- DL manuals
- Aarrow
- Stove
- Beacon
- Operating & Installation Manual
Aarrow Beacon Operating & Installation Manual
Summary of Beacon
Page 1
Beacon multifuel stoves operating & installation manual please retain these instructions for future reference rev 1 october 2005 afs 1269 aarrow beacon 75 shown.
Page 2
Congratulations on your choice of an aarrow stove. More than 20 years experience has been put into the development of our beacon stove to ensure ultimate performance and years of trouble free enjoyment. Every detail on the fire has been carefully engineered and designed which is why we are so confid...
Page 3
Introduction page safety notices 5 the principle of the fire 5 check list 6 technical data 7 operating instructions firebox linings and throat plate 8 multifuel grate 8 air inlet controls 8 airwash system 8 interlock 9 multi-purpose operating tool 9 door trim 9 fire door glass 9-10 door adjustment 1...
Page 4: Warning
Warning to all multifuel users petroleum coke some of whose brand names are "calco", "petrocoke" or "wonderco" must not be burned in this appliance to use these fuels will invalidate the appliance guarantee if in doubt contact the solid fuel association telephone number 0800 600 000 www.Solidfuel.Co...
Page 5
Beacon multifuel stoves 5 introduction safety a fireguard conforming to bs 8423: 2002 should be used in the presence of children and old/or infirm people. If the appliance is used with the fire door open, a spark guard conforming to bs 3248 should be fitted. Do not use aerosol sprays or any other fl...
Page 6
Inside the appliance you should find the following: 6 beacon multifuel stoves check list part description &visual aid (not to scale) beacon 75 beacon 77 2. Throat plate 1 1 3. Flue spigot 1(5”) 1(5”) 4. Hot plate 1(5”) 1(5”) 5. Ash pan 1 1 6.Operating tool 1 1 7. Rear liner 1 1 8. Side liners 2 2 9....
Page 7
Beacon multifuel stoves 7 technical data room min/max room heater only output (kw) 1.5-7 1.5-7 technical data beacon 75 beacon 77 room heater with domestic hot water with add in boiler type n /a n /a max output to room (kw) max output to water (kw) n /a n /a height (mm) 548 543 width (mm) 476 482 de...
Page 8
Firebox linings & throat plate the beacon multifuel stoves firebox has reflective liners to the sides and rear. A specially shaped throat plate which sits on the liners. If these are not in place please refer to page 17 to install these. Multifuel grate the static cast grate fitted to your beacon mu...
Page 9
Interlock system beacon fires are fitted with an "interlock" system. A situation where the fire door is closed and the ash door is open may lead to serious over firing which could damage the appliance. Correct use of the doors and interlock system will ensure that this does not happen. Operation is ...
Page 10
Fig. 6 door adjustment the catch can be adjusted by sharply tapping the catch on the inside of the door. Once the appliance has been under fire for a period of time the fire door may appear to have moved out of alignment with relation to the door aperture or catch on the door interlock mechanism. Th...
Page 11
Fuel types wood- any type of wood is suitable provided it is well seasoned and has a moisture content below 20%. This usually implies that the timber has been suitably stored to allow moisture to evaporate for at least nine months in the case of soft woods, and at least eighteen months in the case o...
Page 12
Ensure that you have read & understood these instructions before lighting the fire. Always wear suitable protective fire gloves when refuelling your stove. Solid fuel burning •ensure that the ash pan is in position and the fire doors are closed. •set the air wash to one quarter open position. •set t...
Page 13
Ash removal the ash pan should be emptied at least twice a day or when the level of ash reaches the top of the ash pan. On no account should the ash be allowed to build up to touch the grate as this will greatly shorten its life. De - ashing it is necessary to maintain an ash layer on the upper surf...
Page 14
Annual maintenance it is important that your fire is regularly serviced in accordance with these instructions. This should be carried out at least annually by a qualified person and should consist of the following. Remove the firebricks lining and throat plate, inspect all gasketing on doors, glass ...
