1. DL manuals
  2. Bailey
  3. Motorhomes
  4. Pegasus GT65
  5. Owner's Manual

Bailey Pegasus GT65 Owner's Manual

Other manuals for Pegasus GT65: Service Manual, Service Manual, Owner's Manual, Owner's Manual
Manual is about: Bailey Caravans Owner's manual

Summary of Pegasus GT65

  • Page 1

    Alu-tech bodyshell.

  • Page 2

    C m y cm my cy cmy k tyrepal a5 advert v2 opt 3 awk_v2.Pdf 1 19/09/2014 11:09.

  • Page 4

    * price valid until 14 december 2014. A joining fee of £10 applies – this fee is waived if you choose to pay by direct debit. There’s no better value in touring discover our many sites on historic estates like longleat the caravan club save £10 a night on pitch fees fantastic ferry fares free glossy...

  • Page 5

    * price valid until 14 december 2014. A joining fee of £10 applies – this fee is waived if you choose to pay by direct debit. There’s no better value in touring discover our many sites on historic estates like longleat the caravan club save £10 a night on pitch fees fantastic ferry fares free glossy...

  • Page 6: Www.Haynes.Co.Uk

    Books for enthusiasts by enthusiasts www.Haynes.Co.Uk available from all good bookshops or order direct on tel: 01963 442030 the motorcaravan manual (3rd edition) isbn: 978 0 85733 124 3 £21.99 build your own motorcaravan (2rd edition) isbn: 978 0 85733 281 3 £21.99 the caravan manual isbn: 978 1 84...

  • Page 7

    Contents 1. Introduction 1 •drivinglicences 2 2. Statement of conformity 2 3. Warranty 3 •touringcaravanwarrantycover 3 •6yearbodyshellintegrityguarantee 3 •warrantyextension 3 •3yearmanufacturer’swarranty 3 •warrantyextension 4 •customersupport 4 •termsandconditions 4 •cover 4 •term 4 •repairs 4 •r...

  • Page 8

    •couplinghead 25 •brakedrum/hubassembly 25 •operatinginstructions 26 •coupling 26 •stabiliserunit 26 •uncoupling 26 •uncoupling 26 •manoeuvringoperation 27 •noiseswhiledriving 27 •remedialaction 27 •storing 28 •towingball 28 •overrunningdevice 28 •jockeywheel 28 •brakelinkage 28 •cornersteadies 28 •...

  • Page 9

    The pursuit control panel 57 20. Unicorn solar dual battery charger sdc 10/20 58 •function 58 •chargingprocess 58 •bulkphase 58 •absorptionphase 59 •floatphase 59 •equalisationchargingphase 59 •parallelmode 59 •settings; 59 •operation 59 •batterytype 59 •chargingcurrentdistribution 59 •pwmchargingfr...

  • Page 10

    21. Exterior features 91 grp 91 rooflights 91 heki rooflights 91 •safetyinstructions: 92 •careinstructions: 92 mpk rooflight 92 22. Cooking equipment 93 thecapricecooker 93 •operation 93 •usingthehotplategasburners 93 •usingtheelectrichotplate 94 •usingthegrill 94 •usingtheoven 95 •oventemperatureco...

  • Page 11

    25. Stainless steel sink 125 26. Smoke alarm 125 •features 125 •simplemaintenance 125 27. Carbon monoxide alarm 126 •features 126 •testing 126 •testingthesensor 126 •maintaining/testingyourdetector 127 28. Bathroom care 128 •bathroomshowertap 128 •mirrors 128 29. Thetford c262 toilet 129 •parts 129 ...

  • Page 12

    ©bailey of bristol 2014. All rights reserved no part of this document may be reproduced or transmitted in any form or by any means, electronicormechanical,foranypurpose,withouttheexpresspermissionofbaileyofbristol ltd..

  • Page 13

    1 intr oduc tion 1. Introduction welcome! Congratulations on the purchase of your bailey caravan. We would like to welcome you into the ranks of bailey owners. We are confidentthatthisvehiclewillgiveyoumany yearsofenjoyment. This handbook has been designed to enable you to derive the maximum benefit...

  • Page 14

    2. Statement of conformity all bailey caravans have been certified by the national caravan council for compliance with uk and european standards and legislation along with industry codesofpracticerelatingtohealthandsafety issues. The approval process covers the testingandinspectionofcriticalareasoft...

  • Page 15

    3 w arr anty 3. Warranty if you have a problem or enquiry relating to yourcaravanpleasefollowthesesteps: checkthehandbooks. Contactyoursupplyingretailerforassistance. The following suppliers provide a direct aftersales service. Please contact them directly: al-ko al-kokoberlimited southwarwickshireb...

  • Page 16

    4 w arr anty inbrakedrumsandshoesthatarecaused through misuse of the braking system or fromnormalwearandtear) •runninggear:roadwheels(excludingtyres) •towing mechanism: all mechanical components fitted to vehicle (excluding electrics). •cooker:thecookerunitincludingburners, grill,oven,flamefailurede...

  • Page 17

    5 w arr anty repairs must be carried out by either bailey itselforanapprovedbaileyservicecentreor agent.Thereafter,duetothetechnicalnature of an alu-tech constructed caravan, annual inspectionsandrepairsmaybecarriedoutby anyworkshoporrepaircentreapprovedbythe national caravan council that has attend...

  • Page 18

    6 w arr anty and re gis tr a tion compensation howsoever arising which was not reasonably foreseeable by both parties when the caravan was originally purchased. Baileywillnotbeliableforanylossordamage sufferedbythirdparties,norforbodilyinjury notcausedbyournegligence. Nothinginthiswarrantyshalllimit...

  • Page 19

    7 cris s re gis tr a tions detailsrecordedareincorrect,pleasecontact: cris registrations: forhelp,supportandadvicecontactcris: ncc crisltd, pobox445, aldershot, gu119sf. Tel+44(0)2032821000 openinghours: mondaytofriday8amto8pm saturday9amto5pm sunday10amto5pm.

  • Page 20

    8 heal th and s afety c onsider a tions 5. Country and coastal code uponarrivalatyourdestinationyoushouldbe awareofthecountrycode. Code of conduct – camp sites checkthesiteregulations. Arrivals reporttoreceptionimmediatelyonarrival. Vehicle movement keeptoroadwaysunlessotherwisedirected. Adhere to s...

