1. DL manuals
  2. Bartell
  3. Trowels
  4. B430
  5. Owner's Manual

Bartell B430 Owner's Manual

Other manuals for B430: Owner's Manual And Parts Book
Manual is about: WALK-BEHIND POWER TROWEL

Summary of B430

  • Page 1

    Walk-behind power trowels b430 b436 b436e b436sd b440 b446 doc. # oi-b09001 orig. Rel. - 05-2010 curr. Rev. - 00 rev. Date - 05-2010 bartell morrison inc. 375 annagem blvd., mississauga, on, canada l5t 2a7 toll free (n.A.): 1 866 501 1683 local: +1 905 364 4200 fax: +1 905 364 4201 owner’s manual ba...

  • Page 2

    Bartell morrison inc. Bartell morrison (usa) llc 375 annagem blvd. 12 industrial drive, mississauga, ontario, canada keyport, new jersey, usa l5t 3a7 07735 toll free (n.A.): (866) 501-1683 toll free: 888-999-1570 phone: (905) 364-4200 phone: (732) 566-5400 facsimile: (905) 364-4201 facsimile: (732) ...

  • Page 3: Danger

    Walk behind power trowel instruction manual 375 annagem blvd., mississauga, ontario, canada l5t 3a7, 905-364-4200 fax 905-364-4201 created: 07/04 revised: 05/10 safety precautions danger explosion hazard never operate the machine in an explosive atmosphere, near combustible materials or where ventil...

  • Page 4

    Walk behind power trowel instruction manual table of contents quality assurance/machine break-in .......................................................................................................4 walk-behind power trowel warranty ...................................................................

  • Page 5: Artell

    Walk behind power trowel instruction manual quality assurance / machine break in the bartell walk-behind power trowel is the product of extensive engineering development designed to give long life and unmatched performance. The walk-behind power trowels are shipped partially assemble, and only requi...

  • Page 6

    Walk behind power trowel instruction manual walk-behind power trowel warranty all products sold by bartell morrison inc. And bartell morrison (usa) llc (the “company”) are warranted against defects in materials and/or workmanship; excluding normal wear on wearing components and components covered by...

  • Page 7

    Walk behind power trowel instruction manual maintenance record preventative maintenance and routine service plan this walk-behind power trowel has been assembled with care and will provide years of service. Preventative maintenance and routine service are essential to the long life of your power tro...

  • Page 8: Routine Service

    Walk behind power trowel instruction manual routine service intervals each use after 1.5 months or 50 hrs each 3 months or 100 hrs each 6 months or 200 hrs each 9 months or 300 hrs each 12 months or 400 hrs general inspection: guards check o o o o o warning stickers check o o o o o test run: check o...

  • Page 9: Artell

    Walk behind power trowel instruction manual routine service intervals due to the nature and environment of use, walk-behind power trowels could be exposed to severe operating conditions. Some general maintenance guidelines will extend the useful life of your trowel. The initial service for your powe...

  • Page 10

    Walk behind power trowel instruction manual safety precautions always keep unauthorized, inexperienced, untrained people away from this machine. Rotating and moving parts will cause injury if contacted. Make sure guards are in place. Keep hands and feet away from moving parts. Fuel the machine only ...

  • Page 11

    Created: 07/04 revised: 06/13 375 annagem blvd., mississauga, ontario, canada, l5t 3a7, 905-364-4200 fax 905-364-4201 25 industrial drive, keyport, new jersey, usa, 07735, 732-566-6400 fax 732-566-5444 walk-behind trowel instruction manual setup procedure step 1: trowel shown with handle separate. (...

  • Page 12

    Created: 07/04 revised: 06/13 375 annagem blvd., mississauga, ontario, canada, l5t 3a7, 905-364-4200 fax 905-364-4201 25 industrial drive, keyport, new jersey, usa, 07735, 732-566-6400 fax 732-566-5444 walk-behind trowel instruction manual step 5: unwrap throttle control and engine safety shut-off w...

  • Page 13

    Created: 07/04 revised: 06/13 375 annagem blvd., mississauga, ontario, canada, l5t 3a7, 905-364-4200 fax 905-364-4201 25 industrial drive, keyport, new jersey, usa, 07735, 732-566-6400 fax 732-566-5444 walk-behind trowel instruction manual step 10: secure the wire to the cable clamp while pushing wi...

