1. DL manuals
  2. Bailey
  3. Motorhomes
  4. Caravan
  5. Owner's Manual

Bailey Caravan Owner's Manual

Summary of Caravan

  • Page 1

    Owner’s manual.

  • Page 2: Owner’S Details

    Owner’s details model _________________________________________________________________ vehicle identification number v.I.N. _______________________________________ owner’s name __________________________________________________________ address _______________________________________________________...

  • Page 3: Enjoy All These Benefits

    Away from the rush of every day life and the busy tourist centres, you’ll find 200 club sites in areas of outstanding natural beauty across the country. Some located in national parks, on land owned by the national trust or even in the grounds of stately homes. And around 2,500 small, informal sites...

  • Page 4: Contents

    Contents owner’s details ............................................................ 1 1.1 introduction ........................................... 1-1 1.2 warranty .................................................. 1-2 1.3 warranty cover .................................... 1-2 1.3.1 6 year body s...

  • Page 5: Contents

    Contents 4.9.3 energy selection ......................................... 4-18 4.9.4 temperature setting cooling compartment .. 4-20 4.9.5 exchange of the igniter’s battery ................. 4-20 4.9.6 storing food ................................................. 4-20 4.10 dometic refrigerator mode...

  • Page 6: Contents

    Contents 4.24.4 fault finding ................................................ 4-58 4.25 daewoo microwave oven ................. 4-59 4.25.1 precautions to avoid possible exposure to excessive microwave energy ...................... 4-59 4.25.2 operational procedure ................................ ...

  • Page 7: Of A Fine Touring Caravan!

    Congratulations on the purchase of a fine touring caravan! The caravan handbook. From haynes “glove box” series, this caravanning handbook offers advice on topics like tow cars and towing, storing your caravan, choosing and using an awning, accessories worth considering, using your caravan’s applian...

  • Page 8: Introduction

    1-1 introduction 1 1.1 introduction bailey of bristol welcome you to the ranks of bailey owners. This handbook has been designed to enable you to derive the maximum benefits and enjoyment from your caravan, its information will be of benefit to both experienced and new caravanners alike. Several sec...

  • Page 9: Introduction

    1-2 1 introduction 1.2 warranty any claims under warranty must be made through the retailer from whom the caravan was purchased. It is with the retailer that the purchaser’s contract of sale exists and consequently bailey caravans cannot enter into any discussions with the purchaser. Bailey retailer...

  • Page 10: Introduction

    1-3 introduction 1 fridge; door seal, condenser, gas control valve, gas igniter, flame failure device, 12 and 230v heater elements, gas thermostat, 230v thermostat, 230v temperature control switch. Water system; water heater (gas or electric), fresh water tank, water pump, water gauges, taps and sho...

  • Page 11: Introduction

    1-4 1 introduction 1.4 caravan registration and identification scheme (c.R.I.S) this caravan has been security marked and recorded under the caravan registration and identification scheme that is organised by the caravan industry. Shortly after purchasing this caravan you should receive your touring...

  • Page 12: Introduction

    1-5 introduction 1 1.5 safety this handbook contains the information that you will require for safe enjoyment of your tourer. All of the information contained herein is important. However to draw your attention to specific items we have prefixed them with the following symbols to indicate a warning,...

  • Page 13: Introduction

    1-6 1 introduction.

  • Page 14: Caravan & Tow Vehicle

    2-1 caravan & tow vehicle 2 2.1 introduction choosing the right car and caravan combination for safe and stable towing is both an art and a science. It may seem complicated to the newcomer, but a few minutes spent understanding the basic principles, common terms and definitions in use will be worthw...

  • Page 15: Caravan & Tow Vehicle

    2-2 2 caravan & tow vehicle maybe no yes 85% 2.2.1 measurement of nose weight nose weight may be measured using a proprietary brand of nose weight indicator. Such equipment is obtainable from your bailey dealer. Another simple method is to use bathroom scales and a suitable piece of strong timber as...

  • Page 16: Caravan & Tow Vehicle

    2-3 caravan & tow vehicle 2 the greater the towing vehicle’s tail overhang (the distance between the rear axle and the tow ball) the greater the effect the noseweight will have on the towing vehicle’s rear suspension. After trying out the caravan it may be found that stiffening of the rear suspensio...

  • Page 17: Caravan & Tow Vehicle

    2-4 2 caravan & tow vehicle where no designated attachment point has been provided on the towbar: fixed ball - loop the cable around the neck of the towball. If you fit the cable like this, use a single loop only. See figs. B and c. Detachable ball - you must seek guidance on procedure from the towb...

