? 2006 b&b armr corporation 0480-9001 revision a3 model 480 series sliding gate operations & maintenance manual b&b armr corporation corporate and technical support: field service: 2009 chenault drive 1934 old gallows road carrollton, tx 75006 suite 114 vienna, va 22182 phone: (800) 367-0387 fax: (9...
Installation and operations manual — model 480 series introduction ii © 2006 b&b armr corporation www . Bb - armr . Com (800)-367-0387 introduction welcome! Congratulations on your purchase of a b&b armr vehicle barrier. In addition to providing detailed operating instructions, this manual describes...
Installation and operations manual — model 480 series introduction iii © 2006 b&b armr corporation www . Bb - armr . Com (800)-367-0387 symbol meaning: the lightning flash with arrowhead symbol, within an equilateral triangle, is intended to alert the user to the presence of uninsulated "dangerous v...
Installation and operations manual — model 480 series table of contents 5 © 2006 b&b armr corporation www . Bb - armr . Com (800)-367-0387 table of contents introduction........................................................................................................Ii safety.....................
Installation and operations manual — model 480 series orientation 5 © 2006 b&b armr corporation www . Bb - armr . Com (800)-367-0387 1 orientation 1.1 overview the model 480 vehicle barrier is designed to contain a vehicle impact and prevent that vehicle from entering a restricted access control are...
Installation and operations manual — model 480 series orientation 6 © 2006 b&b armr corporation www . Bb - armr . Com (800)-367-0387 7. Support wheels 8. Drive wheels figure 1: model 480 cantilever gate barrier figure 1 orients you to the basic components of the model 480 vehicle barrier. 1.1.1 driv...
Installation and operations manual — model 480 series orientation 7 © 2006 b&b armr corporation www . Bb - armr . Com (800)-367-0387 caution: hydraulic hoses are under extreme pressure. Use caution when working on barrier with access cover removed. 1.1.5 battery compartment the battery compartment h...
Installation and operations manual — model 480 series installation 8 © 2006 b&b armr corporation www . Bb - armr . Com (800)-367-0387 caution: for your safety, complete each of these steps before operating the barrier! Verify unit has hydraulic fluid to recommended level. Verify control unit is plug...
Installation and operations manual — model 480 series maintenance 9 © 2006 b&b armr corporation www . Bb - armr . Com (800)-367-0387 2.3 operating time the operating time for the 480 gate is approximately 20-25 seconds to open and close. The time is dependent on the gate length and the gate alignmen...
Installation and operations manual — model 480 series maintenance 10 © 2006 b&b armr corporation www . Bb - armr . Com (800)-367-0387 xcont-8900x24dc contactor, single pole, 60 amp, 24vdc coil xradio-mwt02 door edge transmitter, miller edge xwheel-23345t15 v-groove wheel, 8" x 4", mcmaster xlamp-67w...
Installation and operations manual — model 480 series maintenance 11 © 2006 b&b armr corporation www . Bb - armr . Com (800)-367-0387 safety edge transmitters must have the 9v battery changed every 3 months to prevent failure of the safety device the 480 gate must be operated a minimum of 2-3 times ...
Installation and operations manual — model 480 series troubleshooting 12 © 2006 b&b armr corporation www . Bb - armr . Com (800)-367-0387 4.1 model 480 troubleshooting guide the table below provides guidance on identifying and correcting any problems with your model 480 series vehicle barrier. Pleas...
Installation and operations manual — model 480 series troubleshooting 13 © 2006 b&b armr corporation www . Bb - armr . Com (800)-367-0387 symptom actions hydraulic unit excessively hot 1. Check that the pressure relief valve is closed (fully clockwise). 2. Check that the pressure switch is adjusted ...
Installation and operations manual — model 480 series warrenty 14 © 2006 b&b armr corporation www . Bb - armr . Com (800)-367-0387 5 warranty b&b-armr corporation warranties for a period of one year, after delivery f.O.B. Plant, unless otherwise specified by supplier, from failure of operation in or...
Installation and operations manual — model 480 series appendix 15 © 2006 b&b armr corporation www . Bb - armr . Com (800)-367-0387 equipment maintenance log form product type:________________________ b&b armr 800-367-0387 location:____________________________ servicedept@bb-armr.Com date performed b...
