1. DL manuals
  2. Bakers Pride
  3. Convection Oven
  4. Cyclone BCO-G
  5. Install And Operation Instructions

Bakers Pride Cyclone BCO-G Install And Operation Instructions

Manual is about: GAS CONVECTION OVENS Cyclone Series

Summary of Cyclone BCO-G

  • Page 1

    Installation and operating instructions cyclone series gas convection ovens models: bco-g and gdco-g intended for other than household use. Retain this manual for future reference. Oven must be kept clear of combustibles at all times. This equipment has been engineered to provide you with year round...

  • Page 2

    I. Installation instructions section item page a receiving 2 b set up / mounting 2 c installation with casters (optional) 3 d location & minimum clearances 4 e gas connections 4 f electrical connection 5 g flue connection ventilation 5 h burner operation 5 i system check rotary control 5 j programmi...

  • Page 3

    3 for a single unit: refer to figure 4 (1) tilt oven over to left-hand side and attach two 31” legs on the right-hand side with three ½” bolts and washers. Tighten firmly. (2) using proper lifting equipment, lift up the left-hand side and attach two 31” legs on the left-hand side the same way. For a...

  • Page 4

    D. Location and minimum clearances: move the oven to its final location keeping the minimum clearance from the back of the oven to the wall. This clearance is necessary for safe operation and to provide proper air flow to the burner chamber. Minimum clearances from combustible and noncombustible con...

  • Page 5

    F. Electrical connection: the oven, when installed, must be electrically grounded in accordance with local codes and/or the latest edition of the national electrical code ansi/nfpa no. 70 in the usa (canadian electrical code csa standard c22.1, part 1 in canada). In europe, the appliance must be con...

  • Page 6

    (4) press oven light switch. Oven light will go on and will go off when switch is released. (5) turn gas cock dial to “on” position (only for usa and canada). (6) turn the thermostat knob. The indicator light near the thermostat will illuminate and the burners will come on. (7) turn the timer knob a...

  • Page 7

    (6) turn the timer knob to the desired bake time and timer will start counting down. (7) when timer reaches zero, a buzzer will sound. (8) turn the timer knob to “o” position. (9) remove the product from the oven. Note: timer is a signal device only and does not control the oven. Cook and hold rotar...

  • Page 8

    8 clean the stainless steel interior: baked on splatter, oil, grease or discoloration on the stainless steel inside of the oven may be removed with stainless steel cleaner, or any other similar cleaning agent. Never use vinegar or any corrosive cleaner. Use only cleaners approved for stainless steel...

  • Page 9

    9 motor blower wheel set screw (2) wheel puller bolt 3/8” hex item 1 item 2 item 3 e3770a e3771a 3/8”-16 bolt 1. Attach two item 2 to two item 1 using item 3, 4 and 5. 2. Attach two item 7 to two item 1 using item 3, 4 and 5. 3. U s i n g p r o p e r l i f t i n g equipment attach item 1 to the corr...

  • Page 10

    Wiring diagram - bco-g & gdco-g 120v, 1 phase (dial control) wiring diagram - gdco-g 120v, 1 phase (push-button control) 10 black p1p2p3p4 com nc no t6 t7 t8 t9 t10t11 blue yellow ground stud power light t-stat light switch lights 60 min timer power switch door switch flame sensor igniter high low c...

  • Page 11

    Wiring diagram - bco-g & gdco-g 240v, 1 phase (dial control) wiring diagram - gdco-g 240v, 1 phase (push-button control) 11 black p1p2p3p4 com nc no t6 t7 t8 t9 t10t11 blue yellow ground stud power light t-stat light switch lights 60 min timer power switch door switch flame sensor igniter high low c...

  • Page 12

    12 problem cause solution food browns unevenly improper heating temperature. Preheat until desired temperature is reached. Several pans crowded together. Baking pans too large. Use smaller pan. Baking pan dark or glass. Lower oven temperature 25°f (-3.8°c) for this type of pan. Oven temperature too ...

  • Page 13

    Parts list model number: bco - g & gdco-g type of gas: natural l.P. Other 30 pine street • new rochelle • new york • 10801 914 / 576 - 0200 914 / 576 - 0605 1 - 800 - 431 - 2745 www.Bakerspride.Com fax us & canada web address bakers pride cyclone series 4/05 note: when ordering, always specify part ...

  • Page 14

    E x te ri o r / in te ri o r / c o n tr o ls / d o o rs 4 /0 5 n o te : w h e n o rd e ri n g , a l w a y s s p e c if y p a rt # , m o d e l # , s e ri a l # , v o lt a g e /p h a s e & t y p e o f g a s . P a g e 2 o f 4 (n o t s h o w n ) e 87 52 a k it , 2 5" l e g s b la c k w /3 " a d j f e e ...

  • Page 15

    It e m p a rt # d e s c ri p ti o n q u a n i te m p a rt # d e s c ri p ti o n q u a n 4 /0 5 n o te : w h e n o rd e ri n g , a l w a y s s p e c if y p a rt # , m o d e l # , s e ri a l # ,v o lt a g e /p h a s e & t y p e o f g a s . P a g e 3 o f 4 1 2 3 4 5 6 7 8 9 1 0 11 1 2 1 3 1 4 1 5 1 6 1...

  • Page 16

    16 what is covered this warranty covers defects in material and workmanship under normal use, and applies only to the original purchaser providing that: ♦ the equipment has not been accidentally or intentionally damaged, altered or misused; ♦ the equipment is properly installed, adjusted, operated a...