  • Page 18: Caravan & Tow Vehicle

    2-5 caravan & tow vehicle 2 ▲ always load the caravan in such a way that maximises towing safety. Incorrect caravan loading and/or overloading of the towing vehicles rear suspension will also result in poor towing stability. The weight should be distributed so that each side of the caravan carries, ...

  • Page 19: Caravan & Tow Vehicle

    2-6 2 caravan & tow vehicle 5. All lockers and cupboard doors are closed and secured 6. All bunks are secure 7. All rooflights, extractor fans and sunroofs are closed and secured 8. Tables are securely stored in their transit positions 9. Fridge is on 12v operation and door lock is set (if required)...

  • Page 20: Caravan & Tow Vehicle

    2-7 caravan & tow vehicle 2 the final positioning should be carried out by manoeuvring the caravan by hand. Carefully release the caravan handbrake. Manoeuvre the caravan by hand to position the caravan’s tow hitch directly over the car’s tow ball. ▲ always manoeuvre the caravan by pushing /pulling ...

  • Page 21: Caravan & Tow Vehicle

    2-8 2 caravan & tow vehicle pick up any levelling pads or levelling boards. Check round the caravan for anything left behind. Fully release the caravan’s handbrake. Carry out a second check that the hitch is secure and the secondary braking cable is connected. Adjust all of the car’s driving mirrors...

  • Page 22: Caravan & Tow Vehicle

    2-9 caravan & tow vehicle 2 reduce speed in high winds, cross winds, downhill or in poor visibility. High sided vehicles such as lorries or coaches can cause air buffeting, so extra care must be taken when passing or being passed. Give as muchspace as is possible between your caravan and the high si...

  • Page 23: Caravan & Tow Vehicle

    2-10 2 caravan & tow vehicle 2.3.9 stabilisers a stabiliser should never be used to try to improve a caravan/towing vehicle combination that has poor stability as instability may appear at higher speed. However, a good stabiliser can make an acceptable caravan/towing vehicle combination more comfort...

  • Page 24: Caravan & Tow Vehicle

    2-11 caravan & tow vehicle 2 the cleaning of tyres should only be carried out using soap and water. Petrol, diesel, paraffin and other solvents are not suitable. If the caravan is not used for long periods of time (winter months) it is recommended that the wheels/ tyres are removed and stored at nor...

  • Page 25: Caravan & Tow Vehicle

    2-12 2 caravan & tow vehicle the condition of wheels should be checked regularly particularly for distortion of flanges and the wheel dish. Wheels damaged or distorted, or having the wheel bolt seating cracked or deformed must not be repaired. If a wheel or tyre has to be changed it should be of the...

  • Page 26: Caravan & Tow Vehicle

    2-13 caravan & tow vehicle 2 iii. Lower the corner steadies as a safety measure to stabilise the caravan. Chock the un-punctured wheel on the opposite side of the caravan to prevent any movement. Iv. Slacken off the wheel bolts by no more than one quarter of a turn on the wheel that requires changin...

  • Page 27: Caravan & Tow Vehicle

    2-14 2 caravan & tow vehicle 2.3.18 levelling the caravan levelling must be carried out in both directions in order for the refrigerator and other equipment to function correctly. The positioning of the jockey wheel can be used to help level the caravan. Lower the corner steadies until they are in f...

  • Page 28: Caravan Service Systems

    3-1 caravan service systems 3 3.1 the water system 3.1.1 water supply all models are supplied with a 12 volt submersible pump, controlled by a pressure switch. The water inlet is located in the off-side exterior wall, protected by a lift up lid. 3.1.2 the submersible pump (discovery & ranger) operat...

  • Page 29: Caravan Service Systems

    3-2 3 caravan service systems 3.1.3 whale smartflo on board pump (pageant & senator) operation valves: both the manual valves included in this system must be positioned appropriately (fig 1-3) when switching between the three functions of the water system; using an external water supply, filling the...

  • Page 30: Caravan Service Systems

    3-3 caravan service systems 3 9. The system is now ready for use. Hose can be inserted into plug groove (fig. 6) to keep filter off the ground while refilling water container. Keep socket lid shut at all times when plug is removed. 10. When the caravan is left unattended or water supply has been all...

  • Page 31: Caravan Service Systems

    3-4 3 caravan service systems 3.1.5 troubleshooting (pageant & senator) fault cause solution pump doesn’t run no power to pump check power supply attach leads/clean corrections check tap microswitch if present. Fuse has blown replace fuse do not exceed recommended fuse size. Blockage in pipework che...

  • Page 32: Caravan Service Systems

    3-5 caravan service systems 3 3.1.6 routine maintenance ● ensure the hose adapter ‘o’ ring and the socket in the housing are kept free from dirt. ● use only silicone or water based lubricant to inlet nipple ‘o’ rings on socket for lubrication. ● drain system thoroughly during the winter months, (see...