  • Page 14

    Walk behind power trowel instruction manual operation (floating) when the slab has set sufficiently firm that the operator’s footprint leaves a very slight depression on the surface of the slab, it is ready for the floating operation. Under normal operating conditions the machine should cover as muc...

  • Page 15

    Walk behind power trowel instruction manual storage the following steps should be taken to prepare your walk-behind power trowel for extended storage. 1. Close fuel shut off valve. 2. Siphon excess gasoline from tank. 3. Start engine until it stops from lack of fuel. This will use up all the fuel in...

  • Page 16

    The electric models of bartell power trowels require appropriate power sources, connections, extension cords, and surge protection. Bartell morrison inc. Is not responsible for damage to person or property due to improper use or setup of an electric power trowel. Select your power supply and other p...

  • Page 17

    Walk behind power trowel instruction manual while the trowel should be cleaned daily, and the electronic components are splash-resistant, avoid spraying water or other liquids directly on the motor, starter box, or handle controls, as this can damage the electronics. Never immerse the trowel in wate...

  • Page 18

    Walk behind power trowel instruction manual 1. Plug the trowel into the electrical supply. If the line power is on, the green power indicator lamp on the top of the trowel will glow. 2. Turn the master starter switch clockwise to the on (vertical) position. If it will not stay in the on position, th...

  • Page 19

    Walk behind power trowel instruction manual electric power trowel wiring diagram: 16 375 annagem blvd., mississauga, ontario, canada l5t 3a7, 905-364-4200 fax 905-364-4201 created: 07/04 revised: 05/10 control box pin2 pin1 pin3 control plug safety switch st op st ar t 1 3 2 4 com no deadman off g w...

  • Page 20

    Walk behind power trowel instruction manual the trowel arm adjustment fixture (20801) is reversible. By rotating the arm clamping fixture and the ring bolt, both left hand and right hand trowel arms may be adjusted. Before attempting adjustment, determine whether the trowel arm is right handed or le...

  • Page 21

    Walk behind power trowel instruction manual troubleshooting won’t start • throttle fully open • hand lever wire broken • no gas • dirty gas • gas filter plugged • gas line plugged • hole in gas line • gas supply valve turned off • dead-man safety switch • safety switch wire or connectors not making ...

  • Page 22

    Walk behind power trowel instruction manual specifications walk-behind trowel model path power source (gas option) float blade size finish trowel size combination blade size float pan operating weight b430 30" (75 cm) 5.5 hp honda ohv n/a 6” x 10-1/2" (15 x 27 cm) n/a n/a up to 165 lb. (75 kg) b436 ...

  • Page 23

    Walk behind power trowel instruction manual we: bartell morrison inc. Bartell morrison (usa) llc. 375 annagem blvd. 12 industrial drive mississauga, ontario, canada keyport, new jersey, united states of america l5t 3a7 07735 tel: 905-364-4200 fax: 905-364-4201 tel: 732-566-5400 fax: 732-566-5444 dec...

  • Page 24

    Walk behind power trowel instruction manual technical characteristics: caractéristiques techniques: technisch gegevens: características técnicas: caracteristicas técnicas : qualit às di tecnico : model modéle type modelo modelo modello machineserial number numéro de série machine serienummer machine...

  • Page 25

    Walk behind power trowel instruction manual notes 22 375 annagem blvd., mississauga, ontario, canada l5t 3a7, 905-364-4200 fax 905-364-4201 created: 07/04 revised: 05/10 06/13 375 annagem blvd., mississauga, ontario, canada, l5t 3a7, 905-364-4200 fax 905-364-4201 25 industrial drive, keyport, new je...

  • Page 26

    Walk behind power trowel instruction manual 23 375 annagem blvd., mississauga, ontario, canada l5t 3a7, 905-364-4200 fax 905-364-4201 created: 07/04 revised: 05/10 06/13 375 annagem blvd., mississauga, ontario, canada, l5t 3a7, 905-364-4200 fax 905-364-4201 25 industrial drive, keyport, new jersey, ...

  • Page 27

    Bartell morrison inc. 375 annagem blvd. Mississauga, ontario, canada l5t3a7 toll free: 866-501-1683 local: 905-364-4200 fax: 905-364-4202 www.Bartellmorrison.Com bartell morrison (usa) llc. 12 industrial drive. Keyport, new jersey, usa 07735 toll free: 888-999-1570 local: 732-566-5400 fax: 732-566-5...