  • Page 21

    9 c ountr y and c o a s tal c ode departure: leavethepitchcleanandtidy. On leaving check out with reception, paying therequireddues. Onnoaccountshould: •litter be disposed of other than in the receptaclesprovided. •water be allowed to escape from the vehicle. •chemicaltoiletsbeemptiedexceptintothe d...

  • Page 22

    10 c ountr y and c o a s tal c ode children neverleavechildrenaloneinthecaravanand keeppotentiallydangerousitemsoutofreach asathome,e.G.Matches,drugsetc. ! Whenupperbunksareusedby children,especiallythoseunderthe ageofsix(6),careshouldbetakento ensureagainsttheriskofthemfalling out.Thesebunksarenots...

  • Page 23

    11 c ar a v an and t o w vehicle 6. Caravan and tow vehicle choosing the right car and caravan combinationforsafeandstabletowingisboth anartandascience.Itmayseemcomplicated to the newcomer, but a few minutes spent understanding the basic principles, common termsanddefinitionsinusewillbeworthwhile in...

  • Page 24

    12 c ar a v an and t o w vehicle when taking the measurement the jockey wheelshouldberaisedandthecornersteadies lowereduntiltheyarejustclearoftheground. Kerbweight:theweightofthetowingvehicle asdefinedbythevehiclemanufacturer. Thisisnormally: •withafulltankoffuel •with an adequate supply of other li...

  • Page 25

    13 c ar a v an and t o w vehicle having done this, the cable assembly is designedtopart,allowingthetrailertocome toahaltawayfromthetowingvehicle. Construction;athinsteelcable,coatedinred plasticandfittedwithameansofattachment forconnectiontothetowingvehicle. Operation;intheeventofthemaincouplingof t...

  • Page 26

    14 c ar a v an and t o w vehicle nose weight itisrecommendedthatthenoseweightshould be varied to find the optimum for towing dependent upon the actual laden weight of the caravan. Experience has shown that the nose weight should be approximately 7% of the actual laden weight (i.E. Between 50 and 100...

  • Page 27

    15 c ar a v an and t o w vehicle hitching the caravan to the tow vehicle 1. Ensure that the caravan is in a suitable position, and secure with the handbrake fullyon. 2. Fullyraiseallfourcornersteadies. 3. Shutandlockthecaravanexterior. 4. Gaugetheheightofthecar’stowballthen raiseorlowertheheightofth...

  • Page 28

    16 c ar a v an and t o w vehicle 7. Towing speed limits where a lower limit is not in force, caravans maybetowedatuptoamaximumof50mph on single carriageways or 60 mph on dual carriagewaysandmotorways. Pulling away allowmoreenginespeedtoproducethepower tomovetheadditionalweightofthecaravan. Lettheclu...

  • Page 29

    17 c ar a v an and t o w vehicle holesshouldnotbedrilledineither thecouplingheador‘“a”frame memberswithoutpriorconsultation withthechassismanufacturer. Ifyoudofindyouroutfitsnaking,trytokeep the steering wheel in a central position as far as possible, slow down gently and avoid brakingifpossible. Ro...

  • Page 30: Remely Superior!

    18 e xt remely superior! The new truma mover xt has been developed using years of experience and expertise by the leading manufacturer of caravan mover systems. • up to 20 kg weight saving over competitor systems • revolutionary design. Xt is the first mover to use high efficiency brushless dc motor...

  • Page 31

    19 unhit ching 9. Unhitching donotpitchinapositioninwhichyouroutfit willobstructotherpeople. Trytochooseanareathatisdry,reasonably levelandpreferablywithahardbase. If you have no alternative but to pitch on a slopeensurethat,forwhenyouleave,youare facingdowntheslope. Itisgoodpracticetochockthewheels...

  • Page 32

    20 levelling the caravan levelling must be carried out in both directions in order for the refrigerator and otherequipmenttofunctioncorrectly. The positioning of the jockey wheel can be usedtohelplevelthecaravan. Lower the corner steadies until they are in firmcontactwiththeground. Undernocircumstan...

  • Page 33

    21 wheels and tyre s 10. Wheels and tyres unicorn and pegasus wheel,tyreandboltsafetyfitmentbywheel solutionsltd. Wslindividuallylaserbalanced,tuvtested styled alloy wheels fitted with michelin tyres andantitamperwslsafetybolts. Pursuit wheel, tyre and bolt safety fitment by wheel solutions ltd wsl ...

  • Page 34

    22 wheels and tyre s wheels caravan wheel bolts must always only be tightened to the appropriate setting by tightening each opposite fixing in succession tothecorrecttorque.Alwaysuseacalibrated torque wrench. Do not use a corner steady brace, power or electric wrench. It is as dangerous to over-tigh...

  • Page 35

    23 11. Spare wheel carrier unicorn and pegasus models thesparewheelcarrierfittedinyourleisure homeismuchlikethatfittedintoyourcar. To lower the spare wheel: 1. Removetheplasticstopperinthefloor 2. The winder for the spare wheel carrier canbefoundinthekitbagsuppliedwith thevehicle. 3. Removethewinder...

  • Page 36

    24 sp are wheel c arrier severaltimes. 4. Position the wheel so that it is not obstructed by components under the floor. 5. Continue to raise the wheel by turning the crank clockwise. Raise the wheel a littlebitatatimeandguideituntilitis securelyseatedagainstthefloor. 6. When it is no longer possibl...

  • Page 37

    25 al -k o cha s sis 12. The al-ko caravan chassis (aks 3004) chassis members therecommendedtowvehiclecouplingheight is 385mm +/- 35mm from the ground to the centreoftheball. Offroadvehiclesareexemptfrom thistowballheightspecification. Manufactured from high quality steel, the chassis has extra deep...

  • Page 38

    26 al -k o cha s sis fig. 1. Operating instructions couplinghandleandstabilisinglever. Thestabiliserlever(fig.3/item2)mustbein theuppermostposition(open). Coupling pull the coupling handle (fig. 2/item 1) up in the direction of the arrow. The coupling mechanism has an open position, i.E. As long as ...

  • Page 39

    27 al -k o cha s sis fig.5. Checking the efficiency of the left/right frictionpads: 1. Check that the stabiliser is correctly coupledbyensuringthecouplinghandle isfullydownandtheredindicatorbutton isintheraisedposition. 2. Push the stabiliser lever (fig.5/item 1) down until resistance is felt (i.E. ...

