Manual # p80151035a - date:2011/01/21 failure to comply with these instructions could result in a fire or explosion that could cause serious bodily injury, death or property damage. Whether this grill was assembled by you or someone else, you must read this entire manual before using your grill to e...
Table of contents primary safety warnings............................1-3 pre-assembly instructions................................3 part diagrams and lists............................4-20 assembly instructions.................................21-29 use & care instructions: • gas safety and leak tests...
Pre-assembly instructions for your safety warning caution ! ! Failure to comply with these instructions may result in a hazardous situation which, if not avoided, may result in injury. For safe operation ensure the gas valve assembly orifice is inside the burner tube before using your grill. See fig...
Hardware parts list for models sts2611alp/ng & sts3211alp/ng 4 hardware diagram for models sts2611alp/ng & sts3211alp/ng phillips head screw 3/16"x3/8" qty. 14 (for sts2611alp & sts3211alp) qty. 8 (for sts2611ang & sts3211ang) part # s112g0306e phillips head screw 1/4"x3/8" qty. 8 (for sts2611alp/ng...
5 hardware parts list for models sts2611alp & sts2611blp flange nut 1/4" qty. 8 (for sts2611blp) part # s313g04081 phillips head screw 1/4"x3/8" qty. 12 (for sts2611blp) part # s112g0406e hardware diagram for models sts2611alp & sts2611blp phillips head screw 3/16"x3/8" qty. 4 (for sts2611blp) part ...
Hardware parts list for models sts3211alp & sts3211blp phillips head screw 1/4"x3/8" qty. 12 (for sts3211blp) part # s112g0406e hardware diagram for models sts3211alp & sts3211blp 6 *one battery/aa included in the hardware pack (for sts3211alp & sts3211blp) pan head screw 1/4"x3/8" qty. 2 (for sts32...
7 hardware diagram for models sts2611ang & sts2611bng hardware pack for models sts2611ang & sts2611bng phillips head screw 3/16"x1/2" qty. 3 (for sts2611bng) part # s112g0308e flange nut 1/4" qty. 8 (for sts2611bng) part # s313g04081 phillips head screw 1/4"x3/8" qty. 12 (for sts2611bng) part # s112...
Parts diagram for models sts2611alp/ng 8 78 61 31 10b 25 26 20 19 18 23 37b 21 56a 22 70 69 68 67 66 65 54 57 55 56b 58 52 50 48 62 59 46 53 64 45b 51 47 45a 49 62 64 60 44 73 17 75 72 74 13 15 16 14 77 76 40 39 38 37a 36 71 4 5 3 6 2 1 34 41 29 35 30 27 28 24 22 43 42 10a 8 7 9 11 12 32 33 32 76a 3...
Parts list for model sts2611alp/ng 9 key description part# qty 1 lid as s embly p001462764 1 2 temperature gauge p00601071a 1 3 lid handle bracket, left p03303124a 1 4 lid handle bracket, right p03303125a 1 5 lid handle p00218001r 1 6 protective pad p05518002i 4 7 cooking rack/secondary p01505009k 1...
Parts list for models sts2611alp/ng 10 key description part# qty 48 cart side panel, right p076180494 1 49 door hinge bracket, upper left p033020144 1 50 door hinge bracket, upper right p033020154 1 51 door hinge, left/lower p033020374 1 52 door hinge, right/lower p033020384 1 53 cart bracket, front...
11 parts diagram for models sts3211alp/ng 14 12 9 7 71 1 2 11a 10 54 65 66 47 48 13 6 16 19 21 26 27 32 31 15 20 35 39 33 46 38 70 3 5 4 68 85 70 68 8 40 41a 42 43 44 45 81 82 26 51 49a 53 55 49b 50 64 63 57 56 58 52 62b 61 60 67 59 72 73 74 75 76 77 78 79 80 83 84 62a 37 23 30 30 30 41b 29 87 88 89...
Parts list for models sts3211alp/ng 12 key description part# qty 1 lid as s embly p001473364 1 2 temperature gauge p00601071a 1 3 lid handle bracket, left p03303124a 1 4 lid handle bracket, right p03303125a 1 5 lid handle p00218002r 1 6 protective pad p05518002i 4 7 cooking rack/secondary p01516004b...
13 parts list for models sts3211alp/ng important: use only grand hall replacement parts. The use of any part that is not a grand hall replacement part can be dangerous and will also void your product warranty. Keep this operator's manual for convenient referral and for part replacement. For the repa...
Parts diagram for models sts2611blp/ng 14 12 11 9 7 8 10a 42 43 22 24 28 27 30 35 29 41 34 1 2 6 3 5 4 44 36 37a 38 39 40 51 53 14 16 15 13 49 46 48 17 47 22 33 37b 23 18 19 20 26 50 10b 31 55 21 25 54 52 51a 45 32.
