Audio International AI-HUB-03-x Installation Manual

Manual is about: Data Interface Switch Module

Summary of AI-HUB-03-x

  • Page 1

    7300 industry drive, north little rock, ar 72117 phone: 501-955-2929 fax: 501-955-2988 www.Audiointl.Com installation manual ai-hub-03-x data interface switch module document # 540316 a decrane aircraft company.

  • Page 2

    Audio international, inc. Ai-hub-03-x installation manual document # 540316, rev ir, 03/2006 page 1 of 12 document revision history rev. Level date description ir 03/2006 initial release reference documents document # description 524387 rev ir1 ai-hub-03-x outline drawing service bulletin list servi...

  • Page 3: Table of Contents

    Audio international, inc. Ai-hub-03-x installation manual document # 540316, rev ir, 03/2006 page 2 of 12 table of contents section description page 1.0 general information …………………………………………….. 3 1.1 introduction ………………………………………………………… 3 1.2 purpose of the equipment ……………………………………….. 3 1.3 optional e...

  • Page 4: Ai-Hub-03-X

    Audio international, inc. Ai-hub-03-x installation manual document # 540316, rev ir, 03/2006 page 3 of 12 ai-hub-03-x data interface switch module 1.0 general information 1.1 introduction this manual contains information for the proper installation of the audio international, inc. (ai) data interfac...

  • Page 5

    Audio international, inc. Ai-hub-03-x installation manual document # 540316, rev ir, 03/2006 page 4 of 12 2.0 application 2.1 introduction 2.1.1 each switch has eight (8) connector ports with built-in leds to monitor individual port status, an automatic address learning function to build the packet ...

  • Page 6

    Audio international, inc. Ai-hub-03-x installation manual document # 540316, rev ir, 03/2006 page 5 of 12 2.3 block diagram – typical application.

  • Page 7

    Audio international, inc. Ai-hub-03-x installation manual document # 540316, rev ir, 03/2006 page 6 of 12 3.0 installation 3.1 prior to installation 3.1.1 during the design and layout of the aircraft cabin, careful consideration of the location of this module is necessary. Some of the items to be co...

  • Page 8

    Audio international, inc. Ai-hub-03-x installation manual document # 540316, rev ir, 03/2006 page 7 of 12 3.3.4 a one (1) inch air space, minimum, is required on top of the unit for internal cooling fan air circulation. 3.3.5 do not install near heat sources such as direct sunlight, warm air exhaust...

  • Page 9

    Audio international, inc. Ai-hub-03-x installation manual document # 540316, rev ir, 03/2006 page 8 of 12 3.4.2 power wires audio international recommends the chassis be electrically bonded to the airframe structure by a conductive mounting point with Ω resistance using webbing impregnated with alum...

  • Page 10

    Audio international, inc. Ai-hub-03-x installation manual document # 540316, rev ir, 03/2006 page 9 of 12 3.7 mating connector information all wiring harnesses to the unit shall be supplied and fabricated by the installing agency. Model # pin # mating connector p1 – p8 943-sp-37-08-08-s stewart ai-h...

  • Page 11

    Audio international, inc. Ai-hub-03-x installation manual document # 540316, rev ir, 03/2006 page 10 of 12 4.2 general troubleshooting procedures many problems can be isolated with the following general techniques: • to verify power to the unit, recheck +28 vdc power is applied to the proper pins on...

  • Page 12

    Audio international, inc. Ai-hub-03-x installation manual document # 540316, rev ir, 03/2006 page 11 of 12 5.0 specifications physical specifications housing aluminum weight approx. 1.21 lb / 0.55 kg dimensions (l x w x h) 6.25" x 10.44" x 1.5" 15.9 cm x 26.5 cm x 3.8 cm 6.0 reference drawings the f...

  • Page 13

    Audio international, inc. Ai-hub-03-x installation manual document # 540316, rev ir, 03/2006 page 12 of 12.