  • Page 40

    28 al -k o cha s sis b.Lubricate the draw-shaft sleeve via the greasenipples.Inaddition,pushthegaiter forward and grease (din 51 825 kta 3k) theexposedpartoftheshaft(fig,7). Fig.7. C.Visit a specialist workshop to have the ballholdingareacheckedfordamageand the locking mechanism for function. If nec...

  • Page 41

    29 al -k o cha s sis fig8. V. Always rotating the road wheel in the forward direction–never backwards, adjust thestar-wheelwithasuitablescrewdriver, inthedirectionofthearrowembossedon the backplate until there is resistance in thewheelrotation(fig.8). Vi.Slacken off the star-wheel adjuster until the...

  • Page 42

    30 al -k o cha s sis xvii. Finally,iftheroadwheelshavebeen removed, re-tighten using a calibrated torquewrenchto130nm(onallm12wheel bolts-insequence,i.E.North,south,east, west not clock or anticlockwise.) do not overtightenthisisjustasdangerousasto under-tighten,asthiscandistortthewheel rims.Avoidth...

  • Page 43

    31 al -k o cha s sis soundofthepushrodmovinginsidetheatc canbeheard.Whentheselftestiscomplete, theledwillturngreenorflashinggreento signalthattheatcisactive. If the led does not change to green, then theatcisnotfunctioningcorrectly. Priortocommencinganyjourney,ensurethat the caravan lighting is full...

  • Page 44

    32 tr a cker retrie ve 13. Tracker retrieve the tracker retrieve is fitted to unicorn modelsonly. Batterypoweredtrackerretrieveisaself contained device with its own power source, sotheunitdoesn’tneedtobewiredintothe vehicle’selectricalsystem.Thismakesitmore versatileintermsofboththerangeofvehicles i...

  • Page 45

    33.

  • Page 46

    34 the w a ter s y s tem 14a. The unicorn iii single axles and pegasus gt65 water system water supply these models are supplied with a 12v submersible pump, controlled by a pressure switch. The water inlet is located in the off- side exterior wall, protected by a lift up lid. This pump is designed t...

  • Page 47

    35 the w a ter s y s tem tank. •the micro-switch or phosphor bronze contactscanberemovedforinspectionor replacement. •the pressure switch is sensitive to drops in battery voltage. As the voltage falls, shouldtheunitneedadjustment,turnanti- clockwise. Routine maintenance: ensurethehoseadaptoro-ringan...

  • Page 48

    36 the w a ter s y s tem 14b. Unicorn iii twin axle water system water supply this model is supplied with an on-board 40l tankandinbuiltsubmersiblepumpaswellas an external 12v submersible pump controlled byapressureswitch.Theexternalpumpcan beusedtosupplywaterdirectlytothecaravan fromanoutsidewaters...

  • Page 49

    37 the w a ter s y s tem removingtheplug: •switch off the 12v supply at the main controlpanel(pumpisolatorswitch) •pull the plug out of the socket using the handgrip •shutthelid •donotrunthepumpwithoutwater •donotusethepumpinwatertemperatures above40°c(100°f) •itisbesttostandthepumpverticallyinthe t...

  • Page 50

    38 the w a ter s y s tem •donotusethepumpinwatertemperatures above40°c(100°f) •itisbesttostandthepumpverticallyinthe tank. •the micro-switch or phosphor bronze contactsinthesocketcanberemovedfor inspectionorreplacement •the pressure switch is sensitive to drops in battery voltage. As the voltage fal...

  • Page 51

    39 the w a ter s y s tem helpful hints toobtainefficientrunningandmaximumlife, ensurethefollowing: •thereissufficientwaterinthecontainer– donotrunthepumpdry •allhoseconnectionsarefirmandtight •the power supply is adequate, low performance could result from a weak battery water system troubleshooting...

  • Page 52

    40 the w a ter s y s tem adjusting your pressure switch yourpressureswitchisfactorysetandshould not normally require adjustment. However, adjustment may be required if the power supply voltage has varied from the previous setting, either due to battery drainage or higher voltage being supplied when ...

  • Page 53

    41 the w a ter s y s tem 14c. The pursuit water system truma ultraflow operating instructions raisethelid,cleanboththewatersocketand theplugofthepumpassembly. Plugthepumpconnectorintothesocket. Place the pump into the water container, ensuring that it is fully submerged before operating the system. ...

  • Page 54

    42 the g a s s y s tem 15. The gas system allgasappliancesfittedtoyourbaileycaravan aresuitableforoperationonbothbutaneand propanewithouttheneedforadjustment. General information gascylinders:bottledliquefiedpetroleumgas (lpg)isthemostconvenientportablesource offuelforyourcaravan. Cylindersareavaila...

  • Page 55

    43 the g a s s y s tem hoses available for different types of gas/ bottle. They are also available for camping gasandothermainlandeuropelpgsuppliers. Please contact your retailer who will have a stockofthesehoses. ! Someindustriallpgappliances operateathighpressureandrequirea “highpressure’”regulato...

  • Page 56

    44 the ele c tric al s y s tem thereforesinkstothelowestpoint. Keep gas bottle containers outside (and protectedagainstfrost).Iftheymustbekept insidemakesuretheyarewellawayfromheat. Ventilation allventilationcomplieswithen721andvents should not be obstructed in any manner as this could lead to insuf...

  • Page 57

    45 the ele c tric al s y s tem 6. The electrical system-230v asinthehome,caremustbeexercisedwhen handlingmainselectricity. Instructions for electricity supply - low voltage (230 v) on arrival at caravan site ! Beforeconnectingthecaravan installationtothemainssupply: •check that the mains supply is s...

  • Page 58

    46 the ele c tric al s y s tem the only certain way of making equipment safeistounplugit. Ameansofcheckingthepolarityofthemains supplywhenoverseasisuseful. Thereareavailableseveralproprietarymakes ofequipmentforthepurpose(e.G.Martindale testerunit). Ifitcanbeachieved,itispreferabletoconnect livetoli...

  • Page 59

    47 230v mains equipment typical consumption figures: fridge..................................................0.5amps colourtv.............................................2.5amps charger.................................................1.0amps microwave...........................................10.0am...

  • Page 60

    48 the ele c tric al s y s tem ! Switchoffallappliancesbefore disconnectingthebattery. Negativeconnectionsshouldalways bedisconnectedfirstandreconnected last. Cartypebatterychargersarenot suitableforchargingaleisurebattery andmaydamageit. Whennotusingthecaravanalways ensurethatthefridgecontrolknobis...