Parts list for models sts2611blp/ng 15 key description part# qty 1 lid as s embly p001462764 1 2 temperature gauge p00601071a 1 3 lid handle bracket, left p03303124a 1 4 lid handle bracket, right p03303125a 1 5 lid handle p00218001r 1 6 protective pad p05518002i 4 7 cooking rack/secondary p01505009k...
Parts list for models sts2611blp/ng 16 key description part# qty 46 rotis s erie burner wind shield p069060824 1 47 therm ocouple for rotis s erie burner p05305062a 1 48 rotis s erie burner electrode p02614025a 1 49 rotis s erie burner fram e p020110654 1 50 electric ignitor protector p03328048q 1 5...
17 parts diagram for models sts3211blp/ng 62 61a 14 12 9 7 36 1 2 11a 10 47 48 13 6 16 17 19 21 26 27 32 31 15 59 20 35 39 33 46 38 3 5 4 8 40 41a 42 43 44 45 26 30 50 52 51 54 57 37 41b 29 18 58 49 55 53 60 23 61 11b 22 56 34 65 66 24 64 63 25 28.
Parts list for models sts3211blp/ng 18 key description part# qty 1 lid as s embly p001473364 1 2 temperature gauge p00601071a 1 3 lid handle bracket, left p03303124a 1 4 lid handle bracket, right p03303125a 1 5 lid handle p00218002r 1 6 protective pad p05518002i 4 7 cooking rack/secondary p01516004b...
19 parts list for models sts3211blp/ng important: use only grand hall replacement parts. The use of any part that is not a grand hall replacement part can be dangerous and will also void your product warranty. Keep this operator's manual for convenient referral and for part replacement. For the repa...
Rotisserie assembly parts diagram rotisserie assembly parts list hardware for rotisserie rot. Screw#10-24x3/4" unc qty. 2 part # s112g10124 rot. Thumbscrew 1/4"x1/2" qty. 3 part # s196g04084 rot. Washer 3/16" qty. 2 part # s411g03084 rot. Nut.#10-24 qty. 2 part # s362g10124 key part# description qty...
21 assembly instructions for sts2611alp/ng & sts3211alp/ng caution : while it is possible for one person to assemble this grill, obtain assistance from 2 people when handling some of the larger, heav ier pieces. Install tank holder brackets and tank holder assembly (for sts2611alp & sts3211alp model...
4 install bowl to the cart with the help of your assistants, lift the bowl on to the top of the cart so that the bottom of the bowl sits on top of the bowl brackets. Insert the 4 pan head screws 1/4"x1-3/16"(reserved from step 2) into the cart as shown below. Tighten and secure the screws. Replace t...
23 6-1 install hose holders (for sts2611alp & sts3211alp models) install 2 hose holders on the left cart side and rear panels, secure using 4 phillips head screws 3/16"x3/8" and 4 flange nuts 3/16". The regulator hose should sit inside the hose holders. 6-2 install ng regulator, hose holder, and 12 ...
Install ignitor battery remove ignitor cap from control panel. Place supplied aa battery into the ignitor slot with positive pole facing you. Position the cap and spring over the aa battery and tighten onto control panel. 8 ignitor cap ignitor slot aa battery spring 24 install the transformer. Conne...
Assembly instructions for sts2611blp/ng & sts3211blp/ng caution : while it is possible for one person to assemble this grill, obtain assistance from 2 people when handling some of the larger, heav ier pieces. 1 install bowl side trim brackets install left bowl side trim bracket to left bowl panel us...
4 install ng regulator and 12 foot hose install the ng regulator onto the regulator bracket using 2 phillips head screws 3/16"x1/4". Connect ng gas fitting with hose to the gas manifold. Install the ng regulator bracket to your rear island panel using 3 phillips head screws 3/16" x 1/2" and tighten ...
5 remove the lp regulator and install the regulator hose connector remove the lp regulator from the manifold as shown in figure 1. Install the regulator hose connector to the lp regulator hose as shown in figure 2. Figure 1 figure 2 regulator hose connector caution: build your grill island before in...
28 install ignitor battery remove ignitor cap from control panel. Place supplied aa battery into the ignitor slot with positive pole facing you. Position the cap and spring over the aa battery and tighten onto control panel. 8 install the partition panel (not included in this unit) to the left islan...
29 infrared burner (for sts3211alp/ng & sts3211blp/ng models) and rotisserie burner electrode check 10 push and turn infrared burner control knob & rotisserie burner control knob to . Look for spark between electrode tip and spark receiver tip. If you don't see a spark from infrared burner electrode...
30 use and care instructions correct lp gas tank use the lp gas tank must be constructed and marked in accordance with the specifications for lp-gas cylinders of the u.S. Department of transportation (d.O.T.) or the national standard of canada, can/csa-b339, cylinders, spheres and tubes for transpor...
