1. DL manuals
  2. Bakers Pride
  3. Oven
  4. BCO-E
  5. Installation And Operating Instructions Manual

Bakers Pride BCO-E Installation And Operating Instructions Manual

Manual is about: Cyclone Series

Summary of BCO-E

  • Page 1

    Installation and operating instructions cyclone series electric convection ovens models: bco-e and gdco-e intended for other than household use retain this manual for future reference oven must be kept clear of combustibles at all times this equipment has been engineered to provide you with year rou...

  • Page 2: Index

    A receiving 3 b set-up/mounting 3 c installation with casters 4 d location & minimum clearances 4 e electrical connections 4 f flue connection ventilation 5 g initial cleaning 5 h system check - rotary controls 5 a general instructions 6 b operation sequence for rotary controls 6 1. Cook only 6 2. T...

  • Page 3

    I. Installation instructions a. Receiving b. Set up / mounting: note: for a single unit: refer to figure 4 for a stack of two ovens: refer to figure 3 to assemble an open rack stand: refer to figure 2 read the notice on the outside carton regarding damage in transit. Damage discovered after opening ...

  • Page 4

    4 e. Electrical connection: install according to the spacing requirements listed in the installation section of this manual. We strongly recommend having a competent professional install this equipment. A licensed electrician should make the electrical connections and connect power to the unit. Loca...

  • Page 5

    The oven, when installed, must be electrically grounded in accordance with local codes and/or the latest edition of the national electrical code ansi/nfpa no. 70 in the usa (canadian electrical code csastandard c22.1, part 1 in canada). In europe, the appliance must be connected by an earthen cable ...

  • Page 6

    (6) turn the timer knob past 10 minutes and back to 2 minutes. At the end of 2 minutes the buzzer will sound. Reset by turning to “0.” all settings below 10 minutes require turning past 10 minutes and then back to the time required. (7) open the oven doors. Oven lights will go on and elements and fa...

  • Page 7

    (7) when timer reaches zero, a buzzer will sound. (8) turn the timer knob to “o” position. (9) remove the product from the oven. (1) close the oven doors. (2) turn selector switch to “hi” or “lo” position. The indicator light near the selector switch will be illuminated. (3) turn the thermostat knob...

  • Page 8

    1 2 3 4 5 6 7 8 9 10 8 d. Servicing: note: thisappliance must be serviced byanauthorized serviceagent. (1) power supply to the unit must be disconnected before any service is performed. (2) most of the service on the unit can be performed from the front and/or control panel side. (3) for proper serv...

  • Page 9

    9 figure 3 item 1 item 2 item 3 e3770a e3771a 3/8”-16 bolt stacking instructions for: bco-e & gdco-e convection ovens remove flue from top oven and replace with item 1 2 1 3 attach part # 21818062 with 6 each 8-32 stainless screws material: 14 ga 201 stainless remove flue from bottom oven, and re-in...

  • Page 10

    With plate caster without plate caster figure 4 leg assembly instructions-model: bco-e & gdco-e 1. Attach two item 2 to two item 1 using item 3, 4 and 5. 2. Using proper lifting equipment attach item 1 to the 4 corresponding hole patterns located in the bottom of the oven with item 6. 5 4 7 6 2 3 1 ...

  • Page 11

    11.

  • Page 12

    12 probe door heat fan lights power com relay l1 l3 l2 single phase 208/240v doors activate switch when closed gnd front element 28 29 10 9 16 17 14 15 27 4 21 20 26 25 23 22 18 2 1 27 24 19 8 6 9 12 13 fuse box c no nc motor t3tot2 t1tot4 t1tot2 a1 a2 32 35 33 34 36 37 4 poles, 40 amps contactor 48...

  • Page 13

    Important for future reference please complete this information and retain this manual for the life of the equipment. For warranty service and/or parts, this information is required. Model number serial number date purchased notes:.

  • Page 14

    Notes:.

  • Page 15

    Bakers pride limited warranty 30 pine street new rochelle, new york 10801 914 / 576 - 0200 • us & canada: 1 - 800 - 431 - 2745 • fax 914 / 576 - 0605 bco models: one (1) year limited parts and labor; (1) year limited door warranty. Gdco models: two (2) year limited parts and labor; (2) year limited ...

  • Page 16: Bakers

    Bakers pride bakers pride oven co., inc. 30 pine street new rochelle, ny 10801 +1 (914) 576-0200 phone sales@bakerspride.Com e-mail +1 (914) 576-0605 fax www.Bakerspride.Com webaddress +1 (800) 431-2745 us & canada.