  • Page 61

    49 the c ontr ol p anels 18. Unicorn iii control panels the control panels in the unicorn iii models consistoftwoseparateswitchingblocks. 12v and pump controls (single axles) 1. 12vmainswitch:0=off,1=on. 2.Led “pump run”: this led is lit (yellow) whenthepumpisactuallyrunning. 3.12vwaterpumpswitch:0=...

  • Page 62

    50 the c ontr ol p anels the pegasus gt65 control panel ivan panel operating instructions fig.1:homescreen fig.2:homescreenfunctions operating the space heater 1. Fromthehomescreen,touchthe“van”icon 2.Thefollowingscreenwillappear: fig.3:spaceheaterfunctions 3.Select the desired heat setting by tappi...

  • Page 63

    51 the c ontr ol p anels operatingthewaterheater 1. Fromthehomescreen,touchthe“tap”icon. 2.Thefollowingscreenwillappear; 3.Selectthedesiredsettingbytouchingone ofthefollowingicons.Theiconwillturnredto showithasbeenactivated. *low electric setting. This uses 750w (3.25a). Unlike the heat boost settin...

  • Page 64

    52 the c ontr ol p anels programming the timer, space heater timer: tosetthetimer,touchthespannericononthe homescreenthentouchroomtimer. Thespaceheatertimermaybeprogrammed upto3timesduringa24-hourperiod. Touchthearrowkeystomovethecursoralong eachofthe3programmabletimes.Usethe+ and-toselecttheonandof...

  • Page 65

    53 the c ontr ol p anels redtoshowthatthetimerfunction(withthe lastprogrammedsettings,forbothspaceand waterheater)hasbeenactivated. Operating the pump the whale watermaster® exterior pump worksonapressurisedsystem.Thismeansit willpumpupthesystemuntilworkingpressure is reached and then switch itself ...

  • Page 66

    54 the c ontr ol p anels make sure there is gas in the bottle and no blockage in the gas line. At temperatures below5°cusepropaneratherthanbutane. Press“retry”oncethechecksarecomplete. Ifthereisaproblemwiththegassupplythat cannot be dealt with immediately, select the electriconlyheatingoptionsinstea...

  • Page 67

    55 the c ontr ol p anels contactwhaleheatersupporton+44(0)845 2172933. Water heater diagnostic screens, checkgassupply make sure there is gas in the bottle and no blockage in the gas line. At temperatures below5°cusepropaneratherthanbutane. Press“retry”oncethechecksarecomplete. Ifthereisaproblemwith...

  • Page 68

    56 the c ontr ol p anels faultonwaterheater contactwhaleheatersupporton+44(0)845 2172933. Winterising the ivan® control panel will not be affected bythecold;however,thereanumberofsteps that must be taken to fully winterise the whale® space and water heaters to avoid frostdamageoccurring. Frost prote...

  • Page 69

    57 the c ontr ol p anels the pursuit control panel thepursuitcontrolpanelisdesignedtosend and receive simple signals to control the caravan. 1. Master switch: the master switch will turn on and off all the habitation power except circuits connected to the permanentsupplyfromthebattery. 2. Lightsswit...

  • Page 70

    58 the s olar p anel 20. Unicorn solar dual battery charger sdc 10/20 thesolarmodulegeneratespowerwhenlight iscastonit.Thefullvoltageisalsoavailable evenifthereislittlelight.Thesolarautomatic chargeronlyservestocharge12v(24v)lead accumulators comprising 6 (12) single cells (e.G. Caravan battery) wit...

  • Page 71

    59 the s olar p anel absorption phase thechargingcurrentiskeptforaperiodof2 hours.Attheendofthisperiod,itchangesto thefloatphase. Float phase the charging voltage is set to 13.8v. The chargingcurrentdropstothevaluenecessary to compensate the self-consumption of the battery. Power is still supplied t...

  • Page 72

    60 the s olar p anel 8 80% 20% 9 90% 10% change •presskey(t)for5secondsuntilthedisplay h6flashes. •pressthekey(t)tosettherequiredvalue. •ifthekeyisnotpressedfor5seconds,the displayed value will be saved and flashing stops. I duringthenormalchargingprocess, thedevicedividesthecharging currentbetweenb...

  • Page 73

    61.

  • Page 74

    62 hea ting s y s tems 20. Heating systems alde heating system ! Alwaysreplacetheheattransferfluid (htf)inaccordancewiththe antifreezeproduct’slifespan.Ifinany doubt,replacethehtfafter2years. The corrosion inhibitors found in ethylene glycolantifreezemaynotbecross-compatible. Whentoppinguporreplacin...

  • Page 75

    63 hea ting s y s tems i inagoodsummer,forexample,lower thedesiredtemperatureonthe controlpaneltoaround10°c.The centralheatingwillnotcirculate (unlessthetemperaturedropsto 10°c),butyouwillstillhavehotwater ! Theboilermustnotbeswitchedonif thereisnoheattransferfluid(htf)in thesystem. • always drain d...

  • Page 76

    64 hea ting s y s tems draining freshwater 1. Switchoffthewaterpump. 2.Openallwatertaps,showers,etc. 3.Open the safety/drain valve by lifting the yellow tab (fig.1 [m]): see page 62, or by turningtheblueknob(fig1.[k])90°. 4.The system will drain directly below the vehiclethroughtheclearplastichoseon...

  • Page 77

    65 hea ting s y s tems objectsintothesystem. Alde recommends using the alde 1900-811 or 839 twin-motor service pump to fill the system. To fill the system by hand, unscrew the expansion tank cap (fig.2 [r]), and lift the circulationpump(fig.2[s])outofthetank(if applicable). Carefully pour the htf in...

  • Page 78

    66 hea ting s y s tems to ensure best performance. There is an automaticairbleedvalveontheboiler.There isalsoanairventontheexpansiontank. Theinstallershouldfitbleedpointselsewhere inthesystem,especiallywherethepipesstep upanddown,andonradiatorsandtowelrails. Air will accumulate at these high points ...

  • Page 79

    67 hea ting s y s tems nb:iftheelectricsupplyhasunstablevoltage, theamperagewillalsofluctuate. I alderecommendsfittingthe3010- 246loadmonitor,allowingyoutoset alimitonthecurrentdrawnbythe vehicleandtheelectricheatingto automaticallyaccommodateit. Lpg lpg (liquefied petroleum gas) has two main varian...

