1. DL manuals
  2. Bakers Pride
  3. Oven
  4. EP-2-2828 Single
  5. Installation And Operating Instructions Manual

Bakers Pride EP-2-2828 Single Installation And Operating Instructions Manual

Manual is about: EQUIPMENT PRICE LIST

Summary of EP-2-2828 Single

  • Page 1

    For your safety: do not store or use flammable liquids or vapors in the vicinity of this or any other appliance. ! ! Bakers pride oven co., inc. 30 pine street new rochelle, ny 10801 +1 (914) 576-0200 phone (800) 431-2745 us & canada +1 (914) 576-0605 fax www.Bakerspride.Com webaddress info@bakerspr...

  • Page 2: Table Of Contents

    2 table of contents section item page 1 dimensions & specifications 3 2 installation 4 counter-top installation 4 floor installation 4 optional open base feature 5 double stacked ovens 6 3 electrical connections 6 4 explanation of controls 7 5 usage recommendations 8 6 troubleshooting 8 7 cleaning 9...

  • Page 3

    1. Dimensions & specifications 28” (711mm) 5.25” (133mm) 42” (1067mm) 2.5” (64mm) 33.25” (845mm) 29” (737mm) note: each oven requires its own supply connection to mains. Ovens are shipped individually. ! ! 3 28” (711mm) 28” (711mm) 208-1 44 9.5 44 208-3 25 9.5 30/31/32 230-1 39 9.5 39 240-1 38 9.5 3...

  • Page 4

    4 2. Installation it is the responsibility of the purchaser to insure the oven is properly installed in a manner that meets all applicable codes. In the absence of local codes refer to applicable national codes. In the case of any discrepancy between this document and any local codes it is recommend...

  • Page 5

    Upper support bracket (2) rack guide (2) bottom shelf 5 the fit of the insert to the leg is intended to be snug, you should expect to tap them lightly in place with a mallet or rubber hammer. Using your fingers screw the ends of the bullet feet into the leg clockwise until they are at their shortest...

  • Page 6

    3. Electrical connections 1 installation must be performed by a licensed electrician. 2 a separate electrical connection to the mains must be provided for each oven. 3 an all pole disconnect must be provided by the installer. 4 connection to the electrical service must be grounded in accordance with...

  • Page 7

    Hook up 7 4. Explaination of controls the oven has a main power switch at the bottom portion of the control panel. This switch must be on for the oven to operate. When switched to the on position the lamps in each cavity light. Each cavity has separate temperature controls. The thermostat dial may b...

  • Page 8

    5. Usage recommendations 1. Pre-heat the oven thoroughly before use. Allow one hour and fifteen minutes for pre-heat. 2. Pre-heat ovens @ 75°f (24°c) desired cook/bake temperature. 3. Do not move baking location in the middle of a bake, but spinning is okay. 4. Keep decks clean of flour, cheese, etc...

  • Page 9

    7. Cleaning when the oven is new, operate it for at least one hour at a setting of at least 500°f (250ºc). Due to normal manufacturing processes, a small amount of steam and/or smoke will exit the oven from moisture and oils on the oven components. Shut off and allow the oven to cool. After cooling ...

  • Page 10

    9. Parts lists & exploded views ep-2-2828 figure 2 doors 10 figure 3 control panel c5029x c5058x u1382x u1395x u1383x m1367x m1368x s1306x m1481x m1352x m1382x m1384x s1311s control panel w/o timer control panel w/timer overlay - no timer overlay - 15 minute timer overlay - 60 minute timer infinite ...

  • Page 11

    Figure 1 main body electrical components see fig 5 doors see fig 2 control panel see fig 3 door hardware see fig 4 1 2 5 6 7 8 9 9 1 2 3 4 5 6 7 8 1 2 4 5 6 1 2 4 3 5 6 7 figure 2 doors figure 3 control panel 11 1 2 3 4 5 6 8 8 7.

  • Page 12

    Figure 4 door hardware 10 9 1 2 3 3 4 5 5 6 6 7 8 figure 4 door hardware 12 figure 5 electric components 1 2 3 4 5 6 7 8 9 figure 5 electric components c5025x p1003x p1207x m1371x m1372x m1482x m1360x p1018x p1192x p1208x p1201x component bracket terminal block - 3 pos din rail contactor - 208v cont...

  • Page 13

    Wiring diagram ep-2-2828 230/400, 50hz wiring diagram ep-2-2828 230/400, 50hz 13 upper oven optional single phase three phase tb1 s1 cb3 cb1 l 2 l 1 k 4 k 3 3 1 5 7 9 11 2 3 1 5 7 9 11 2 19 21 33 22 14 org blu yel terminate wht & red 55 57 53 7 11 3 58 56 54 58 12 56 54 89 91 92 53 57 10 55 32 87 88...

  • Page 14

    Wiring diagram ep-2-2828 208/240, 60hz (domestic) wiring diagram ep-2-2828 208/240, 60hz (domestic) 14 upper oven s1 cb3 cb1 l 2 l 1 19 21 33 22 14 red 208v org 240v blu yel terminate white and unused 55 57 53 7 11 3 58 56 54 32 cb2 49 51 47 5 9 13 52 50 48 48 30 73 45 28 34 27 29 45 th 4 t2 th 2 23...

  • Page 15

    Wiring diagram ep-2-2828 480v, 60hz, 3ph wiring diagram ep-2-2828 480v, 60hz, 3ph 15 u4189a upper oven s1 cb3 cb1 l 2 l 1 19 21 33 22 14 org blu yel terminate white and red 55 57 53 7 11 3 58 56 54 32 cb2 49 51 47 5 9 35 52 50 48 48 30 73 45 28 34 27 29 45 th 4 t2 th 2 23 29 19 15 17 31 31 blk h1 l1...

  • Page 16

    16 bakers pride limited warranty 30 pine street new rochelle, new york 10801 914 / 576 - 0200 • us & canada: 1 - 800 - 431 - 2745 • fax 914 / 576 - 0605 bco models: one (1) year limited parts and labor; (1) year limited door warranty. Gdco models: two (2) year limited parts and labor; (2) year limit...