Summary of OptiFresh 1
Page 1
Nl gb d f gebruiksaanwijzing manual betriebsanleitung mode d'emploi.
Page 2
48 07/2009 rev. 0.9 07/2009 rev. 0.9 49 content preface .......................................................................................................................................... 50 purpose of use ..........................................................................................
Page 3
50 07/2009 rev. 0.9 07/2009 rev. 0.9 51 © 2009 animo® all rights reserved. No part of this document may be reproduced and/or made public in print, micro lm, electronic media or any other form without the manufacturer's prior consent. This also applies to the corresponding diagrams and/or charts. Ani...
Page 4
52 07/2009 rev. 0.9 07/2009 rev. 0.9 53 purpose of use this device can only be used for preparing hot drinks. Use for any other purpose is inadmissible and can be dangerous. The manufacturer cannot be held liable for any damages caused by use for any other purpose than what is described here or by i...
Page 5
54 07/2009 rev. 0.9 07/2009 rev. 0.9 55 safety provisions this device has the following safety provisions: door switch (1-18) the machine has a door switch that automatically switches off the machine when the door is opened. [ out of order door open ] the machine can be switched on whilst the door i...
Page 6
56 07/2009 rev. 0.9 07/2009 rev. 0.9 57 2. Technical data model optifresh optifresh hot & cold capacity coffee hour capacity per cup of 120 ml 125 cups 125 cups preparation time per cup of 120 ml abt. 29 sec. Abt. 29 sec. Preparation time jug (12 x 120ml cups) 5’.50” 5’.50” preparation time jug (7 x...
Page 7
58 07/2009 rev. 0.9 07/2009 rev. 0.9 59 3. Installation this device should only be placed and connected by an authorised service engineer. The following must be taken into account: • only suitable for indoor use • unsuitable for use in damp areas • unsuitable in areas with a risk of explosion 3.1 un...
Page 8
60 07/2009 rev. 0.9 07/2009 rev. 0.9 61 3.4 electrical connection warning supply voltage and frequencies can differ per country. Check if the appliance is suitable for connection to the local power mains. Check if the details on the type plate ( g. 6) correspond. Connect the appliance to an earthed ...
Page 9
62 07/2009 rev. 0.9 07/2009 rev. 0.9 63 3.8 standard recipe settings 1-12 = standard = optional = special model (only on request) table 1 1 2 3 4 recipes button no. Coffee 1 1 1 1 coffee with milk 2 2 coffee with sugar 3 coffee with sugar & milk 4 espresso 2 2 3 5 double espresso 3 3 4 6 hot chocola...
Page 10
64 07/2009 rev. 0.9 07/2009 rev. 0.9 65 3.10 positioning 3.10.1 positioning on the work top 1. Position the device on an appropriate at work area. 2. Allow an area of at least 11 cm to the left of the device so that the door can be opened. 3. Allow an area of at least 22 cm above the device so that ...
Page 11
66 07/2009 rev. 0.9 07/2009 rev. 0.9 67 5. Operating panel the device has two operating panels. • the front operating panel ( g. 22) is for normal daily use. • the operating panel at the inside of the door ( g. 23) can be used by the operator to gain access to the operator and service menus (only wi...
Page 12
68 07/2009 rev. 0.9 07/2009 rev. 0.9 69 escape (back without con rming any changes) previous (menu item / increase value) next (menu item / decrease value) enter (con rm menu choice) operator menu structure range factory setting > yes > yes no hour : min dd - mm - yyyy 00:00-23:59 00:00 = not active...
Page 13
70 07/2009 rev. 0.9 07/2009 rev. 0.9 71 6.2 quick recipe with the quick recipe ( g. 25) you can easily adjust the volume and the strength of the used ingredients such as coffee, milk (topping), cocoa and/or sugar for each drink (recipe). The quick recipe menu is only available if it has been activat...
Page 14
72 07/2009 rev. 0.9 07/2009 rev. 0.9 73 7.3 dispensing cups/goblets the machine has separate dispensing points for hot drinks and water ( g. 30). Hot drinks hot water cold water (option) see g. 31: 1. Select your drink. 2. The blue led above the dispensing point starts ashing. 3. Place your cup and ...
