1. DL manuals
  2. Bakers Pride
  3. Kitchen Appliances
  4. COUNTERTOP GAS RADIANT XX-10
  5. Installation And Operating Instructions Manual

Bakers Pride COUNTERTOP GAS RADIANT XX-10 Installation And Operating Instructions Manual

Manual is about: EQUIPMENT PRICE LIST

Summary of COUNTERTOP GAS RADIANT XX-10

  • Page 1

    Bakers pride oven co., inc. 30 pine street new rochelle, ny 10801 (914) 576-0200 phone (914) 576-0605 fax www.Bakerspride.Com web address (800) 431-2745 us & canada info@bakerspride.Com e-mail this equipment has been engineered to provide you with year round dependable service when used according to...

  • Page 2

    2 important for future reference please complete this information and retain this manual for the life of the equipment. For warranty service and/or parts, this information is required. Model number serial number date purchased notes:.

  • Page 3

    Contents i. Installation instructions section item page 1 general description 4 2 installation 4 3 clearances 4 4 gas connection 4 5 burners 5 6 radiants 5 7 top grates 6 8 lighting 6 9 griddle plates 6 10 additional installation requirements 6 11 installation with casters 6 ii. Operating instructio...

  • Page 4

    4. Gas connection: the gas pressure regulator supplied must be installed at the gas inlet of each broiler. Each regulator is adjusted to yield a manifold pressure of 5 in. Water column for natural gas or 10 in. Water column for propane gas. No pressure regulator is required for propane gas in canada...

  • Page 5

    The broiler and its individual shutoff valve must be disconnected from the gas supply piping system during any pressure testing of that system at test pressures in excess of ½ psig (3.45 kpa). The broiler must be isolated from the gas supply piping system by closing its individual manual shutoff val...

  • Page 6

    7. Top grates: place a grate over each of the radiants. For normal operation, the pointed side of the grate is facing up. For use with foods that require extra support, the flat side may be used. On xx models, grates can be placed on three levels; two positions are built into the rear of the unit; t...

  • Page 7

    Ii. Operating instructions 1. Lighting procedure: see section 8 of installation instructions. Once the pilot burners are lit, the broiler may be turned “on” or “off” by turning the control valves on or off as necessary. 2. Broiling procedure: broiler top grates must be hot enough to make black char-...

  • Page 8

    (b) care and cleaning of top grates: the top grates should be cleaned using a stiff wire brush. If this is done daily, the accumulation of food and fat caught in the grates and work necessary to keep them clean will be reduced. Periodically, they should be turned over and brushed and then put back. ...

  • Page 9

    9 (b) if there is a problem with the gas supply, it may be checked fairly easily. Turn off half of the burners orturn off all other gas appliances and see if the broiler flames increase. If there is an increase in the flame height then there is a problem with the gas supply. A problem with the gas s...

  • Page 10

    10 5. Valve assembly views: (a = cap hold-down screw) figure 4 side view - xx series air mixer cap valve handle burner valve burner manifold orifice a figure 2 air mixer cap and pilot burners pilot burners pilot flame adjusting screw air mixer cap manifold a air mixer cap valve extension (straight) ...

  • Page 11

    Xx-4, 6, 8, 10, 12 gas char broiler 30 pine street • new rochelle • new york • 10801 914 / 576 - 0200 914 / 576 - 0605 1 - 800 - 431 - 2745 www.Bakerspride.Com fax us & canada web address bakers pride page 4 of 4 note: when ordering, always specify part #, model #, serial #, voltage/phase & type of ...

  • Page 12

    30 pine street • new rochelle • new york • 10801 914 / 576 - 0200 914 / 576 - 0605 1 - 800 - 431 - 2745 www.Bakerspride.Com fax us & canada web address bakers pride page 2 of 4 note: when ordering, always specify part #, model #, serial #, voltage/phase & type of gas. 2/05 xx-4, 6, 8, 10, 12 gas cha...

  • Page 13

    Splash guard, s/s (xx-4) optional splash guard, s/s (xx-6) optional splash guard, s/s (xx-8) optional splash guard, s/s (xx-10) optional splash guard, s/s (xx-12) optional grease pan (xx-4 & 12) 20 3/8", 1 used grease pan (xx-6 & xx-10) 30 7/8", 1 used grease pan (xx-8) 19 5/8", 2 used or (xx-12) 1 ...

  • Page 14

    58 57 51 48 47 56 55 49 50 54 53 52 46 gas char broiler 30 pine street • new rochelle • new york • 10801 914 / 576 - 0200 914 / 576 - 0605 1 - 800 - 431 - 2745 www.Bakerspride.Com fax us & canada web address bakers pride figure a exploded view page 2 of 4 note: when ordering, always specify part #, ...

  • Page 15

    30 pine street • new rochelle • new york • 10801 914 / 576 - 0200 914 / 576 - 0605 1 - 800 - 431 - 2745 www.Bakerspride.Com fax us & canada web address bakers pride parts list (see figure a) 8/03 note: when ordering, always specify part #, model #, serial #, voltage/phase & type of gas. Page 3 of 4 ...

  • Page 16

    16 what is covered this warranty covers defects in material and workmanship under normal use, and applies only to the original purchaser providing that: * the equipment has not been accidentally or intentionally damaged, altered or misused; * the equipment is properly installed, adjusted, operated a...