  • Page 80

    68 hea ting s y s tems beabout1cmabovetheminmarkwhencool. Theheattransferfluid(htf)shouldbetopped up if below this level, to prevent a break in circulation.Onlytopupwithcompatiblehtf. Nb:neverleavethesystememptyofhtf. Alwaysreplacethehtfinaccordancewiththe antifreeze product’s lifespan. If in any do...

  • Page 81

    69 hea ting s y s tems troubleshooting the alde control panel will display any error messages.Seetheoperatingandinstallation instructionssuppliedseparately. The system is completely dead, the control panel is blank •check the 20mm t3.15 amp glass fuse in the boiler. This is located under the lid of ...

  • Page 82

    70 hea ting s y s tems warranty aldeundertakestorectifyanymanufacturing defect or early component failure through normal use that occurs within 12 months of theinstallationdate. Ifyouraldeboilerdevelopsafault,yourfirst action should be to contact your dealer or installer, as they will be familiar wi...

  • Page 83

    71 hea ting s y s tems 1. Boththecontrolpanelandboilerareoff. 2.Tostartthesystem,pressthepowerbutton on the control panel. The splash screen is displayedandgreenledislit.Theboilerwill now start with the previously saved settings (factorysettingsbydefault). Thesystemwillnowbedrawingvariable0.2– 1aofc...

  • Page 84

    72 hea ting s y s tems desired room temperature thedesiredroomtemperaturecanbesetfrom 5°cto30°c,in0.5increments. I theworldhealthorganisation recommendsaroomtemperatureof 18–24°cforhealthyliving. Nb: if day or night mode are active, the temperaturecannotbeadjusted,andtheplus andminusbuttonswillbegre...

  • Page 85

    73 max current draw from 230v supply is 4.5a on1kw,9aon2kw,14aon3kw.Iftheelectric supplyhasunstablevoltage,theamperagewill alsofluctuate. Gas heating the alde boiler is programmed to use power economically.Thegasburnerhastwostages, shiftingdynamicallybetweenloworfullflame. Therearetimeswhenitmayusen...

  • Page 86

    74 hea ting s y s tems “fanfailure” •combustionfanspeedtoolow.Bearingmay bestiffafteraperiodofdisuse. •automatically clears after 5 mins. Please tryagain. “connectionfailure” •loose connection between alde control panelandboiler. •unplug cable at the control panel and boiler,thencarefullyplugbackin....

  • Page 87

    75 hea ting s y s tems function description the liquid gas heater combi e is a warm- air heater with integrated hot water boiler (10 litres volume). The burner operates fan supported, which ensures trouble-free functionevenwhenonthemove.Theunitalso hasheatingelementsforelectricaloperation. In winter...

  • Page 88

    76 hea ting s y s tems safety/drain valve (operational) fillingthewaterheater checkthesafety/drainvalveinthecoldwater intakeisclosed.Levershouldbeinhorizontal position,positione. E= leverposition“closed” f= leverposition“drain” openhottapinbathroomorkitchenwithpre- selecting mixing taps or single-le...

  • Page 89

    77 hea ting s y s tems pumpswitch). Openhotwatertapsinkitchenandbathroom, (set preselecting mixing taps or single-lever fittingsto“hot”).Leavethefittingsopenfor as long as it takes for the boiler to displace theairandfillupandthewatertoflowwithout interruption. ! If just the cold water system is bei...

  • Page 90

    78 hea ting s y s tems heating without water temperature monitoring. Selectgas,electricalormixedoperationusing the power switch. Illumination of the yellow led on the power selector switch indicates thattheunitisoperatingwith230v. Move rotary switch on control panel to operatingposition. Turn the ro...

  • Page 91

    79 hea ting s y s tems ! Ifthe230vpowersupplyis interruptedforjustabriefperiodof approximately1secondduring operation,theheaterwill subsequentlyresumeasnormal. Mixed mode malfunctioninthepowersupply230v. Theyellowledonthepowerselectorswitch goesoffandtheredledonthecontrolpanel flasheswith5hz. If in ...

  • Page 92

    80 hea ting s y s tems overheating protection 230v. The 230v heating facility has a mechanical overheating switch. If the 12v power supply is interrupted during operation or during the after-runperiod,forexample,thetemperature withintheunitcouldactivatetheoverheating protection. To reset the overhea...

  • Page 93: Fault

    81 hea ting s y s tems fault cause remedy no led is shining, the device is switched on and is supplied with operating current. Automatic restart is blocked, e.G. After a powerfailure. Reset (fault reset) by switching off, waiting5secondsandthenswitching onagain. After switching (winter and summer op...

  • Page 94

    82 hea ting s y s tems after operating for a longer period of time, the heaterswitchestofailure. Summer operation with emptywatertank. Hot-airoutletsblocked. Recirculated air intake blocked. Gas pressure regulator icedup. Butane content in the gascylindertoohigh. Switchdeviceoffandallowtocool. Fillb...

  • Page 95

    83 hea ting s y s tems truma cp plus digital control panel operating instructions safety instructions • thedevicemayonlybeoperatedifitisin perfectworkingorder. • arrange for malfunctions to be rectified immediately. Only rectify malfunctions yourself if the remedy is outlined in the troubleshooting ...

  • Page 96

    84 hea ting s y s tems heater settable temperature range 5°c–30°c (1°c steps) a=heater*-heaterisswitchedon. *thissymbolwillflashuntiltherequiredroom temperatureisreached. Change the warm water level • usethecontrolknob/pushbuttontoselect thesymbolinmenuline(3). • clicktochangetothesettinglevel. • us...

  • Page 97

    85 hea ting s y s tems oncethewatertemperatureisreached,the roomisheatedagain. * this symbol will flash until the required watertemperatureisreached. Select power type • usethecontrolknob/pushbuttontoselect thesymbolinmenuline(3). • clicktochangetothesettinglevel. • usethecontrolknob/pushbuttontosel...

  • Page 98

    86 hea ting s y s tems select power type • clicktochangetothesettinglevel. • usethecontrolknob/pushbuttontoselect thepowertype. • click the control knob/push button to confirmthevalue. Select fan level • clicktochangetothesettinglevel. • usethecontrolknob/pushbuttontoselect therequiredfanlevel. • cl...

