1. DL manuals
  2. Bakers Pride
  3. Oven
  4. Cyclone CO11-E1
  5. Install And Operation Instructions

Bakers Pride Cyclone CO11-E1 Install And Operation Instructions

Manual is about: ELECTRIC CONVECTION OVENS Cyclone Series

Summary of Cyclone CO11-E1

  • Page 1

    Installation and operating instructions cyclone series electric convection ovens models: co11-e and coc-e intended for other than household use retain this manual for future reference oven must be kept clear of combustibles at all times this equipment has been engineered to provide you with year rou...

  • Page 2: Index

    Index installation instructions section item page 1 receiving 2 2 location & minimum clearances 2 3a set-up & mounting for coc-e1 3 3b set-up & mounting for co11-e 3 4 electrical connections 4 5 initial start up 5 6 system check & rotary controls 5 7 steam injection (optional) 6 operating instructio...

  • Page 3

    Minimum clearances coc-e1 co11-e1 inches mm inches mm right 1 25 1 25 left 1 25 2 50 rear 1 25 1 25 suitable for installation on combustible floors when installed on factory supplied legs or casters. 3a.Set-up / mounting for coc-e1 counter-top installation must conform to one of the following method...

  • Page 4

    4 2. Co11-2e: installation / mounting 6” legs a. After unpacking the unit, remove legs and any other material from inside the oven. B. Tilt the bottom oven onto its left side and attach the two mounting plates to the right underside using ½” bolts and washers and tighten firmly. Screw the 6” legs in...

  • Page 5

    2. Field connections a. Remove access panel from the right side of the oven. B. Feed power cable (supplied by the customer) through the access hole in the rear of the oven and pull the cable to the front of the oven under the access panel where it may be attached to the cable support bracket. C. Fol...

  • Page 6

    7. Steam injection option the solenoid valve for steam injection is mounted behind the service panel on the right hand side of the unit on coc-e and on the back of the unit on co11-e. It is pre-wired at the factory. The electronic timer is pre-set at the factory. A ¼” copper tubing with a compressio...

  • Page 7

    7 5. Oven cool down rotary control to cool down the oven to a lower desired temperature, follow the steps detailed below: a. Open the oven door(s). B. Turn selector switch to “oven cool down” position. Fan will now operate and cool down the oven. C. When the oven has cooled to the desired temperatur...

  • Page 8

    8 oven interior: clean the racks and rack support guides: open the doors and remove all wire racks and rack support guides. Take them to the sink and thoroughly clean in warm water with mild detergent or soap. Use a nylon scouring pad or stiff nylon brush. Do not use steel wool. Clean the stainless ...

  • Page 9

    4. Servicing 1. The power supply to the unit must be disconnected prior to service. 2. Most of the service to this unit can be performed from the front and/or the control panel side. 3. For proper service, access to the control panel side of the unit is required. 4. It is necessary to have access to...

  • Page 10

    17 b l k 2 b l k a4 w h t c2 wht a5 w h t a6 wht 9 blk 10 blk h5 w h t h3 wht h6 wht 6 wht 16 w h t 1 b l k com no l2 9 b l k 12 b l k s b l k a3blk c1 blk 13 wht a3 blk a4 wht 4 3 2 p4 p3 p2 p1 buzzer timer 2 1 4 s selector switch pilot light (power) door switch c nc no butt connector 208v 1 220-24...

  • Page 11

    4- all poles disconnect must be provided by the installer rc 1 f , 2 50 v a c m 1 f , 2 50 v a c m m1 f , 2 50 v a c 2 speed 250v 10 b l u c2 brn s b l u 2 b l u 2 b l u 1 b r n c1 blu 17 b l u h5 b r n a5 b r n a6 brn a3 blu a4 brn a4 b r n buzzer timer 2 1 4 s 14 b l k 18 w h t used only on co11-e...

  • Page 12

    1 2 5c. Wiring diagram - coc-e & co11-e (w/fast temperature controller) g-6 board 208/220-240v 1 or 3 phase dwg. U4212q 8/07 2 speed motor lo hi com 6 13 17 30 t4 t3 t2 t1 a2 a1 k 1 l4 l3 l2 l1 three phase tb1 x e y z s1 16 r 3 2 2 5 2 28 z x 27 r 2 2 2 4 1 27 y z 26 r 1 2 2 3 0 26 x y 28 10 s2 s1 1...

  • Page 13

    1 3 5d. Wiring diagram - coc-e & co11-e ce (w/fast temperature controller) e-6 board 230/400v 1 or 3 phase dwg. U4203q 8/07 2 speed motor lo hi com 6 13 17 30 t4 t3 t2 t1 a2 a1 k 1 l4 l3 l2 l1 three phase tb1 x e y z s1 16 r 3 3000 watts 25 28 z x 27 r 2 3000 watts 24 27 y z 26 r 1 3000 watts 23 26 ...

  • Page 14

    Co11-e full size electric convection oven 30 pine street • new rochelle • new york • 10801 914 / 576 - 0200 914 / 576 - 0605 1 - 800 - 431 - 2745 www.Bakerspride.Com fax us & canada web address bakers pride figure a exterior / interior / elements / controls / door e s b r ak e s b r ak r p i e d r p...

  • Page 15

    Co11-e full size electric convection oven 30 pine street • new rochelle • new york • 10801 914 / 576 - 0200 914 / 576 - 0605 1 - 800 - 431 - 2745 www.Bakerspride.Com fax us & canada web address bakers pride exterior / interior / elements / controls / door item part # description item part # descript...

  • Page 16

    Co11-e full size electric convection oven figure b door chain / legs & open rack stand item part # description 30 pine street • new rochelle • new york • 10801 914 / 576 - 0200 914 / 576 - 0605 1 - 800 - 431 - 2745 www.Bakerspride.Com fax us & canada web address bakers pride steam option (not shown)...

  • Page 17

    Coc-e half size electric convection oven 30 pine street • new rochelle • new york • 10801 914 / 576 - 0200 914 / 576 - 0605 1 - 800 - 431 - 2745 www.Bakerspride.Com fax us & canada web address bakers pride figure a exterior / interior / elements / controls / door 1 1 3 3 4 4 5 5 6 6 coo l coo l ow d...

  • Page 18

    Coc-e half size electric convection oven 30 pine street • new rochelle • new york • 10801 914 / 576 - 0200 914 / 576 - 0605 1 - 800 - 431 - 2745 www.Bakerspride.Com fax us & canada web address bakers pride exterior / interior / elements / controls / door item part # description item part # descripti...

  • Page 19

    34 coc-e half size electric convection oven figure b door latch / electrical components item part # description item part # description 30 pine street • new rochelle • new york • 10801 914 / 576 - 0200 914 / 576 - 0605 1 - 800 - 431 - 2745 www.Bakerspride.Com fax us & canada web address bakers pride...

  • Page 20

    20 what is covered this warranty covers defects in material and workmanship under normal use, and applies only to the original purchaser providing that: ♦ the equipment has not been accidentally or intentionally damaged, altered or misused; ♦ the equipment is properly installed, adjusted, operated a...