1. DL manuals
  2. Bad Boy
  3. Lawn Mower
  4. 2010 6000 Compact
  5. Owner's & Parts Manual

Bad Boy 2010 6000 Compact Owner's & Parts Manual

Summary of 2010 6000 Compact

  • Page 1

    Zt model mower owner’s & parts manual 2010 edition for additional information, please see us at www.Badboymowers.Com bad boy, inc. 102 industrial drive batesville, arkansas 72501 (870) 698-0090 page 1.

  • Page 2: Table Of Contents

    Table of contents basic information ........................................................................................... Section 1 (pages 3, 4) bad boy safety guidelines ............................................................................. Section 2 (pages 5, 6) operation ...............

  • Page 3

    This manual applies to the following equipment: bad boy zt series zt 2600 36˝ 26 hp briggs els zt 2600 50˝ 26 hp briggs els zt 2300 50˝ 27 hp kohler zt 2300 60˝ 27 hp kohler all information in this manual may not apply to your mower! Page 3.

  • Page 4: Section 1:

    Section 1: basic information congratulations on the purchase of your new bad boy mower! The purpose of this manual is to assist operators in maintaining and operating their machine. The information and instructions in this manual can help you attain years of performance from your new bad boy. Also, ...

  • Page 5: Section 2:

    Section 2: mower operation never allow untrained people to operate this machine. It is the owner’s responsibility to get training and see to it that anyone who has permission to use your machine receives the proper training. Do not mow around people. The factory discharge chute is designed to deflec...

  • Page 6: Section 3:

    2.23 safety warning decals are located on the mower and should always be observed and followed. 2.24 never operate the mower with the discharge chute open. 2.25 prevent fires—remove grass and debris from engine compartment and muffler area, before and after operating machine, especially after mowing...

  • Page 7: Section 4:

    3.9 increase rpm by sliding the throttle to fast position, toward the rabbit. 3.10 owners must become familiar with the controls before operating a zero-turn radius vehicle. 3.11 start slowly and build your skill level. Have ample practice before using the machine at full capabilities. 3.12 be comfo...

  • Page 8: Section 5:

    Section 5: mower storage 5.1 keep machine from collecting debris by storing in a covered area while not in use. 5.2 fuel can harm your machine if left for more than 30 days without changing. 5.3 disconnect the negative battery cable when machine will be stored for more than 30 days. 5.4 always secur...

  • Page 9: Section 7:

    Standard hydraulic/ oil/filter servicing procedure 6.12 on all bad boy zt models, the hydraulic oil filters need to be initially changed when the mower has reached 50 hours of usage. Each subsequent changing of the hydraulic oil and filters needs to occur every 250 hours or once a year. The required...

  • Page 10: Section 8:

    7.7 q: what is the difference between a liquid-cooled engine and an air cooled-engine? 7.7 a: a liquid-cooled engine gives you a constant operating temperature which will increase fuel economy, decrease oil breakdown, and may last up to 50% longer. In addition, a cooler engine also means a cooler op...

  • Page 11

    8.3 choke control—a cable is linked to manually operate the engine choke. When the lever is in the down position, the choke is in the off (run) position. When the lever is pulled up, the choke is in the on (start) position. Do not operate the machine in the on (start) position. The choke lever is be...

  • Page 12: Section 9:

    Section 9: moving inoperable mower 9.1 if it is necessary to move mower when the engine is inoperable, the hydraulic drive pumps are equipped with bypass valves. Before moving the mower, turn the bypass valves counter- clockwise one-half to one revolution. The valve stems on each pump are located ne...

  • Page 13: Section 10:

    Section 10: instrumentation 10.1 electronic hour meter—registers hour increments up to 9,999.9 total hours. This meter records the cumulative time the engine is running. 10.2 oil pressure light—not on zt models—this light comes on upon placing the ignition switch in the run position and stays lit un...

  • Page 14: Section 11:

    Section 11: mower blade maintenance 11.1 check mower blades after each use. This is essential for maintaining well-groomed turf. Keep the blades sharp. If a dull blade is used for cutting, the grass will tear rather than cut. This could damage the grass leaving a brown frayed top on the grass within...

  • Page 15: Parts Manual For Your

    Parts manual for your zt model zero turn mower page 15.

  • Page 16

    Page 16.

  • Page 17

    Page 17.

  • Page 18

    Page 18.

  • Page 19

    Page 19.

  • Page 20

    Page 20

  • Page 21

    Page 21.

  • Page 22

    Page 22.

  • Page 23

    Page 23.

  • Page 24

    Page 24.

  • Page 25

    Page 25.

  • Page 26

    Page 26.

  • Page 27

    Page 27.

  • Page 28

    Page 28.

  • Page 29

    Page 29.

  • Page 30

    Notes: __________________________________________________________________ _________________________________________________________________________ _________________________________________________________________________ _________________________________________________________________________ ____...

  • Page 31

    Bad boy, inc. 102 industrial drive batesville, ar 72501 1.866.622.3269 www.Badboymowers.Com technical support: james russell ..........................................................................................................Extension 6638 bill hurst (bill@badboymowers.Com) ......................

  • Page 32: Www.Badboymowers.Com

    For additional information, please see us at www.Badboymowers.Com bad boy, inc. 102 industrial drive batesville, arkansas 72501 (870) 698-0090 page 32.