Antunes, AJ TBS-1X Owner's Manual - page 11
TACO BELL STEAMER TBS-2X & TBS-1X
10
P/N 1010698 Rev. E 03/04
11
TACO BELL STEAMER TBS-2X & TBS-1X
P/N 1010698 Rev. E 03/04
Daily Cleaning
1. Turn the Rocker Switch (power On/Off) to OFF,
unplug the power cord(s), and allow the unit to
cool down before proceeding.
2. Check the water quick disconnect fitting and all
hose clamp connections for leakage. If leakage
is apparent, tighten all clamps or replace part if
required.
3. Remove the Top Cover, Spatula(s), and Liner(s)
(Figure 4).
4. Remove Chimney from rear of unit by sliding
upward and away from unit (Figure 4). Clean the
Top Cover, Spatula(s), Liner(s), and chimney in
hot soapy water, rinse in clear water and wipe
dry.
5. Clean the chamber(s) of any product spills.
6. Clean entire unit with a clean, hot, damp cloth
(not dripping wet) and wipe dry.
7. Re-install chimney, liner(s) and spatula(s) and
Top Cover.
MAINTENANCE
WARNING
Turn the unit off, disconnect the power source
and allow the unit to cool down before performing
any service or maintenance on the unit. The TBS-
2X has two power cords. Make sure both cords
are disconnected.
CAUTION
Chlorides or phosphates in cleansing agents
(e.g. bleach, sanitizers, degreasers or detergents)
could cause permanent damage to stainless steel
equipment. The damage is usually in the form of
discoloration, dulling of metal surface finish, pits,
voids, holes or cracks. This damage is permanent
and not covered by warranty. The following tips
are recommended for maintenance of your stain-
less steel equipment:
• Always use soft, damp cloth for cleaning, rinse
with clear water and wipe dry. When required,
always rub in direction of metal polish lines.
• Routine cleaning should be done daily using
soap, detergent, and water.
• Stains and spots should be sponged using a
vinegar solution.
• Finger marks and smears should be rubbed off
using soap and water.
• Hard water spots should be sponged using a
vinegar solution.
Figure 4. Steamer Components
Spatula
Chimney
Liner
Generator
Cover
Diffuser
Steam Generator
Top Cover
Wing Nut
CAUTION
Do not use a sanitizing solution or abrasive mate-
rials. The use of these may cause damage to the
stainless steel finish.
CAUTION
If a chemical cleaner is used, be sure it is safe to
use on cast aluminum. Observe all precautions
and warnings on product label.
NOTE: Frequency of cleaning is determined by
water conditions, usage, and water filter systems.
Steam
Ports