  • Page 99

    87 hea ting s y s tems i thetimerremainsactive,evenfor severaldays,untilitisdeactivated (off). Deactivate the timer (off) • clicktochangetothesettinglevel. • use the control knob/push button to deactivatethetimer(off). • click the control knob/push button to confirmthevalue. Set time • thehourdispla...

  • Page 100

    88 hea ting s y s tems ifthecauseisnotremedied,themalfunction willoccuragainandthecontrolpanelwilljump againtothemenulevel“malfunction” cause not remedied/return to setting level • pressthebackbutton. I in this case, the malfunction is not acknowledgedinthecontrolpaneland the warning symbol remains ...

  • Page 101

    89 hea ting s y s tems troubleshooting instructions (combi gas heater) error code cause remedy #17 summer mode with empty water container switchoffdeviceandallowtocool.Fillboiler withwater warmairoutletblocked checkeachoftheoutletopenings circulatedairintakeblocked remove the blockage from the circu...

  • Page 102

    90

  • Page 103

    91 ex terior fea ture s 21. Exterior features grp grp components need to be washed, waxed andcaredforlikeacar.Chemicalsanddirtcan collect during storage, and the outer surface called a gel coat can be stained or marked when chemicals combine with rain or dew. Moststainsormarkscanberemovedwithmild di...

  • Page 104

    •onlyusewaterandmildsoapsudstoclean theblinds. •failure to comply with these instructions makestheguaranteenullandvoid. Mpk rooflight thempkrooflightissituatedinthebathroom ofyourcaravanovertheshowercompartment. Itisfittedwithaflyscreenforyourcomfort. Theflyscreenishinged,allowingyouaccess to the ha...

  • Page 105

    93 c ooking e quipment 22. Cooking equipment the caprice cooker- used in unicorn and pegasus models ! Neverusethecookerasaspace heater. ! Beforeusingtheapplianceplease ensurethatyouareawareofthe following: •applianceandaccessiblepartsbecomehot duringuse. •avoidtouchingheatingelements. •childrenlesst...

  • Page 106

    94 c ooking e quipment • thefollowingpansizesarethemaximum werecommend: • electric hotplate: - Ø180mm (dual fuel only) • auxiliaryburner:Ø200mm • semi-rapid burner: 2x Ø200mm or 1x Ø220mmwith1xØ180mm • whenusingsmallpanstheflamesshould not spread beyond the base of the pan as this will reduce the ef...

  • Page 107

    95 c ooking e quipment grillingchopsetc •positiontrivetlow slowgrilling •removethetrivet 8. To turn off: turn the control knob until the line on the control knob is aligned withthedotonthecontrolpanel.Always make sure the control knob is in the off positionwhenyouhavefinishedgrilling. ! Thegrillarea...

  • Page 108

    96 c ooking e quipment must be taken that the foil does not impair circulationorblocktheovenflueoutlet. Do’s and don’ts doreadtheuserinstructionscarefullybefore usingtheapplianceforthefirsttime. Doallowtheoventoheatbeforeusingforthe firsttime,inordertoexpelanysmellsbefore theintroductionoffood. Docl...

  • Page 109

    97 c ooking e quipment always remove the handle from the pan wheninuse. •ensure gas cylinder/supply is connected andturnedon.Intheeventofagassmell turn off at the gas cylinder/mains and contactsupplier. •remove all accessories and packing that may be in the grill including any plastic coating that m...

  • Page 110

    98 c ooking e quipment youhavefinishedgrilling. Oven •ensure the gas cylinder is connected and turnedon.Intheeventofagassmell,turn offthegasatthecylinderandcontactyour retailer. •remove all accessories and packing that may be in the oven and clean the interior beforeusingitforthefirsttime. •to light...

  • Page 111

    99 c ooking e quipment do’s and don’ts do readtheuserinstructionscarefullybefore usingtheapplianceforthefirsttime. Doallowtheoventoheatbeforeusingforthe firsttime,inordertoexpelanysmellsbefore theintroductionoffood. Docleantheapplianceregularly. Doremovespillsassoonastheyoccur. Do always use oven gl...

  • Page 112: 100

    100 micr o w a ve o ven 23. Daewoo microwave oven ! Precautions to avoid possible exposure to excessive microwave energy •do not attempt to operate this oven with the door open since open-door operation canresultinharmfulexposuretomicrowave energy. It is important not to remove or tamperwiththesafet...

  • Page 113: 101

    101 micr o w a ve o ven 1. Informationscreen 2.Autocook:usedtocookusingaprogramme ortoreheat. 3.Defrost:usedtodefrostfoodsbyweightor time. 4.Power:usedtosetpowerlevel. 5.Clock:usedtosettheclock. 6.Weightandtimedialknob:usedtosetthe timeandweight. 7.Start/easy cook: used to start the oven operationan...

  • Page 114: 102

    102 micr o w a ve o ven ifyouselected12-hoursystem,thedisplaywill showthehoursfrom“1”to“12”. If you selected 24-hours system, the display willshowthehoursfrom“0”to“23”. Theadjustedhoursstartsblinking. The minute stops blinking and “00” starts blinking. Thedisplaywillshowtheminutesfrom“0”to “59”. The...

  • Page 115: 103

    103 micr o w a ve o ven 4.Turn the knob to adjust the cooking time (thedisplaywillshowwhatyouselected). 5.Pressstartbutton. Whenyoupressstartbutton,thedefandm/w indicatorscomeontoconfirmthepowerlevels selected.Thedefindicatorstartsblinkingto showyouthattheovenisindefrostmode. The display counts down...

  • Page 116: 104

    104 micr o w a ve o ven child safety lock safetylockpreventsunwantedovenoperation such as by small children. To set, press and hold stop/clear button for 3 seconds. Lock indicator appears and a beep sounds. To cancel,pressandholdstop/clearbuttonfor3 seconds.Lockindicatordisappearsandabeep sounds. To...

  • Page 117: 105

    105 c arb on mono xide alarm please read all steps thoroughly before attemptingtotestyouralarm. •if the alarm is wall mounted, remove by unhooking the unit from the wall fixing screws. •cover the sounder vents with one hand andholdthetest/resetbuttondownwith your thumb/finger until the power led ill...

