ABS AS 0530 Installation And Operating Instructions Manual - page 5
Installation and Operating Instructions 7
ABS submersible wastewater pump AS
ABS submersible wastewater pump AS
Legend
1004-00
Model
Pump type/ Item No.
SN
Serial No.
UN
Rated Voltage
P2
Rated Output Power
HP
)/$PSV
)XOO/RDG$PSV
Hz
)UHTXHQF\
Phase
Three/Single Phase
RPM
Speed
min-1
Imp. dia
Impeller diameter
mm
Max. چ
Max submersible depth
)W
)ORZ0D[
Rated Discharge
GPM
Head Max. Max. Head
)W
Figure 4 Nameplate Standard Version
2 Safety
7KHJHQHUDODQGVSHFL¿FKHDOWKDQGVDIHW\KLQWVDUHGHVFULEHGLQGHWDLOLQWKHVHSDUDWHERRNOHW6DIHW\+LQWV,I
anything is not clear or you have any questions as to safety make certain to contact the manufacturer ABS.
3 Transport
m
During transport the unit should not be dropped or thrown.
c
The unit should never be raised or lowered by the Power cable.
7KHXQLWLV¿WWHGZLWKDOLIWLQJGHYLFHWRZKLFKDFKDLQDQGVKDFNOHPD\EHDWWDFKHGIRUWUDQVSRUWSXUSRVHV
m
Any hoist used must be adequately dimensioned for the weight of the unit.
All relevant safety regulators as well as general good technical practice must be complied with.
4 Set-up and installation
ATTENTION All relevant regulations covering sewage pumping installations and, where
applicable, explosion-proof installations must be complied with.
c
7KHFDEOHGXFWWRWKHFRQWUROSDQHOVKRXOGEHPDGHJDVWLJKWE\¿OOLQJZLWKIRDPDIWHUWKHSRZHU
supply and control circuit cables have been laid.
m
Particular attention must be paid to the safety regulations covering work in closed areas in
sewage plants as well as good general technical practices .
4.1 Discharge line
The discharge line must be installed in compliance with the relevant regulations.
DIN 1986/100 and EN 12056 applies in particular to the following:
7KHGLVFKDUJHOLQHVKRXOGEH¿WWHGZLWKDEDFNZDVKORRSEHQGORFDWHGDERYHWKHEDFNZDVKOHYHODQG
VKRXOGWKHQÀRZE\JUDYLW\LQWRWKHFROOHFWLRQOLQHRUVHZHU
The discharge line should not be connected to a down pipe.
1RRWKHULQÀRZVRUGLVFKDUJHOLQHVVKRXOGEHFRQQHFWHGWRWKLVGLVFKDUJHOLQH
ATTENTION The discharge line should be installed so that it is not affected by frost.
-
-
-