1. DL manuals
  2. Bakers Pride
  3. Broiler
  4. C
  5. Installation And Operating Instructions Manual

Bakers Pride C Installation And Operating Instructions Manual

Manual is about: Dante Series

Summary of C

  • Page 1

    Bakers pride oven co., inc. 30 pine street new rochelle, ny 10801 +1 (800) 431-2745 us & canada +1 (914) 576-0200 phone sales@bakerspride.Com e-mail +1 (914) 576-0605 fax www.Bakerspride.Com web address installation and operating instructions p/n 1/07 u4201a 1 dante series gas char broilers models: ...

  • Page 2

    2 contents section page i. Installation instructions 3 1 installation 3 2 clearances 3 3 gas connection 3 4 burners 4 5 radiant units 4 6 glo-stone units 4 7 grease drawer & water pans 5 8 griddle plate 5 9 smoker boxes 5 10 lighting instructions 5 11 additional instructions 6 12 installation with c...

  • Page 3

    I. Installation instructions 1. Installation: (i) it is advisable to call on a qualified installer to install the appliance and, if the need causes to convert it for use with other gases. (ii) installation of this broiler must conform to the installation regulations in force in the destination count...

  • Page 4

    When making gas pipe connections, only pipe joint compound resistant to the action of liquefied petroleum gases should be used. The broiler and its individual shut-off valve must be disconnected from the gas supply system during any pressure testing of that system at test pressure in excess of ½ psi...

  • Page 5

    7. Grease drawer, water pans: (i) a grease drawer is provided at the very left of each broiler to collect the grease from the grease trough above. (ii) depending on the size of the broiler, one or more water pans are provided to collect any drippings from the broiling area above. Water pans assist i...

  • Page 6

    11. Additional instructions: (i) keep the area around the broiler free and clear of all combustible material. (ii) provision of adequate supply of air to your broiler is essential. Provide for sufficient outside air to enter the broiling area and assure that this air flow is not obstructed. (iii) ai...

  • Page 7

    Iii. Maintenance 1. Service: all servicing should be performed by a factory authorized technician only. Shut off the main gas supply before attempting any maintenance or service on the unit. If required, contact your dealer, a local service company or the factory to obtain a qualified technician for...

  • Page 8

    Iv. Illustrations: (i) see figure “f” for typical top view and front views of a cabinet style broiler. Both radiant and glo- stone type are shown and so are single and double burners, lighter tubes and carry-over lighter tube to illustrate and identify the various components utilized. For more detai...

  • Page 9

    6" adj. Legs (std) 4" casters (opt) 4" adj. Legs (std) 4" adj. Legs (opt) drip pan(s) low profile grease drawer low profile grease deflector (typ) double burner (typ) observation & igniter holes "o" position marks carry-over valve knobs drip catch (opt) lighter tube burner suppt radiant & glo-stone ...

  • Page 10

    1 0 applicable supply burner to model pressure pressure being tested (mbar) (mbar) net 1 net 2 gross 1 gross 2 main 1 main 2 i 2h x g20 20 8.7 6.3 6.3 i 2e+ x g20/25 20/25 8.7 6.3 6.3 i 2h x g20 20 8.7 6.3 6.3 i 2h x g20 20 8.7 6.3 6.3 x g20 20 8.7 6.3 6.3 x g20 20 8.7 6.3 6.3 i 2e+ x g20/25 20/25 8...

  • Page 11

    Applicable supply burner to model pressure pressure being tested (mbar) (mbar) net 1 net 2 gross 1 gross 2 main 1 main 2 i 2h x g20 20 8.7 5.3 10.55 5.9 11.7 2.05 3.1 1.35 6.3 6.3 i 2e+ x g20/25 20/25 8.7 5.3 10.55 5.9 11.7 2.05 3.1 1.35 6.3 6.3 i 2h x g20 20 8.7 5.3 10.55 5.9 11.7 2.05 3.1 1.35 6.3...

  • Page 12

    12 what is covered this warranty covers defects in material and workmanship under normal use, and applies only to the original purchaser providing that: ♦ the equipment has not been accidentally or intentionally damaged, altered or misused; ♦ the equipment is properly installed, adjusted, operated a...