  • Page 33: Caravan Service Systems

    3-6 3 caravan service systems 3.1.11 aquasource direct mains water connection (this is not included as standard equipment, but is available from your nearest bailey retailer). ● the aquasource fits simply and securely to your whale socket system. ● comes with 7.5m of foodgrade layflat hose, which is...

  • Page 34: Caravan Service Systems

    3-7 caravan service systems 3 3.1.15 waste (grey) water system the waste water (often referred to as ‘grey’ water) from the caravan’s sinks and shower tray are routed to two outlets just behind the offside wheel. When setting up your caravan short pieces of waste pipe hose should be fitted to the wa...

  • Page 35: Caravan Service Systems

    3-8 3 caravan service systems 3.2.2 types of gas ● butane butane is supplied in the uk in green or blue bottles. Continental bottles usually have a male left hand thread similar to but not identical with uk butane. Butane is suitable for use at temperatures down to 2 °c but will not work below that ...

  • Page 36: Caravan Service Systems

    3-9 caravan service systems 3 your caravan is fitted with a regulator as standard equipment. This is located in the caravan gas box mounted on the front bulkhead of the caravan between the gas bottles. The gas regulator has a working pressure of 30mbar and is suitable for both propane and butane liq...

  • Page 37: Caravan Service Systems

    3-10 3 caravan service systems extinguish naked lights including cigarettes and pipes. Do not operate electrical switches. Open all doors and windows to disperse any gas escape. Butane/propane gas is heavier than air, any escaping gas will therefore collect at a low level. The strong unpleasant smel...

  • Page 38: Caravan Service Systems

    3-11 caravan service systems 3 3.3 the electrical system – 230 volt as in the home, care must be exercised when handling mains electricity. Your attention is drawn to the following notice as laid down by the institute of electrical engineers. Instructions for electricity supply - low voltage (230 v)...

  • Page 39: Caravan Service Systems

    3-12 3 caravan service systems 3.3.2 on leaving caravan site ● first switch off the site supply. ● switch off the caravan rcd unit. ● then disconnect the pitch lead. In case of difficulty consult an approved electrical installation contractor (who may be the local electricity board). It is dangerous...

  • Page 40: Caravan Service Systems

    3-13 caravan service systems 3 a means of checking the polarity of the mains supply when overseas is useful. There are available several proprietary makes of equipment for the purpose (e.G. Martindale tester unit). If it can be achieved, it is preferable to connect live to live, and neutral to neutr...

  • Page 41: Caravan Service Systems

    3-14 3 caravan service systems 230v mains equipment typical consumption figures: fridge .............................................. 0.5 amps colour tv ....................... 2.5 amps charger ........................................... 1.0 amps microwave ....................... 10 amps water heat...

  • Page 42: Caravan Service Systems

    3-15 caravan service systems 3 3.4.1 12-volt control panel the system is fitted with an automatic relay to select the power source. When the car is connected via lead the car power will be used. When the car is not connected the battery and or the power supply will be used to power the caravan. The ...

  • Page 43: Caravan Service Systems

    3-16 3 caravan service systems ▲ switch off all appliances before disconnecting battery. ▲ negative connections should always be disconnected first and reconnected last. ▲ car type battery chargers are not suitable for charging a leisure battery and may damage it. When storing the caravan for long p...

  • Page 44: Caravan Equipment

    4-1 caravan equipment 4 4.1 the truma ultrastore water heater operating instructions 4.1.1 filling the truma ultrastore with water ● check that the safety/drain valve in the cold water intake is closed. The yellow lever should be in the horizontal position, position (e). ● open the hot tap in bathro...

  • Page 45: Caravan Equipment

    4-2 4 caravan equipment 4.1.2 gas operating instructions ▲ never operate the water heater without water in it! ● remove exterior cowl cover. ● open gas cylinder and open quick-acting valve in the gas supply line. ● select required water temperature at rotary knob (a) infinitely variable from approx....

  • Page 46: Caravan Equipment

    4-3 caravan equipment 4 4.1.4 electrical operating instructions (230v) ensure that the water heater is full then switch the isolation switch on. (usually mounted on the bunk face adjacent to the gas control switch.) ▲ the water temperature cannot be selected, temperature is automatically limited to ...

  • Page 47: Caravan Equipment

    4-4 4 caravan equipment 4.1.7 important operating notes: ● if the cowl is positioned close to an opening hatch (window), keep this closed during operation . See warning plate. Always mount the cowl cover if the heater is not being used. Nonobservation of this point can lead to the function of the ap...

  • Page 48: Caravan Equipment

    4-5 caravan equipment 4 4.1.9 technical data water contents: .................................... 10 litres water pressure: ................... Up to max. 2.8 bar type of gas: .... Liquid gas (propane or butane) operating pressure: .............................. 30mbar (or 28mbar butane, 37mbar prop...