Page 15
74 07/2009 rev. 0.9 07/2009 rev. 0.9 75 7.5 payment systems (optional) 7.5.1 coin system major parts ( g. 35): 1. Coin acceptor slot 2. Returns button 3. Money return slot 4. Money tray 5. Door lock is also money tray lock set to free 1. Open the operator menu (see chapter 6). 2. Go to 1.0 free vend...
Page 16
76 07/2009 rev. 0.9 07/2009 rev. 0.9 77 8. Maintenance warning the device must not be submerged or hosed down. Do not leave the device during maintenance. You can follow the haccp hygiene code instructions of your organisation for the use of cleaning products. Look or search under object: machine of...
Page 17
78 07/2009 rev. 0.9 07/2009 rev. 0.9 79 8.3 cleaning daily 8.3.1 cleaning the brewer unit the brewer is in constant contact with coffee. After some time, a deposit of coffee oils, coffee particles and minerals from the water forms on the brewer's permanent lter. This will reduce the permeability of ...
Page 18
80 07/2009 rev. 0.9 07/2009 rev. 0.9 81 8.4 weekly cleaning 8.4.1 cleaning the brewer lter / brewer chamber carry out before the daily cleaning. Duration: approx. 5 min. Requirements: - permanent lter (cleaned) (art. No. 03488) - filter disassembly tool (art. No. 03343) 1. Open the door of the machi...
Page 19
82 07/2009 rev. 0.9 07/2009 rev. 0.9 83 8.4.4 removing the entire brewer the brewer can be entirely removed for thorough cleaning. Removing the brewer ( g. 49): 1. Open the door of the machine and press the open/ close brewer button. The brewer will turn into the 'open' position. Close the door or p...
Page 20
84 07/2009 rev. 0.9 07/2009 rev. 0.9 85 8.5.2 cleaning the mixer extraction lter first carry out chapter 8.4.5 cleaning the mixer unit (weekly)! If the machine is used very frequently, carry out this cleaning procedure every week! Duration: approx. 2 min. Requirements: - normal detergent / coffee fu...
Page 21
86 07/2009 rev. 0.9 07/2009 rev. 0.9 87 8.6 cleaning the canister(s) daily: clean the dispensing opening ( g. 53-1) and the dispensing element ( g. 53-2) with a dry dusting brush. Weekly: empty and clean the ingredient canister(s) with a dry dusting brush. Remove any caked residue. Monthly: empty an...
Page 22
88 07/2009 rev. 0.9 07/2009 rev. 0.9 89 warning in order to descale the water reservoir, the device must be opened. This will expose live parts of the machine, which can be touched easily. This can lead to highly dangerous situations! Warning the device must not be submerged or hosed down. Always st...
Page 23
90 07/2009 rev. 0.9 07/2009 rev. 0.9 91 12. Troubleshooting display messages and errors possible cause action out of order boiler lling when used for the rst time: boiler is still empty and is being lled. No action required. When boiler achieves the appropriate level, the display will show 'boiler i...
Page 24
92 07/2009 rev. 0.9 07/2009 rev. 0.9 93 malfunction possible cause action the device does not work. Fuses (distribution board). Check fuses. Main switch (distribution board). Check main switch. The plug and lead. Check main cable. The device does not respond. The device is in standby. Switch off sta...
Page 25
186 07/2009 rev. 0.9 07/2009 rev. 0.9 187 afmetingen / dimensions / abmessungen / dimensions optifresh 1, 2 & 3 (hot & cold) (optifresh 3) 272 390 60 91 187 131 36 527 214 123 800 821 483 589 402 839 89 ~ volt afmetingen / dimensions / abmessungen / dimensions optifresh 4 (hot & cold) 589 527 483 60...
Page 26
188 07/2009 rev. 0.9 07/2009 rev. 0.9 189 afmetingen / dimensions / abmessungen / dimensions optifresh 1, 2, 3 muntmechannisme / coin system / münzprüfer system / système monnayeur optifresh 4 muntmechannisme / coin system / münzprüfer system / système monnayeur 589 483 527 483 214 123 800 821 553 2...
Page 27
190 07/2009 rev. 0.9 232 962 521 925 670 485 505 625 240 afmetingen / dimensions / abmessungen / dimensions onderkast / base cabinet / unterschrank / table support art.Nr. 65070 met afvalbak / with waste bin / mit abfallbehälter / avec trappe art.Nr. 65060 met koelunit / with cool unit / mit kühlein...