1. DL manuals
  2. Bakers Pride
  3. Grill
  4. CH Dante Series
  5. Installation And Operating Instructions Manual

Bakers Pride CH Dante Series Installation And Operating Instructions Manual

Manual is about: Dante Series GAS CHAR BROILERS

Summary of CH Dante Series

  • Page 1

    Bakers pride oven co., inc. 30 pine street new rochelle, ny 10801 (914) 576-0200 phone (914) 576-0605 fax www.Bakerspride.Com webaddress info@bakerspride.Com e-mail (800) 431-2745 us & canada this equipment has been engineered to provide you with year round dependable service when used according to ...

  • Page 2

    2 important for future reference please complete this information and retain this manual for the life of the equipment. For warranty service and/or parts, this information is required. Model number serial number date purchased notes:.

  • Page 3: Index

    Index i. Installation instructions ii. Operating instructions iii. Troubleshooting guide section item page section item page section item page 1 general description 4 2 installation 4 3 clearances 4 4 gas connection 4 5 burners 5 6 radiants 5 7 top grates 6 8 lighting 6 9 griddle plates 6 10 additio...

  • Page 4

    4. Gas connection: the gas pressure regulator supplied must be installed at the gas inlet of each broiler. Each regulator is adjusted to yield a manifold pressure of 5 in. Water column for natural gas or 10 in. Water column for propane gas. No pressure regulator is required for propane gas in canada...

  • Page 5

    5. Burners: 6. Radiants: check to see that air mixer caps on the front of all burners are tightened and adjusted, allowing half the opening to show. Install the burners and deflector shields first following the steps below. (a) install all burners with deflector shield assemblies attached. (b) place...

  • Page 6

    7. Top grates: 8. Lighting: place a grate over each of the radiants. For normal operation, the pointed side of the grate is facing up. For use with foods that require extra support, the flat side may be used. On xx models, grates can be placed on three levels; two positions are built into the rear o...

  • Page 7: II. Operating Instructions

    Ii. Operating instructions 1. Lighting procedure: see section 8 of installation instructions. Once the pilot burners are lit, the broiler may be turned “on” or “off” by turning the control valves on or off as necessary. 2. Broiling procedure: 3. Helpful hints: broiler top grates must be hot enough t...

  • Page 8

    4. Maintenance: (a) service: (b) careand cleaning of top grates: (c) grease collection: (d) cleaning tools: shut off the main gas supply before attempting any maintenance on the unit. If required, contact your dealer, the factory, or a local service company to obtain qualified maintenance and repair...

  • Page 9

    Iii. Trouble shooting guide caution: take extreme care to assure that, if a valve is opened, a flame is present. If a valve is left open without a flame, turn the valve off and wait at least five minutes before attempting to (re)light. Service should be performed only by a qualified gas technician. ...

  • Page 10

    (d) and has a proper flame, close all the burner valves , allow to cool and then remove the top grate and radiant over the burner. Remove the burner by lifting the rear of the burner off the support pin, slide it towards the rear of the broiler, enough to clear the burner orifice (fig. 3 or 4). Usin...

  • Page 11

    Xx-4, 6, 8, 10, 12 gas char broiler 30 pine street • new rochelle • new york • 10801 914 / 576 - 0200 914 / 576 - 0605 1 - 800 - 431 - 2745 www.Bakerspride.Com fax us & canada web address bakers pride page 4 of 4 2/05 note: when ordering, always specify part #, model #, serial #, voltage/phase & typ...

  • Page 12

    30 pine street • new rochelle • new york • 10801 914 / 576 - 0200 914 / 576 - 0605 1 - 800 - 431 - 2745 www.Bakerspride.Com fax us & canada web address bakers pride page 2 of 4 2/05 note: when ordering, always specify part #, model #, serial #, voltage/phase & type of gas. Xx-4, 6, 8, 10, 12 gas cha...

  • Page 13

    Splash guard, s/s (xx-4) optional splash guard, s/s (xx-6) optional splash guard, s/s (xx-8) optional splash guard, s/s (xx-10) optional splash guard, s/s (xx-12) optional grease pan (xx-4 & 12) 20 3/8", 1 used grease pan (xx-6 & xx-10) 30 7/8", 1 used grease pan (xx-8) 19 5/8", 2 used or (xx-12) 1 ...

  • Page 14

    58 57 51 48 47 56 55 49 50 54 53 52 46 gas char broiler 30 pine street • new rochelle • new york • 10801 914 / 576 - 0200 914 / 576 - 0605 1 - 800 - 431 - 2745 www.Bakerspride.Com fax us & canada web address bakers pride figure a exploded view page 2 of 4 8/03 note: when ordering, always specify par...

  • Page 15

    30 pine street • new rochelle • new york • 10801 914 / 576 - 0200 914 / 576 - 0605 1 - 800 - 431 - 2745 www.Bakerspride.Com fax us & canada web address bakers pride parts list (see figure a) 8/03 note: when ordering, always specify part #, model #, serial #, voltage/phase & type of gas. Page 3 of 4 ...

  • Page 16

    V. Bakers pride limited warranty 30 pine street new rochelle, new york 10801 914 / 576 - 0200 • us & canada: 1 - 800 - 431 - 2745 • fax 914 / 576 - 0605 bco models: one (1) year limited parts and labor; (1) year limited door warranty. Gdco models: two (2) year limited parts and labor; (2) year limit...