  • Page 49: Caravan Equipment

    4-6 4 caravan equipment 4.2 the truma s 3002 el space heater 4.2.1 gas operation switching on ● turn on gas cylinder. ● for space heaters fitted with manual piezo ignition (discovery and ranger) turn control knob to thermostat setting 1-10 and press it down as far as the stop. At the same time keep ...

  • Page 50: Caravan Equipment

    4-7 caravan equipment 4 ● any alteration to the appliance (including exhaust duct and cowl) or the use of spare parts and accessories which are important to the function of the heater and which are not original truma parts, as well as the non-observance of the installation and operating instructions...

  • Page 51: Caravan Equipment

    4-8 4 caravan equipment ● do not operate appliance when refuelling the vehicle and when in the garage. ● always connect the pressure regulator to the gas cylinder with great care. Inspect the regulator connection hoses regularly for signs of weakness. Caravanning gas cylinders must always be upright...

  • Page 52: Caravan Equipment

    4-9 caravan equipment 4 ▲ any alteration to the appliance (including exhaust duct and cowl) or the use of spare parts and accessories which are important to the function of the heater and which are not original truma parts, as well as the non-observance of the installation and operating instructions...

  • Page 53: Caravan Equipment

    4-10 4 caravan equipment greater heat requirement. This means that the air output can be used to the full on this side. By adjusting the air flap (fig. 1:d) the quantity of air can be increased individually. This means that the air output on the other side is reduced. ▲ if the air output drops or th...

  • Page 54: Caravan Equipment

    4-11 caravan equipment 4 4.4 the country leisure cooking appliances operating instructions ensure the gas cylinder is turned on. In the event of a gas smell turn off at the cylinder and contact supplier. The use of a gas cooking appliance results in the production of heat and moisture in the room in...

  • Page 55: Caravan Equipment

    4-12 4 caravan equipment 4.6 the midi oven & grill (ranger, pageant & senator) 4.6.1 grill ▲ accessible parts may be hot when the grill is used! Young children should be kept away. ▲ the heater deflector below the fascia should be pulled out prior to grill operation. ▲ whilst the grill is operating ...

  • Page 56: Caravan Equipment

    4-13 caravan equipment 4 4.6.2 oven 1. Ensure the gas cylinder is connected and turned on. In the event of a gas smell turn off at gas cylinder and contact supplier. 2. Remove all accessories and packing that may be in the oven and clean the interior before using it for the first time. Use warm soap...

  • Page 57: Caravan Equipment

    4-14 4 caravan equipment 4.6.4 temperature control the temperature control in the oven is controlled by a thermostatic gas tap and is variable over the range 130 °c to 240°c. Approximate temperatures for the settings on the control knob are shown in the table below. The temperatures indicated refer ...

  • Page 58: Caravan Equipment

    4-15 caravan equipment 4 most cookery books give details of the shelf positions and gas mark settings for each recipe. If in doubt about a recipe you intend to use, study the recipe carefully then find a similar dish in our guide and use our shelf position and gas mark setting recommendation. Shelf ...

  • Page 59: Caravan Equipment

    4-16 4 caravan equipment 4.7 the fire sentry smoke alarm the smoke alarm is operational once the battery is connected. When products of combustion are sensed, the unit sounds a loud pulsating alarm until the air is cleared. 4.7.1 false alarms ‘hush’ control units with the ‘hush’ feature have the cap...

  • Page 60: Caravan Equipment

    4-17 caravan equipment 4 4.8 refrigerators winter operation - thetford and dometic refrigerators ▲ please check that the ventilation grilles or the flue outlets are not blocked by snow, leaves etc. Your caravan is supplied with winter covers as standard equipment. These covers should be fitted when ...

  • Page 61: Caravan Equipment

    4-18 4 caravan equipment 4.9.3 energy selection 12v electrical operation (dc) ▲ the refrigerator should only be used while the motor is running, otherwise the on-board battery would be discharged within a few hours! Mains power this option should only be selected where the supply voltage of the conn...

  • Page 62: Caravan Equipment

    4-19 caravan equipment 4 3. Set energy selector switch (a) to gas. 4. Press and hold rotary switch (b). 5. Activate ignition by pressing the button (c) and keep it depressed. 6. Check the inspection glass to see whether there is a flame (the inspection glass is inside the refrigerator at the bottom ...

  • Page 63: Caravan Equipment

    4-20 4 caravan equipment 4.9.4 temperature setting cooling compartment as already shown, with rotary knob (b) the temperature in the cooling compartment can be regulated as necessary. ▲ the cooling unit’s performance is influenced by ambient temperatures. At ambient temperatures of +15 deg c up to +...