31 use and care instructions ! Warning ! Refer to the this table when designing the island unit for the sts2611blp/ng & sts3211blp/ng. Side* and rear* show the minimum amount of distance the unit must be from combustibles (ex. Vinyl or wood siding, fences and overhangs) or sources of ignition (ex. P...
Use and care instructions 32 note: the built-in appliance for use with a remote self-con- tained lp gas supply system must use rigid pipe. Semi- rigid tubing or a connector complying with the standard for connections for gas appliance, znsi z21.24/csa 6.10 one nut is fixed to tank holder. An additio...
33 warning ! Lp gas model only: connect regulator with hose to your lp gas tank turn all burner valves to the off position. Inspect the valve connection port and regulator assembly for damage or debris. Remove any de- bris. Never use damaged or plugged equipment. Connect the regulator assembly to th...
34 natural gas connection natural gas model only: connecting natural gas to your grill check all connections for natural gas leaks never test for leaks with an open flame. Prior to first use and at the beginning of each season, you must check for gas leaks. Follow these three steps: make a soap solu...
Use and care instructions 35 rotisserie burner lighting instructions follow steps 1 through 5 of the grill lighting instruc- tions. Push and turn control knob to and hold knob in. Keep pressing while you turn knob to and hold in 5 - 10 seconds before releasing. If ignition does not occur in 5 second...
Use and care instructions if ignition does not occur in 5 seconds, turn the control knob(s) and gas source off and conduct a leak test as explained in the use and care section of this guide. If no leaks are detected, wait 5 minutes for any gas to clear and repeat the lighting procedure. Warning ! ! ...
Use and care instructions 37 correct rotisserie use read all instructions before initial use. Important: when using electrical appliances, basic safety precautions should always be used. The rotisserie motor is set for 120v, 60hz ac current. The rotisserie is for outdoor use only. Do not equip your ...
38 rotisserie instructions 1. Remove all components from the carton. Attach the motor bracket on the outside of the right grill bowl panel. Align the two holes of the bracket with the holes on the grill bowl. Tighten securely using two screws #10-24x3/4" unc, plain washers and nuts provided. 2. Slid...
39 install the ac (alternating current) rotisserie motor onto the motor bracket as shown below. Be sure the motor attaches to the bracket with the electrical cord down. This installation insures that once the spit is inserted into the motor it will also rest securely into the slot of your grill bowl...
Proper care and maintenance will keep your grill in top operating condition and prolong its life. Follow these cleaning procedures on a timely basis and your grill will stay clean and operate with minimum effort. Caution: be sure your grill is off and cool before cleaning. Cleaning exterior stainles...
To reduce the chance of flashback fire you must clean the burner tubes as follows at least once a month in summer and fall or whenever spiders are active in your area, and if your grill has not been used for an extended period of time. Regardless of which burner cleaning procedure you use, we recomm...
A-1 cooking instructions preheating Ÿ Ÿ Ÿ the fats and juices dripping from grilled food can cause flare-ups which impart a favorably, distinctive taste and color to food. They should be accepted up to a point. To minimize flare-ups: trim excess fat from meats and poultry preheat the grill properly ...
A-2 guide to grilling using the main burners and direct cooking method grilling steak and ribs turn the grill burners on hi, close the lid and preheat your grill 3 to 5 minutes. Open lid and place the meat on the cooking grid directly above the lit burners. Cook the meat on both sides until seared. ...
A-3 guide to searing using the infrared cooking zone searing steak and ribs turn the infrared burner on hi and preheat for 3 to 5 minutes with the lid open. Then place the meat on the cooking grid and sear each side for approximately 2 minutes. Reduce the infrared burner to low or move meat to the p...
A-4 type of food beef lamb veal pork chicken duck fish turkey, under 16 pounds turkey, over 16 pounds how cooked rare medium well done medium well done approximate cooking times 18 minutes per pound 23 minutes per pound 27 minutes per pound 18 minutes per pound 23 minutes per pound 27 minutes per po...
A-5 vegetables are generally easy to cook on the grill. The secondary cooking rack makes it convenient because you can still use the main cooking area while the vegetables are suspended above the grids. Pre-cook hard vegetables by briefly boiling or microwaving them before cooking on the grill. Wrap...
F r e q u e n t l y a s k e d q u es t io n s (f a q 's) a-6 question: sometimes i hear a humming sound coming from my regulator. What causes this? And - my grill has a low flame and sometimes will not light. Why? Answer: the humming sound is gas flowing through the regulator. A low volume of sound ...
A-7 you may also review faq’s, troubleshooting and care & maintenance tips online at www.Grandhall.Com. After every use (after your grill has cooled down), wipe stain- less surfaces with a soft, soapy cloth or sponge then rinse with water. Be sure to remove all food particles, sauces or marinades fr...
A-8 barbeques galore will warrant to the original purchaser of this gas grill that it will be free of defects in material and workmanship for set periods below from the date of purchase when used under normal outdoor use and correct assembly. - burners, cooking grids - 5 year limited warranty (no ru...
