- DL manuals
- C.T.M.
- Wheelchair
- HS-1000
- User Manual
C.T.M. HS-1000 User Manual
Summary of HS-1000
Page 1
C.T.M. Mini power chair c.T.M. Mini power chair c.T.M. Mini power chair hs-1000 user's manual.
Page 2
User's manual hs-1000 table of contents introduction important precautions electromagnetic interference and warnings identification of parts operating your power chair disassembling / re-assembling your power chair installation of batteries charging the batteries care and maintenance troubleshooting...
Page 3: C.T.M.Homecare Product, Inc.
User's manual hs-1000 c.T.M.Homecare product, inc. 6191 schaefer ave suite b chino ca 91710 tel : +909-590-1388 fax : +909-590-3365 e-mail : ctm@ctmhomecare.Com http : //www.Ctmhomecare.Com if you have any questions, please contact your local dealer or: or your local dealer: introduction 1 thank you...
Page 4
User's manual hs-1000 important precautions 2 •only one person at a time can ride a c.T.M. Power chair. •maximum load is 135 kg/300 lbs. •turn off power before getting on or off your power chair. •always drive carefully with your feet on footplate and be aware of others in your area. •always use ped...
Page 5
User's manual hs-1000 electromagnetic interference and warnings 3 caution: it is very important that you read this information regarding the possible effects of electromagnetic interference on your power chair. Powered wheelchairs and motorized scooters may be susceptible to electromagnetic interfer...
Page 6
User's manual hs-1000 4 3.Long-range transmitters and transceivers such as commercial broadcast transmitters (radio and tv broadcast antenna towers) and amateur (ham) radios. Because em energy rapidly becomes more intense as one moves closer to the transmitting antenna (source), the em fields from h...
Page 7
User's manual hs-1000 rear bag arm width adjustment thumbscrews arm height adjustment thumbscrews charging port rear reflectors ciricuit breaker charging indicator/ ammeter figure 1 - hs-1000 power chair front view figure 2 - hs-1000 joystick figure 3 - hs-1000 power chair rear view identification o...
Page 8
User's manual hs-1000 6 joystick ： •speed dial knob by turning knob clockwise, you could increase speed. Turning knob counterclockwise will decrease speed. •self diagnostic warning lights flashing of lights indicates there is a problem within power chair. See page 18 for more information. •battery g...
Page 9
User's manual hs-1000 7 footplate ： •footplate the footplate can be adjusted according to your specific needs. It can be adjusted vertically or horizontally. To adjust footplate, loosen screw (a) and arrange height to desired position, then, tightened screw (a) to secure plate in place. Figure 6 fig...
Page 10
User's manual hs-1000 figure 9 figure 9 figure 10 figure 10 operating your scooter 8 before beginning your journey with your new power chair, make sure power chair is on a level surface and clear of any obstacle. Although your power chair is able to climb slopes, it is safer to practice on a leveled...
Page 11
User's manual hs-1000 figure 12 figure 12 figure 11 figure 11 9 keep in mind these rules ： •use your power chair only where it is safe for walking. •drive in low speed when reversing, riding downhill on ramp or curb or on uneven surface. 6.When the battery gauge is lighting in only few sections, you...
Page 12
User's manual hs-1000 10 other operating information ： hill climbing : you may need to use a higher speed. For a higher speed, turn speed dial clockwise. Down slopes : proceed with dawnward slope slowly, and turn speed dial counterclockwise. This enables good control when speed is set in slower moti...
Page 13
User's manual hs-1000 (b) 11 disassembling / re-assembling your power chair seat removal ： please follow instructions below to remove seat from power base. 1.Unplug joystick cable at rear of power chair.(see fig. 13) 2.Bend chair back forward and press lock pins underneath front and along seat sides...
Page 14
User's manual hs-1000 12 installation of batteries please follow instructions below to install batteries. 1.Refer to page 11 on "disassembling / re-assembling your power chair" before installing batteries. 2.Make sure free-wheeling lever is set to "d" to engage motors. 3.Once the shrouds are removed...
Page 15
User's manual hs-1000 the stickers on frame should match battery cables (negative and positive). 13 8.Follow steps 6 - 7 for another side of the cables. (see fig. 21) 9.Make sure battery cables are tight and use velcro strap to secure batteries in place. (see fig. 22) 10.Re-assemble shroud and seat ...
Page 16
User's manual hs-1000 14 charging the batteries your c.T.M. Power chair is equipped with two, service free 12v 36ah rechargeable batteries and one 24v/3a on-board charger. Batteries must be charged before using power chair for the first time and it is recommended to be charged up to 8 - 14 hours aft...
Page 17
User's manual hs-1000 15 batteries will only give maximum performance after power chair has been used, and batteries have been recharged up to 10 times. For safety, please follow guidelines below. 1.Do not use charger if power cord is damaged. 2.Do not use an extension cord when charging batteries. ...
Page 18
User's manual hs-1000 16 care and maintenance taking care of your power chair will keep it in top-notch condition. It is recommended that you have your dealer to provide a thorough inspection and servicing. Regular cleaning will reveal loose or worn parts and enhance the smooth operation of your pow...
Page 19
User's manual hs-1000 17 tire pressure (for air-filled tires only): the condition of tires and maintenance of specified tire pressures not only influence tire life, but also effect road safety to a very considerable extent. Incorrect pressure is often a cause of tire problems and could result in an ...
Page 20
User's manual hs-1000 troubleshooting flash code description 1 2 3 4 5 6 7 8 9 10 11 user fault battery fault left motor fault right motor fault left park brake fault right park brake fault shark remote fault shark power module fault shark communications fault unknown fault incompatible remote possi...
Page 21
User's manual hs-1000 other problems ： 19 •power chair will not move when power is turned on : 1.Check battery gauge on joystick. All led lights should be on. 2.Check self-diagnostic warning light. It should be steady; if it is flashing, see the chart on page 18 for problem identification. 3.Check a...
Page 22
User's manual hs-1000 *subject to change without notice. (issue a) specification 20 overall length overall width overall height wheels: front wheels: middle wheels: rear weight w/ batteries max. Speed weight capacity ground clearance grade climbable curb climbing turning radius brake seat width driv...