  • Page 64: Caravan Equipment

    4-21 caravan equipment 4 4.10 dometic refrigerator model rm 8550l (pageant & senator) 4.10.1 cleaning before starting up the refrigerator, it is recommended to clean it inside and repeat this at regular intervals. Use a soft cloth and lukewarm water with a mild detergent. Then wipe out the appliance...

  • Page 65: Caravan Equipment

    4-22 4 caravan equipment explanation: the refrigerator is equipped to operate on mains power, 12v dc or liquid gas. Select the desired power supply by turning the energy selector switch a. The energy selector switch a has four settings: off, ac mains voltage, dc (battery), gas (liquid gas). 4.10.4 e...

  • Page 66: Caravan Equipment

    4-23 caravan equipment 4 prior to starting the refrigerator in gas mode: ● open the gas cylinder valve. ● open the shut-off valve for gas supply to the refrigerator. Appliances with battery igniter: ▲ each refrigerator with manual ignition is equipped with an automatic flame safety valve which inter...

  • Page 67: Caravan Equipment

    4-24 4 caravan equipment if the vehicle is parked for a longer period of time, the locking hook may be clamped by means of a lockbar. The door may now be opened by just pulling it without need of pressing the locking button. Restore the original position by pushing the hook down. Fixing and releasin...

  • Page 68: Caravan Equipment

    4-25 caravan equipment 4 4.10.9 exchange of the igniter’s battery 4.10.10 shutting off the refrigerator 4.10.11 lighting unlock the battery by depressing and turning the button (c) approximately 90 degrees clockwise. Remove cap and exchange battery (1.5v aaa / r3 / micro). Observe correct polarity. ...

  • Page 69: Caravan Equipment

    4-26 4 caravan equipment 4.10.12 troubleshooting before notifying the authorised service centre, please check whether: ▲ the instructions in the section “operating the refrigerator” have been followed. ▲ the refrigerator is level. ▲ it is possible to operate the refrigerator with any available power...

  • Page 70: Caravan Equipment

    4-27 caravan equipment 4 14.101.13 maintenance ● works on gas components and electrical installation may only be carried out by authorised personnel. We recommend to contact your dometic service centre. ● en 1949 stipulates that the appliance’s gas equipment and its associated fume system must be in...

  • Page 71: Caravan Equipment

    4-28 4 caravan equipment 4.11 thetford refrigerator model n97 (ranger) 4.11.1 switching on the refrigerator ● clean the inside of the refrigerator before you switch it on. ● let the refrigerator cool for at least eight hours before you place food in it for the first time. ● the freezer compartment s...

  • Page 72: Caravan Equipment

    4-29 caravan equipment 4 open the valve of the gas bottle and the gas taps. Set the gas control button to the maximum position. Set the energy source selector switch (a) to ignite the gas flame. 4.11.4 power with gas 1 open the valve of the gas bottle and the gas taps. 2 set the thermostat button (b...

  • Page 73: Caravan Equipment

    4-30 4 caravan equipment 4.11.7 door locking mechanism the refrigerator door has an automatic locking mechanism. The door locks automatically when you press it shut firmly. The lock releases unnoticed when you open the refrigerator with your hand. This automatic locking mechanism also keeps the refr...

  • Page 74: Caravan Equipment

    4-31 caravan equipment 4 4.12 the thetford cassette c-200 cw / cwe (discovery & ranger) the unit consists of two sections, a permanently installed toilet system and a slide out waste holding tank. The toilet section of the c-200 cw includes a rotatable bowl, removable seat and cover, a console with ...

  • Page 75: Caravan Equipment

    4-32 4 caravan equipment 1 2 3 4 5 6 7 8 9 10 12 13 14 15 11.

  • Page 76: Caravan Equipment

    4-33 caravan equipment 4 vii. Open the water fill door and add 50ml. Of aqua rinse. This results in a better flush and improves the hygiene of the toilet. Then fill the tank with fresh water using a jerry can or hose. Tank capacity is 7 litres (fig.7). 4.12.2 operation viii. Turn the bowl into most ...

  • Page 77: Caravan Equipment

    4-34 4 caravan equipment and cover and the outside of the toilet. When the toilet is not going to be used for a long time, leave the cap off the pour-out spout and leave the blade open so the cassette can dry. ▲ never use household cleaners (bleach, solvents or other powerful cleaning agents). These...

  • Page 78: Caravan Equipment

    4-35 caravan equipment 4 4.13 the thetford cassette c-250 (pageant & senator) 4.13.1 introduction the thetford cassette toilet is a high quality product. The toilet forms an integral part of your caravan or camper bathroom, thanks to its functional design which combines modern styling and ease of us...

