanakapura taluk, ramanagara district - 562 112, karnataka, india. Toll free: 1.800.103.2468 website: www.Aosmithindia.Com.