Page 15
Beacon multifuel stoves 15 accessories accessories stands elegant stands are available for the beacon multifuel stoves. These increase the height of the appliance and rear flue outlet by approximately 100mm (4''). Traceries for added decorative effect, beautiful door traceries are available to compl...
Page 16
16 beacon multifuel stoves installation general precautions note - all installations must conform to the appropriate building regulations. The building regulations for england and wales 2000 ref approved document j 2002 edition (issued by the dtlr). The building standards (scotland) (consolidation) ...
Page 17
Beacon multifuel stoves 17 installation firebox liner panels the beacon multifuel stove uses firebox liner panels to the sides and back. The throat plate sits on top of the side and rear panels (fig 9). These should come fitted to your fire, if however they are not proceed as follows to fit them. •o...
Page 18
18 beacon multifuel stoves installation fitting the flue outlet and hot plate the flue outlet spigot is found packed inside the appliance. The hot plate (blanking plate) is sup- plied fitted to the top opening and is removed by turning clockwise (as is the flue outlet). Smear a very thin layer of fi...
Page 19
Beacon multifuel stoves 19 installation due to the gradual introduction of european chimney standards chimneys will be specified according to their performance designation as defined in bs en 1443 that covers the general requirements for chimneys. The minimum performance designation required for use...
Page 20
20 beacon multifuel stoves installation.
Page 21
Beacon multifuel stoves 21 installation t ypical m etal i nsulated c himney s ystem t o be installed to the chimney manufacturers instructions in compliance with building regulations and bs7566 p ts 1-4 p lan v iew of register plate and clearances for non insulated flues a is minimum clearance for n...
Page 22
22 beacon multifuel stoves installation checklist hearths, fireplaces, flues and chimneys this checklist is to ensure hearths, fireplaces, flues and chimneys are satisfactory, and to show what you have done to comply with the requirements of the building regulations 2000 approved document j 2002. 1....
Page 23
Beacon multifuel stoves 23 part list 1. Replacement instruction manual afs1269 afs1269 afs1019 afs1019 afs1083 afs1083 afs010 afs010 afs008 afs008 afs058 afs058 afs009 afs009 2. Throat plate 3. Grate 4. Hot plate 5. Operating tool 6. Ashpan 7. Flue spigot part description visual aid (not to scale) b...
Page 24
24 beacon multifuel stoves part list 8. Liner set afs1271 afs1271 afs1058 afs1058 afs1072 afs1072 afs069 afs088 afs070 afs089 afs047 afs047 afs1077 afs1077 9. Side liner 10. Back liner set 11. Glass replacement kit complete with gasket 12. Glass clips and gasket 13. Hinge kit comprises 2 hinges & 4 ...
Page 25
Beacon multifuel stoves 25 part list 15. Fire door rope kit complete with door rope glue. Afs048 afs048 afs1270 afs1272 afs094a afs095 afs1146 afs1146 afs997 afs997 16. Main door assembly complete with handle,glass, gaskets,clips and seal. 17. Decorative door surround 18. Fire door locking assembly ...
Page 26: Guarantee
26 beacon multifuel stoves guarantee guarantee once again we would like to thank you for buying a beacon multifuel stove. When you buy an aarrow fire, you are not only buying a first class appliance - you are buying a commitment from us to look after you and your appliance for as long as you want. T...
Page 27
Beacon multifuel stoves 27 service record should you have any questions about your beacon multifuel stove that is not covered in this manual please contact your aarrow retailer. Please keep all repair receipts safely. Please ensure you have this manual available when an engineer visits as they will ...
Page 28: I’Ve Checked It
Final factory check list bk001 quality finish parts flue outlet hot plate operating instructions grate firebox linings throat plate air wash door catches interlock ash pan operating tool model.................................. Serial no............................. I’ve checked it and it’s o.K. Asse...