1. DL manuals
  2. Bukh
  3. Engine
  4. DV36 ME
  5. Owner's Handbook Manual

Bukh DV36 ME Owner's Handbook Manual

Manual is about: Bukh Marine Diesel Lifeboat Engine

Summary of DV36 ME

  • Page 1

    009w0327-r03 owner's handbook for bukh marine diesel lifeboat engine type dv36 me bukh a/s aabenraavej 13 - 17 dk - 6340 krusaa tel: +45 74 62 20 88 fax: +45 74 62 74 07 e-mail: bukh@bukh.Dk www.Bukh.Dk.

  • Page 2

    Operating manual for bukh dv36me engines 009w0327-r03 - 2 - contents page pictures for recognition of engine ................................................ 3 introduction .................................................................................. 4 standard equipment ..........................

  • Page 3

    Operating manual for bukh dv36me engines 009w0327-r03 - 3 - 1. Lubricating oil filling plug 2. Valve cover 3. Electric stop solenoid 4. Air filter with noise suppression 5. Fuel filter 6. Cooling water drain plug 7. Dipstick for engine oil 8. Oil pressure switch 9. Lubricating oil filter 10. Fuel pu...

  • Page 4

    Operating manual for bukh dv36me engines 009w0327-r03 - 4 - introduction basic engine configuration: the bukh marine diesel engine is a four-stroke marine diesel engine with direct fuel injection and the following basic equipment: crankcase with oil pan, one-piece cylinder head with 2 valves per cyl...

  • Page 5

    Operating manual for bukh dv36me engines 009w0327-r03 - 5 - preparation before first start 1. Pour lubricating oil through filling hole on top of valve cover. Check that oil level is between the marks on the dipstick, placed at the port side of the engine. Check oil level as mentioned below: a) remo...

  • Page 6

    Operating manual for bukh dv36me engines 009w0327-r03 - 6 - after start 1. When the engine has started, the rpm should be 900-1000 rpm when idling. 2. Check the oil pressure. Normally this should be 2-4.5 bar. With cold engine the rpm should be kept down so that the oil pressure does not exceed 4.5 ...

  • Page 7

    Operating manual for bukh dv36me engines 009w0327-r03 - 7 - fuel lift pump the fuel lift pump is a cam shaft driven sealed type diaphragm pump, which cannot be dismantled for repair or cleaning. It is recommended to install a water/dirt accumulating filter in the suction line to the pump. After repa...

  • Page 8

    Operating manual for bukh dv36me engines 009w0327-r03 - 8 - freshwater cooling when using freshwater cooling it will be possible to reach a higher operating temperature of 70-95°c which will prolong the life of the engine. This cooling system is recommended for engines operating for more than 500 ho...

  • Page 9

    Operating manual for bukh dv36me engines 009w0327-r03 - 9 - propeller equipment (as supplied by bukh – for other types consult individual manufacturer’s instructions) flexible stern tube: every three years replace the three seal rings in the stuffing box “a” and the rubber hose “b” connecting stuffi...

  • Page 10

    Operating manual for bukh dv36me engines 009w0327-r03 - 10 - galvanic corrosion to avoid corrosion of the propeller due to galvanic action it is advisable to fit a sacrificial zinc anode on the outside of the hull. To obtain a high degree of protection, electrical contact between sacrificial zinc (a...

  • Page 11

    Operating manual for bukh dv36me engines 009w0327-r03 - 11 - winter storage of the engine 1. Carry out the following whilst the boat is still in the water: 1. Run the engine until normal workingtemperature is reached. 2. Drain off engine and gear oil with the oil bilge pump. 3. Fill the engine and g...

  • Page 12

    Operating manual for bukh dv36me engines 009w0327-r03 - 12 - technical main data dv36me working principle………………………………………………………………………..…4-stroke number of cylinders ................. ........................................ ...................................... 3 cylinder bore/stroke ..................

  • Page 13

    Operating manual for bukh dv36me engines 009w0327-r03 - 13 - recommended maintenance and a check list for bukh engines 1. Tightness of connections through hull: check rectify if needed w e e k l y m o n t h l y y e a r l y every 5 years 1.1 s tern tube hull connection change sealing x 2. Check of lu...

  • Page 14

    Operating manual for bukh dv36me engines 009w0327-r03 - 14 - irregular operation - causes and remedies 1. Engine does not start symptom cause remedy insufficient or very little compression inlet and/or exhaust valves leaking grind or replace the valves, mill the seats inlet and/or exhaust valves sti...

  • Page 15

    Operating manual for bukh dv36me engines 009w0327-r03 - 15 - lubricating oil chart lubricating oil for engine: temp range auxili- aries oil company oil type hd oil grade & quality belo w – 15 o c belo w 5 o c 5 o c – 25 o c above 2 5 o c prm12 0 ge ar ( atf) stern tube (flex ible) bp oil visco 5000 ...

  • Page 16

    Operating manual for bukh dv36me engines 009w0327-r03 - 16 -.

  • Page 17

    Operating manual for bukh dv36me engines 009w0327-r03 - 17 - installation: dv36.

  • Page 18

    Operating manual for bukh dv36me engines 009w0327-r03 - 18 - bukh distributors – worldwide fiala & cia. S.R.L. Av. Presidente roque saenz peña 710 piso 3º “d” 1035 buenos aires argentina tel: +54-11-4328-1474 / 6280 fax: +54-11-4328-2838 e-mail: info@fialaycia.Ar bukh diesel australia pty. Ltd. P.O....

  • Page 19

    Operating manual for bukh dv36me engines 009w0327-r03 - 19 - montmontaza greben d.O.O. Obala 4 br. 50 20270 vela luka croatia tel: +385-20-812-028 fax: +385-20-813-354 e-mail: sales@greben.Hr website: www.Greben.Hr imocom ecuatoriana cia. Ltda. Casilla 17-17-292 quito ecuador tel: +593-2-447662 fax:...

  • Page 20

    Operating manual for bukh dv36me engines 009w0327-r03 - 20 - scandiesel via coloredo 38 28069 trecate (no) italy tel: +39-0321-777880 fax: +39-0321-777959 e-mail: info@scandiesel.It website: www.Scandiesel.It contact: attilio origo, tiziana dellera mizuno marine co ltd 1-12-15 meishinguchi toyonaka-...

  • Page 21

    Operating manual for bukh dv36me engines 009w0327-r03 - 21 - civic international pte ltd 38 benoi place singapoe 629952 singapore tel: +65-6861-7633 fax: +65-6861-5069 e-mail: chee_keong_chia@civic.Com.Sg e-mail: civicint@singnet.Com.Sg contact: chia chee keong / han jock kwong keppel sea scan pte l...

  • Page 22

    Operating manual for bukh dv36me engines 009w0327-r03 - 22 - general terms of sale and delivery 1. Introduction the terms of sale and delivery specified below shall apply to all quotations, orders and consignments unless otherwise specified in any other written agreement. 2. Quotations quotations sh...