  • Page 79: Caravan Equipment

    4-36 4 caravan equipment control panel (with optional features) standard c250 optional features c250

  • Page 80: Caravan Equipment

    4-37 caravan equipment 4 4.13.2 preparing for use (standard) 1. Open the access door on the outside of your caravan or camper. 2. Remove the waste holding tank by pulling the safety catch (which holds the tank in place) upwards. 3. Pull the waste holding tank outward to the stop. Tip it slightly and...

  • Page 81: Caravan Equipment

    4-38 4 caravan equipment pressing the flush button for several seconds (if necessary re-activate the control panel). Close the blade after use. ▲ if your toilet has its own flush-water tank, please make sure that you do not travel with a flush-water tank that is too full. Do not travel with water in...

  • Page 82: Caravan Equipment

    4-39 caravan equipment 4 20. Waste pump-out system: when activating the control panel this feature automatically lights up. When the waste holding tank level indicator illuminates, press the waste pump-out button to pump out the waste from the holding tank into the vehicle’s waste tank. The button w...

  • Page 83: Caravan Equipment

    4-40 4 caravan equipment the rubber seals in the toilet (the lip seal, the mechanism seal, the automatic pressure release vent seal and the cap seal) should be regularly cleaned with water and treated with thetford high grade seal lubricant. This will ensure that the seals remain flexible and in goo...

  • Page 84: Caravan Equipment

    4-41 caravan equipment 4 4.14 al-ko secure ● align the wheel so that the receiver can be seen in the centre of the rim opening. Do not use the rim opening in which the tyre valve is fitted (fig 1). ● unscrew the plastic cap from the receiver and store in the tool kit box. (when al-ko secure is not i...

  • Page 85: Caravan Equipment

    4-42 4 caravan equipment 4.15 al-ko atc trailer control system al-ko atc is an electronic, emergency braking system for caravans and trailers. It automatically recognises critical swinging motions and applies the caravan brakes accordingly to regain control of the car and caravan. ▲ al-ko atc is a p...

  • Page 86: Caravan Equipment

    4-43 caravan equipment 4 4.16 omnivent rooflight mounted extraction fan (pageant & senator only) 4.16.1 use ventilator (only for omnivent 12v) the ventilator is started by the switch marked (extraction or intake) the airflow is adjusted by the black switch: position 1 = 7m 3 /min. (245 cft/min.) (10...

  • Page 87: Caravan Equipment

    4-44 4 caravan equipment 4.17 the alko caravan chassis 4.17.1 chassis members the recommended tow vehicle coupling height is 415 +/- 35mm from the ground to the centre of the ball. Manufactured from high quality steel, the chassis has extra deep sections to provide strength at points of maximum stre...

  • Page 88: Caravan Equipment

    4-45 caravan equipment 4 4.17.5 operation : type ak 160 & ak 300 coupling head lift locking trigger and lift handle upward and forward. Place the unlocked coupling onto the towing ball and with the slightest downward pressure it will lock onto the ball automatically. Ensure locking trigger returns t...

  • Page 89: Caravan Equipment

    4-46 4 caravan equipment fig 4 fig 5 fig 3 fig 2 4.17.11 stabiliser unit: 2) to operate the stabiliser (once coupled to the towball), simple press the stabiliser lever down as far as it will go (fig. 4/item 2). 4.17.12 uncoupling 1) pull the stabiliser lever handle up as far as it will go, open the ...

  • Page 90: Caravan Equipment

    4-47 caravan equipment 4 fig 6 fig 7 down by hand force only do not use your foot or an extension bar, this will damage the components (fig. 6). 3) when opening or closing the stabiliser lever, please ensure your hand does not touch the coupling handle - you may accidentally trap your fingers! (fig....

  • Page 91: Caravan Equipment

    4-48 4 caravan equipment fig. 9 fig. 8 4.17.20 jockey wheel lubricate wheel and screw thread periodically with grease. 4.17.21 brake linkage all moving parts should be lubricated periodically to ensure their satisfactory operation. 4.17.22 corner steadies the screw and pivot pins should be lubricate...

  • Page 92: Caravan Equipment

    4-49 caravan equipment 4 fig. 10 xi. Check the brake rod support bracket, (fixed to the floor) is supporting the brake rod evenly. The brake rod must always run straight, never bent or curved under any fittings. On tandem axles, using the double balance bar, a brake rod support tube (part no. 228827...

  • Page 93: Caravan Equipment

    4-50 4 caravan equipment ▲ in order to operate the al-ko braking system correctly adequate traction of caravan wheels is required when reversing. Therefore surface conditions that would result in a lack of traction should be avoided. Example: peas, shingle/loose gravel. ▲ care should be taken when t...

