1. DL manuals
  2. Bakers Pride
  3. Grill
  4. Dante CBBQ-30S
  5. Install And Operation Instructions

Bakers Pride Dante CBBQ-30S Install And Operation Instructions

Manual is about: EQUIPMENT PRICE LIST

Summary of Dante CBBQ-30S

  • Page 1

    Bakers pride oven co., inc . 30 pine street new rochelle, ny 10801 (914) 576-0200 phone (800) 431-2745 us & canada (914) 576-0605 fax www.Bakerspride.Com web address installation and operating instructions outdoor char broilers intended for other than household use models: cbbq-30s & cbbq-60s retain...

  • Page 2: Contents

    Contents section item page 1. Installation instructions a safety precautions 2 b unpacking instructions 3 c assembly 3 d connecting the gas lines to the propane tanks 4 e installing side tank mounting brackets 4 f installing optional tank caddies 5 g leak testing 5 2. Lighting instructions a lightin...

  • Page 3

    Figure “a” 1 2 4 5 7 3 6 instructions must be posted in a prominent location. All safety precautions must be taken in the event the user smells gas. Safety information can be obtained from your local gas supplier. 1. This unit should be only operated outdoors. 2. Lighting: follow the instructions on...

  • Page 4

    Tank brace mounting bracket 20# cylinder figure “a-2” mounting bracket clamp 1/4-20 thumb screws figure “a-1” 1. Remove shipping bands from carton. 2. Remove top of carton. 3. Remove grates from the unit and set them aside. 4. Remove and unwrap any small parts packages that are located underneath th...

  • Page 5

    G. Leak testing: · the plumbing must now be tested for gas leaks before use. Turn all propane tank, burner control and carryover control valves to the off position. Wet all gas line fittings and connectors with a solution of soapy water (or commercial leak disclosing liquid). Slowly open the propane...

  • Page 6

    Figure “c” al g en i nm t a. Cleaning instructions ! Clean the unit regularly after use. ! Top grates: after removing from the unit, use warm soapy water and a stiff bristled brush or plastic pad. Cooking grates must be removed to steam clean or pressure wash. Do not use steel wool or abrasive pads ...

  • Page 7

    Burners & carryover will not turn on burners produce excessive carbon deposits carryover will not remain lit. Excessive flare-up broiler does not seem hot enough grates &/or radiants &/or burners &/or gas valves warp not enough gas to the burners (l.P. Only) regulator freezes (l.P. Only) main gas su...

  • Page 8

    4. Instructions for installing outdoor char broiler accessories your new char broiler has been shipped in several cartons, partly assembled. Please follow the instructions below which detail the assembly of shelves, hoods, wind guards, tank brackets, tank caddy and stand. 2. Clamp the optional side ...

  • Page 9

    9 30 pine street • new rochelle • new york • 10801 914 / 576 - 0200 914 / 576 - 0605 1 - 800 - 431 - 2745 www.Bakerspride.Com fax us & canada web address bakers pride figure a exterior / interior page 2 of 4 note: when ordering, always specify part #, model #, serial #, voltage/phase & type of gas. ...

  • Page 10

    10 bakers pride 30 pine street • new rochelle • new york • 10801 914 / 576 - 0200 914 / 576 - 0605 1 - 800 - 431 - 2745 www.Bakerspride.Com fax us & canada web address cbbq-30s/60s outdoor gas char broiler exterior / interior figure a item part # description item part # description 1 2 3 4 5 6 7 8 9...

  • Page 11

    11 bakers pride 30 pine street • new rochelle • new york • 10801 914 / 576 - 0200 914 / 576 - 0605 1 - 800 - 431 - 2745 www.Bakerspride.Com fax us & canada web address cbbq-30s/60s outdoor gas char broiler 57 82 81 62 58 74 natural 63 80 l.P . 78 83 77 64 65 67 69 66 61 71 76 59 60 79 70 73 75 68 72...

  • Page 12

    12 what is covered this warranty covers defects in material and workmanship under normal use, and applies only to the original purchaser providing that: ♦ the equipment has not been accidentally or intentionally damaged, altered or misused; ♦ the equipment is properly installed, adjusted, operated a...