  • Page 118: 106

    106 c arb on mono xide alarm detector.Anyattempttodosomaycause malfunctionandwillinvalidatethewarranty. ! Never ignore any alarm. What to do in the event of an alarm •keep calm and open all the doors and windowstoventilateyourcaravan. •stopusingallfuelburningappliancesand ensurewherepossibletheyaret...

  • Page 119: 107

    107 b a thr oom c are 28. Bathroom care do not expose the bathroom plastic fittings to cleaning products or abrasive material containing concentrated perfumes, body oil, linseed oil, gritty or abrasive substances, solvents(whitespirits,antifreezeetc).These maycausepermanentdamagetothematerial. Alway...

  • Page 120: 108

    108 thetf ord c2 6 2 t oilet 29. Thetford c262 toilet thethetfordcassettetoiletisahighquality product. The toilet forms an integral part of your caravan bathroom, thanks to its functional design which combines modern stylingandeaseofuse. The c262 cassette toilet is manufactured from high quality syn...

  • Page 121: 109

    109 thetf ord c2 6 2 t oilet aquarinse.Thisthetfordtoiletfluidkeeps the flush water fresh and improves the flushing. Next, fill up the flush-water tank with clean water (approximately 8 litres) usingawateringcanorhose.Yourtoiletis nowreadytouse. Using the toilet (standard) •turnthebowltothedesiredpo...

  • Page 122: 110

    110 e c oc amel sho wer head •removethecoverplatefromtheautomatic pressurereleaseventbyprisingitupusing asmallscrewdriver.Useonehandtopush the automatic pressure release vent open while holding the float of the automatic pressurereleaseventontheinsideofthe tank with the other hand. Push the float up...

  • Page 123: 111

    111 refriger a t ors 24. Refrigerators winter operation—dometic refrigerators ! Pleasecheckthattheventilation grillesortheflueoutletsarenot blockedbysnow,leavesetc. 24a. Dometic refrigerator model rm8550/ rms8550/rm8500- used on pegasus gt65 and pursuit models cleaning before starting up the refrige...

  • Page 124: 112

    112 refriger a t ors for physical reasons, ignition faults could occur starting from an altitude above sea levelofapprox.1,000m/3,280ft.(thisisnot amalfunction!) on the initial refrigerator start-up or after a cylinderchange,airmaybetrappedinthegas line.Topurgetheairfromtheline,switchon therefrigera...

  • Page 125: 113

    113 refriger a t ors removable freezer compartment •to enlarge the cooling space just remove thefreezercompartment. •unlock the freezer compartment on both sidesandpullitout. •store the freezer compartment safely in ordertopreventdamage. Positioning the storage racks •the storage racks may be pulled...

  • Page 126: 114

    114 refriger a t ors shutting off the refrigerator •set energy selector switch a to position off.Theapplianceisswitchedoff. •releasethelockingmechanismofthedoor lockbypushingitandshiftittothefront. Ifthedoorisshutinthisposition,asmall gap is nevertheless kept open to prevent formationofmildew. •if t...

  • Page 127: 115

    115 refriger a t ors extended shut down of the vehicle. Please contactdometiccustomerservices. Explanationofoperatingcontrols (power on switch/energy selector switch (mode) temperatureselection poweronswitchframeheating indicatorledfailure indicatorledframeheating indicatorled/operatingmodedisplay t...

  • Page 128: 116

    116 refriger a t ors i thecoolingunit’sperformanceis influencedbyambienttemperatures. Pleaseselectthemediumsettingfor ambienttemperaturesbetween+15°c and+25°c.Theunitoperateswithin itsoptimumperformancerange. Dometicrefrigeratorsworkaccording totheabsorptionprinciple.For physicalreasons,anabsorption...

  • Page 129: 117

    117 refriger a t ors positioning storage racks the storage racks may be pulled out by loosening the two locking devices (1) underneath. For loosening pull the slider to themiddle,forfasteningpullthemsidewards. Lighting if the door is open for more than 2 minutes, theinteriorlightingisautomaticallycu...

  • Page 130: 118

    118 refriger a t ors ofmildew. Iftherefrigeratoristobetakenoutofservice foranextendedperiodoftime,closetheon- boardshut-offvalveandthecylindervalve. Defrosting as time goes by, frost builds up on the fins insidetherefrigerator.Alayeroffrostthicker ononesidemayoccuranddoesnotrepresent a malfunction. ...

  • Page 131: 119

    119 refriger a t ors shortperiodoftime? A) check whether the cooling compartment worksafter4–5hours. Q)ambienttemperaturestoohigh. A)regularlyremoveventilationgrilles. Failure: the refrigerator does not cool in gas operationmode. Possiblecauseandactionyoucantake q)gascylinderempty. A)changegascylind...

  • Page 132: 120

    120 refriger a t ors 24c. Dometic refrigerator model rml9330- used on unicorn single axle models introduction the refrigerator, which works silently, meets high quality standards and guarantees the efficient utilization of resources and energy throughout its entire life cycle, during manufacture,inu...

  • Page 133: 121

    121 refriger a t ors safety instructions application according to regulations thisrefrigeratorisdesignedforinstallationin recreationvehiclessuchascaravansor motorhomes. The appliance has been type approval tested for this application in accordancewiththeecgasdirective. Therefrigeratoristobeusedsolel...

  • Page 134: 122

    122 refriger a t ors ! Operating appliance with gas is not permitted • atpetrolstations • onferryboats,andonboardmotor railtrains • while transporting the caravan by transportedorbreakdownvehicle thereisadangeroffire! Switchofftheappliance. If you smell gas •openallwindowsandleavetheroom. •do not op...

  • Page 135: 123

    123 refriger a t ors refrigerator operation the refrigerator is equipped to operate on threepowermodes: •mainsvoltage(230vac) •direct-currentvoltage(12vdc) •gas(liquidgaspropane/butane) select the desired power mode by the energy selector switch (battery igniter type models) or the energy selector b...

  • Page 136: 124

    124 refriger a t ors switch on the refrigerator and any other gasappliances(e.G.Stove)forashorttime. Thegasigniteswithoutdelay. •each refrigerator with manual ignition is equipped with an automatic flame safety valve which interrupts the gas supply automatically after approx. 30 seconds whentheflame...

  • Page 137: 125

    125 refriger a t ors i please select the medium setting (a) for ambient temperatures between +15°c and+25°c.Theunitoperateswithinits optimumperformancerange. • 12v operation: the refrigerator operateswithoutthermostaticcontrol (continuousoperation). Door locking ! Asabasicrule,shutandlockthe refrige...