  • Page 94: Caravan Equipment

    4-51 caravan equipment 4 4.19 heki 2 rooflight operating instructions ▲ before commencing any journey always ensure that the heki 2 rooflight is fully closed and both handles are securely fastened. 4.19.1 to open in the tilted position a) press the knob in the toggle catches on either side of the gl...

  • Page 95: Caravan Equipment

    4-52 4 caravan equipment 4.19.5 opening the blinds a) move blind (end rod with rocker) right to the outside. B) hold the recessed grip with one hand; with the other hand, press the rocker and move the blind back (do not let it recoil). ▲ do not stand on the acrylic glass dome. ▲ close heki 2 complet...

  • Page 96: Caravan Equipment

    4-53 caravan equipment 4 4.21 discovery, ranger & pageant combination window blinds operation and care the cassette contains a sun screen and a fly screen blind. The fly screen is operated by gently pulling down the handle nearest the window. It is designed to be either fully up or fully down. Push ...

  • Page 97: Caravan Equipment

    4-54 4 caravan equipment 4.22 tracker monitor operating instructions tracker monitor for caravans is armed and disarmed by an alarm. Triggering the alarm siren does not generate an alert from the tracker monitor unit. 4.22.1 to arm to arm the tracker monitor system, press the button on the remote co...

  • Page 98: Caravan Equipment

    4-55 caravan equipment 4 4.23 status 315 omni-directional television & fm radio antenna (ranger only) 4.23.1 travelling ▲ do not travel when using the suction pad facility. 4.23.2 operating the system 1. Switch on the power pack and the red led will illuminate. 2. Check the gain control switch is se...

  • Page 99: Caravan Equipment

    4-56 4 caravan equipment 4.23.5 fault finding the following are some of the key areas we suggest you check which generally solve the most common problems encountered with the operation of the status antenna. Coaxial plugs it is critical that all coaxial plugs in the system are fitted correctly. Plea...

  • Page 100: Caravan Equipment

    4-57 caravan equipment 4 4.24 status 530 directional television & fm radio antenna (pageant & senator) 4.24.1 travelling do not travel: with the antenna raised. With the antenna set for vertical signals. With the telescopics extended. When travelling adjust the antenna so that it points to the rear ...

  • Page 101: Caravan Equipment

    4-58 4 caravan equipment 4.24.4 fault finding the following are some of the key areas we suggest you check which generally solve the most common problems encountered with the operation of the status antenna. Coaxial plugs it is critical that all coaxial plugs in the system are fitted correctly. Plea...

  • Page 102: Caravan Equipment

    4-59 caravan equipment 4 4.25 daewoo microwave oven 4.25.1 precautions to avoid possible exposure to excessive microwave energy ▲ do not attempt to operate this oven with the door open since open-door operation can result in harmful exposure to microwave energy. It is important not to defeat or tamp...

  • Page 103: Caravan Equipment

    4-60 4 caravan equipment 6. Microwave energy will be turned off automatically when the timer reaches “off”. Then food can be taken out of the oven. • to prevent the oven from operating with the door open, your microwave oven is fitted with safety door interlock switches. • if you wish to inspect the...

  • Page 104: Caravan Equipment

    4-61 caravan equipment 4 4.25.4 cooking techniques stirring stir foods such as casseroles and vegetables while cooking to distribute heat evenly. Food at the outside of the dish absorbs more energy and heats more quickly, so stir from the outside to the center. The oven will turn off when you open t...

  • Page 105: Caravan Equipment

    4-62 4 caravan equipment 5. Plastic - most heat resistant plastic dinnerware may be used for heating food. However polyethylene, melamine, phenol are unsuitable for use in the oven. They become hot in the microwave. 6. Wax paper - use as a cover to avoid spatters. 4.25.6 care and cleaning although y...

  • Page 106: Caravan Equipment

    4-63 caravan equipment 4 q: why do i have moisture in my microwave oven after cooking? A: the moisture on the side of your microwave oven is normal. It is caused by steam from cooking food hitting the cool oven surface. Q: does microwave energy pass through the viewing screen in the door? A: no. The...

  • Page 107: Caravan Equipment

    4-64 4 caravan equipment.

  • Page 108: General

    5-1 general 5 5.1 general maintenance 5.1.1 exterior the exterior of your caravan is very durable and easy to clean owing to its high gloss properties. To maintain a showroom finish one needs only to wash the caravan regularly with a car shampoo, rinse with cold water and chamois leather off. Do not...

  • Page 109: General

    5-2 5 general 5.1.3 window catches and stays turn catch arm to the vertical position to open. A night vent position is available by locking the catch into the outer catchplate slot. The windows are held open by an adjuster knob, tightening off the knob in a clockwise direction will hold the window o...

