1. DL manuals
  2. Barbeques Galore
  3. Grill
  4. downunder G2DLK
  5. Instructions Manual

Barbeques Galore downunder G2DLK Instructions Manual

Summary of downunder G2DLK

  • Page 1

    2 burner solid hotplate barbeque with folding legs (g2dlk) instructions for safe use and enjoyment of your new barbeque.

  • Page 2

    Important health & safety information 1. Warning for outdoor use only ! Do not use indoors • please read these instructions carefully prior to assembly and use. • failure to follow these instructions could lead to serious injury and/or significant damage to property. • do not start the barbeque if t...

  • Page 3

    4. Precautions before first time operation and after each gas cylinder exchange/refill all connections should be checked for gas leaks • connections can be checked for leaks by using a soapy water solution as described in section 4 precaitionary leak test. • naked flames (matches or other open flame...

  • Page 4: Assembly Instructions

    Assembly instructions parts list 1 2 3 4 5 6 7 8 item description quantity picture 1 4 4 2 1 1 2 1 1 fire-box assembly leg support bracket leg leg cross brace gas cylinder hook heat insulation panel handle grease cup regulator and hose 9 part #.

  • Page 5: Assembly Instructions

    Assembly instructions fasteners item descirption quanitity picture a m6 x 12mm short phillips head screw 12 b m6 steel washers 12 c m6 nuts 8 d m6 wing nuts 4 e m6 x 40mm long phillips head screw 12 f m6 x 16mm medium phillips head screw 4 part #.

  • Page 6: Assembly Instructions

    Assembly instructions step 1. Step 2. Attach the legs (3) to the leg support bracket (2) using long screws (e), washers (b), nuts (c) and wingnuts (d). Then attach the leg cross brace using (e), (b) and (c). Attach the four leg support brackets (2) to the firebox (1) using screws (a). Eight of the n...

  • Page 7

    Attach the gas cylinder hook (5) and heat insulation panel (6) at the same time using short screws (a). Four of the nuts (closest to the heat insulation panel) are pre-installed for your convenience. Step 4 attach the handles (7) from underneath using screws (f) and washers (b). Step 3 4pcs 4pcs b f...

  • Page 8

    Hang the grease cup onto its hook underneath the two burners. Full assembly. Step 5.

  • Page 9: Setting Up The Barbeque

    Setting up the barbeque this appliance shall only be used in an above ground open air situation with natural ventilation, without stagnant areas, where gas leakage and products of combustion are rapidly dispersed by wind and natural convection 1. Positioning • please make sure that the barbeque is n...

  • Page 10

    2. Precautions d do not obstruct any airflow path or ventilation paths of the barbeque • do not obstruct any ventilation ports on the body of the barbeque. • the gas cylinder must be securely placed on the gas cylinder hook as supplied. • it is important that the gas cylinder is not positioned under...

  • Page 11: Operating Your Barbeque

    Operating your barbeque 1. Warnings: • before using the barbeque please ensure you have read and understood the entire instructions manual. 2. Prior to cooking: • it is advisable to wash the cooking surface with soapy water, then apply a light coating of cooking oil before starting to cook. • when y...

  • Page 12: Care & Maintenance

    Care & maintenance before any care and maintenance is attempted please ensure that the barbeque controls are in the ‘off’ position and that all surfaces have been given sufficient time to cool down. Please note the following when maintaining and caring for your barbeque: • cleaning your barbeque reg...

  • Page 13: Troubleshooting Guide

    Troubleshooting guide problem potential cause corrective action cannot light burners gas cylinder is empty check and refill/exchange gas cylinder regulator is faulty check and replace if required blocked burner check and clean all burner holes blocked gas jets check and clean gas jets blocked gas ho...

  • Page 14: Technical Specifications

    Technical specifications model bgw2nh007h gas type propane only burner injector size 1.0mm burner gas consumption 12.4 mjhr burner gas pressure 2.75 kpa total gas consumption 24.8 mjhr approval number gmk 10011 barbeque dimension (lxwxh) 536mm x 746mm x 794mm air is admitted from the ventilation hol...