  • Page 138: 126

    126 refriger a t ors door shelves maximum four door shelves (4) can be installed in the door. To remove the shelves, pressslightlytogetheratthesidesandreplace theminmountingsattherequiredplaceagain. Removable freezer compartment •to enlarge the cooling compartment, just removethefreezercompartment. ...

  • Page 139: 127

    127 refriger a t ors operation during low outside temperatures checkregularlythattheventilationopenings (1)(2)havenotbeenblockedbysnow,leaves orsimilar. Cold air can restrict the performance of the unit.Installthewintercovers(3)ifyoudiscover anylossofcoolingperformancewhenoutdoor temperatures are lo...

  • Page 140: 128

    128 refriger a t ors making ice cubes icecubesarebestfrozenovernight.Atnight, the refrigerator has less work to do and the unithasmorereserves. •filltheicecubetray withdrinkingwater •place the ice-cube tray in the freezer compartment ! Onlyusedrinkingwater. Refrigerator compartments 1. Freezercompar...

  • Page 141: 129

    129 refriger a t ors •after defrosting (freezer compartment and fins free of frost), wipe both cooling compartmentsdrywithacloth. Note:waterthawinginthemaincompartment of the refrigerator runs into an appropriate containeratthebackoftherefrigerator.From there,thewaterevaporates thelayeroficemustneve...

  • Page 142: 130

    130 refriger a t ors trouble shooting failure: the refrigerator does not cool sufficiently. Possiblecause actionyoucantake inadequateventilationtotheunit checkthatventilationgrillesarenotcovered thermostatsettingistoolow setthermostattohigherlevel thecondenserisheavilyfrosted checkthattherefrigerato...

  • Page 143: 131

    131 smoke alarm 25. Stainless steel sink stainless steel sinks need little maintenance other than cleaning immediately after use. Mostdepositscanberemovedbywashingwith soapormilddetergentandhotwater,followed byacleanwaterrinseanddryingwithasoft clothtopreventwaterspotting. For more tenacious deposit...

  • Page 144: 132

    132 s oft furnishing s 31. Soft furnishings carpet when cleaning the interior of your caravan pleaseremovethecarpetfromthevehicle. Vacuumthecarpetstotakethedirtoutofthe pile. For general cleaning use a dry shampoo, followingtheproduct’sdirections. For stains, use a mixture of 1/3 bleach to 2/3warmwa...

  • Page 145: 133

    133 remis blind s 32. Remis blinds remibase plus window blinds. Please note the blinds should not be in the closedpositionwhenthevehicleistravelling orwheninstorageforextendedperiods. The sun screen is housed at the bottom and theflyscreenatthetopoftheblind.Toopen eitherholdthecrossbarandpullupordow...

  • Page 146: 134

    134 s ta tus aerial 33. Status 550 digital antenna system frequencyrange: uhf470–860mhz fm88–108mhz dab175–230mhz antennaforwardgain 7db amplifiergain 16db gainadjustment 15db noisefigure 2.8db outputimpedance 75ohms output 95dbuv powersupply 12–24vdc powerconsumption 55ma signaloutputs 2tv1radio tr...

  • Page 147: 135

    135 gener al c are amplifierandswitchon.Tuneinyourtvfor thestrongestsignal. If the picture quality improves the fault lies with the wiring of the system between the amplifierandtvoutletsocket. Short hook up: test 2 thistestisolatestheamplifierbyconnecting yourtvdirecttotheantenna. Unplug the antenna...

  • Page 148: 136

    136 gener al c are allitemsstoredinthegasbottle storagelockermustbesecuredto preventimpactdamagetotheinside ofthebodypanelwhenthecaravanis beingtowed. Donotallowanychemicals,toiletorotherwise, tospillorleakintothegasboxfloor.Before placingitemsinthecradleensurethatthetray is clean and free from any ...

  • Page 149: 137

    137 gener al c are humid air and condensation can also be generatedbythingspeopledoonadailybasis. •cooking:upto3litresperday •showers:1.5litresperperson •washingdishes:upto1litresperday •breathing: active adult 0.2 litres an hour perperson •breathing,adultasleep:0.02litresanhour perperson how to kee...

  • Page 150: 138

    138 c ar a v an ke y s 35. Caravan keys each unicorn model is supplied with 2 identicalkeys.Intheeventofbothkeysbeing lostthesecannotbereplaced.Inthisinstance anewlockwillhavetobefittedwithafresh setofkeys. Allpegasusgt65andpursuitmodelshavea highsecuritylockfortheentrancedoorand2 keysforthislockare...

  • Page 151: 139

    139 b aile y p ar t s 37. Modifications & diy work ownersneedtobeawarethatcarryingoutdiy modificationstoyourcaravanmay,incertain circumstances, invalidate the warranty cover andcouldalsoaffectthesafetyandstructure ofthevehicle. 38. Spares & aftersales there are numerous parts and accessories availab...

  • Page 152: 140

    140 bed make up 39. Pegasus gt65 front bed make up step 1: pull out the slats from the offside towards the bunks on the other side of the vehicle. Step2:therewillbeaslightgapbetweenthe twobunkfaces. Step3:turnthecushionsoverandmovethe backrestsintothemiddle. Step4:movetheseatbasecushionssothat thekn...

  • Page 153: 141

    141 bed make up 41. Side dinette top bunk assembly step 1 remove cushions and draw the curtains and close the blind if fitted. Step 2 holding the bunk in both hands pull it inwards step 3 whilst lifting upwards step 4 the bunk mechanism will automatically lock in the up position. Step 5 release reta...

  • Page 154: 142

    142 bed make up 42. Side dinette bottom bunk assembly side dinette bottom bunk assembly i. Remove table from support leg. Ii. Place the table top between seats on ledge. Iii. Arrange seat cushions as appropriate. When children, especially those under 3 years of age, use any bunk/bed care must be tak...

  • Page 155: 143

    143 useful c ont a c t s 43. Useful e-mail addresses and telephone numbers baileycustomerservices customerservices@baileyofbristol.Co.Uk baileysparesdepartment parts@baileyofbristol.Co.Uk criss +44(0)2032821000 michelintyreplc +44(0)8453661535 al-ko +44(0)1926818500 mail@al-ko.Co.Uk fireangel +44(0)...

  • Page 156: 144

    144.