  • Page 110: General

    5-3 general 5 5.1.7 hinges and catches lightly oil occasionally. Carpets vacuum periodically to remove grit and to ensure long life. 5.1.8 free standing table ● maximum load on the table is 50kg. ▲ do not at any time sit or stand on the table. 5.1.9 kitchen chopping board care and usage of your hard...

  • Page 111: General

    5-4 5 general 5.1.12 for containers 1. All water remaining in the container should be disposed of so that the container is empty. (if the container is an onboard tank, it should be removed if possible.) 2. The outside of the container should be thoroughly cleansed and washed down to remove any dirt,...

  • Page 112: General

    5-5 general 5 5.2 fire and safety precautions ▲ your attention is drawn to the notice affixed in the caravan advising on fire prevention, ventilation and what to do in case of fire. Ensure that the occupants are familiar with escape routes, in case of a fire. 5.2.1 children ▲ do not leave children a...

  • Page 113: General

    5-6 5 general 5.2.6 original equipment appliances see sections devoted to individual appliances. ▲ replacement parts for any appliance shall conform to the appliance manufacturer’s specification; and should be fitted by them or an authorised agent. 5.2.7 portable appliances ▲ never use portable cook...

  • Page 114: General

    5-7 general 5 2 1 5 4 3 6 5.3 assembling the bunks.

  • Page 115: General

    5-8 5 general fig. 2 fig. 1 5.3.1 lift up bunk i. Remove cushions and draw the curtains and close the blind if fitted. Ii/iii. Holding bunk in both hands pull it inwards whilst lifting upwards. Iv. The bunk mechanism will automatically lock in the up position. V. Release retaining straps on the unde...

  • Page 116: General

    5-9 general 5 5.4 water system - fault finding 5.4.1 fault - water not flowing from any tap when operated but pump runs cause cure freshwater tank empty check pump wired in reverse check wiring, refer to pump manufacturers’ instructions pump not primed refer to pump manufacturers’ instructions pipe ...

  • Page 117: General

    5-10 5 general 5.4.4 fault - water flows from hot tap but has reduced flow from cold cause cure cold water pipe kinked preventing flow check and re-route if necessary blockage in cold pipe line disconnect pipes after 1st y connector and check up to tap cold tap not connected refer to installation in...

  • Page 118: General

    5-11 general 5 5.4.8 fault - water heater difficult to drain cause cure hot taps not open preventing air entering open taps hot system to let water out. Air bleed pipe kinked or blocked. Unkink or unblock pipe..

  • Page 119: General

    5-12 5 general 5.5 room heater - fault finding 5.5.1 fault - heater will not light symptoms cause cure spark visible no gas. Bottle temperature too low check bottle and taps. See gas supply notes. Regulator malfunction. See gas supply notes. Overgassed. Refer to lighting instructions. Turn off. Wait...

  • Page 120: General

    5-13 general 5 5.6 brake fault finding chart - al-ko 5.6.1 fault - braking is one-sided cause cure incorrect adjustment at wheel. Adjust as described. Brake cable seized. Free off cable or replace. Brake lining contaminated with grease. Replace brake shoe assemblies. 5.6.2 fault - the trailer brakes...

  • Page 121: General

    5-14 5 general 5.6.6 fault - trailer brakes inoperative cause cure brakes underadjusted. Check action and rectify. Lining contamination. Replace brake shoe assemblies. Seized cables. Free off or replace. Linings worn out. Replace brake shoe assemblies. 5.6.7 fault - hot brakes cause cure brakes over...

  • Page 122: General

    5-15 general 5 to disarm the tracker monitor system press the button on the remote control once. The siren will beep once and the tracker monitor will be disarmed. If already sounding the siren will be silenced. Q i have been pushing my caravan around the car park and the alarm has not gone off? A p...

  • Page 123: General

    5-16 5 general q how long will the tracker system work if the caravan is not connected to a mains supply? A please see above question. Q how do i know if my tracker battery is fully charged? A your tracker battery will be fully charged as long as you have not had a flat leisure battery and you at re...

  • Page 124: General

    5-17 general 5 a you need to go to your dealer to purchase a replacement remote. He will de-program your old remote from the alarm then it will never work and at the same time re-program the alarm to the replacement remote q i only have one radio remote. Can i obtain more? A yes, your dealer will be...

  • Page 125: Index

    6-2 6 index.

  • Page 126: Index

    6-1 index 6 a antenna status 315 .................................................... 4-55 status 530 .................................................... 4-57 b blinds, window ................................................. 4-52 braking system ................................................ 4-42...

  • Page 127: Www.Bailey-Caravans.Co.Uk

    Bailey caravans, south liberty lane, bristol bs3 2ss www.Bailey-caravans.Co.Uk.