- DL manuals
- Bukh
- Engine
- DV48 RME
- Owner's Handbook Manual
Bukh DV48 RME Owner's Handbook Manual
Summary of DV48 RME
Page 1
009w4226-r10 20-02-2014 owner's handbook for bukh marine diesel lifeboat engine type dv48 rme bukh a/s aabenraavej 13 - 17 dk - 6340 krusaa tel: +45 74 62 20 88 fax: +45 74 62 74 07 e-mail: bukh@bukh.Dk www.Bukh.Dk.
Page 2
Operating manual for bukh dv48rme lifeboat engines 009w4226-r09 - 2 - contents page pictures for recognition of engine ................................................. 3 introduction ................................................................................... 4 standard equipment ..............
Page 3
Operating manual for bukh dv48rme lifeboat engines 009w4226-r09 - 3 - 1. Lubricating oil filter 2. Oil pressure switch 3. Cooling water drain plug 4. Fuel filter 5. Dipstick for engine oil 6. Electric stop solenoid 7. Valve cover 8. Lubricating oil filling plug 9. Lifting fittings 10. Fuel lift pump...
Page 4
Operating manual for bukh dv48rme lifeboat engines 009w4226-r09 - 4 - introduction basic engine configuration: the bukh lifeboat engine is a four-stroke marine diesel engine with direct fuel injection and the following basic equipment: crankcase with oil pan, one-piece cylinder head with 2 valves pe...
Page 5
Operating manual for bukh dv48rme lifeboat engines 009w4226-r09 - 5 - preparation before first start 1. Pour lubricating oil through filling hole on top of valve cover. Check that oil level is between the marks on the dipstick, placed at the port side of the engine. Check oil level as mentioned belo...
Page 6
Operating manual for bukh dv48rme lifeboat engines 009w4226-r09 - 6 - after start 1. When the engine has started, the rpm should be 900-1000 rpm when idling. 2. Check the oil pressure. Normally this should be 2-4.5 bar. With cold engine the rpm should be kept down so that the oil pressure does not e...
Page 7
Operating manual for bukh dv48rme lifeboat engines 009w4226-r09 - 7 - fuel lift pump the fuel lift pump is a cam shaft driven sealed type diaphragm pump, which cannot be dismantled for repair or cleaning. It is recommended to install a water/dirt accumulating filter in the suction line to the pump. ...
Page 8
Operating manual for bukh dv48rme lifeboat engines 009w4226-r09 - 8 - frost precautions as protection against corrosion and to secure the cooling water freezing temperature to min. Minus 15° celsius as per imo/solas requirement or lower if required from climate conditions, it is recommended to use a...
Page 9
Operating manual for bukh dv48rme lifeboat engines 009w4226-r09 - 9 - winter storage of the engine 1. Carry out the following whilst the boat is still in the water: 1. Run the engine until normal workingtemperature is reached. 2. Drain off engine and gear oil with the oil bilge pump. 3. Fill the eng...
Page 10
Operating manual for bukh dv48rme lifeboat engines 009w4226-r09 - 10 - rme-engines mounted with hydro- or spring starter equipment (service info 9201) the above mentioned type of starting method has proved to start the lifeboat engines in a very short period of time. In cold climates a standard mult...
Page 11
Operating manual for bukh dv48rme lifeboat engines 009w4226-r09 - 11 - lubricating oil for spray pump bearing housing checking of oil level: dismount the filling plug with dipstick when the spray pump is in a horizontal position. The oil level must be just above the lower edge of the shaft. When tur...
Page 12
Operating manual for bukh dv48rme lifeboat engines 009w4226-r09 - 12 - technical main data dv24rme working principle ...................... ........................................ ...................................... 4-stroke number of cylinders ................. ....................................
Page 13
Operating manual for bukh dv48rme lifeboat engines 009w4226-r09 - 13 - recommended maintenance and check list for bukh lifeboat engines check rectify if needed 1. Tightness of connections through hull: w e e k l y m o n t h l y y e a r l y every 5 years 1.1 stern tube hull connection change sealing ...
Page 14
Operating manual for bukh dv48rme lifeboat engines 009w4226-r09 - 14 - recommended maintenance and check list for bukh lifeboat engines check rectify if needed w e e k l y m o n t h l y y e a r l y every 5 years 8. Engine maintenance 8.1 valve clearance clearance adjust x 8.2 electric starter rust p...
Page 15
Operating manual for bukh dv48rme lifeboat engines 009w4226-r09 - 15 - irregular operation - causes and remedies 1. Engine does not start symptom cause remedy insufficient or very little compression inlet and/or exhaust valves leaking grind or replace the valves, mill the seats inlet and/or exhaust ...
Page 16
Operating manual for bukh dv48rme lifeboat engines 009w4226-r09 - 16 - lubricating oil chart lubricating oil for engine: temp. Range auxili- aries oil company oil type hd oil grade & quality belo w – 15 o c belo w 5 o c 5 o c – 25 o c above 2 5 o c m60 gearb ox (atf) stern tube (flex ible) bp oil vi...
Page 17
Operating manual for bukh dv48rme lifeboat engines 009w4226-r09 - 17 -.
Page 18
Operating manual for bukh dv48rme lifeboat engines 009w4226-r09 - 18 -.
Page 19
Operating manual for bukh dv48rme lifeboat engines 009w4226-r09 - 19 - installation: dv48.
Page 20
Operating manual for bukh dv48rme lifeboat engines 009w4226-r09 - 20 - bukh distributors – worldwide fiala & cia. S.R.L. Av. Presidente roque saenz peña 710 piso 3º “d” 1035 buenos aires argentina tel: +54-11-4328-1474 / 6280 fax: +54-11-4328-2838 e-mail: info@fialaycia.Ar bukh diesel australia pty....
Page 21
Operating manual for bukh dv48rme lifeboat engines 009w4226-r09 - 21 - klydon d.O.O. Mrgani 9 52352 kanfanar croatia tel: +385-52-501-553 fax: +385-52-501-553 e-mail: info@klydon.Hr website: www.Klydon.Hr imocom ecuatoriana cia. Ltda. Casilla 17-17-292 quito ecuador tel: +593-2-447662 fax: +593-2-44...
Page 22
Operating manual for bukh dv48rme lifeboat engines 009w4226-r09 - 22 - mizuno marine co ltd 1-12-15 meishinguchi toyonaka-city osaka 561-0841 japan tel: +81-6-6863-5233 fax: +81-6-6863-5029 e-mail: mizuno@mizuno-marine.Co.Jp website: www.Mizuno-marine.Co.Jp contact: nobuyuki shimazaki bns korea co. ...
Page 23
Operating manual for bukh dv48rme lifeboat engines 009w4226-r09 - 23 - keppel sea scan pte ltd no. 44 benoi road singapore 629904 singapore tel: +65-6863-0788 fax: +65-6863-6960 e-mail: sherry.Li@keppelseascan.Com contact: ms sherry li shaoling southern marine workshops cc 3 carlisle street, paarden...
Page 24
Operating manual for bukh dv48rme lifeboat engines 009w4226-r09 - 24 - general terms of sale and delivery 1. Introduction the terms of sale and delivery specified below shall apply to all quotations, orders and consignments unless otherwise specified in any other written agreement. 2. Quotations quo...