1. DL manuals
  2. C.T.M.
  3. Mobility Aid
  4. HS-898
  5. Instruction Booklet

C.T.M. HS-898 Instruction Booklet

Manual is about: MOBILITY SCOOTER

Summary of HS-898

  • Page 1

    Hs-898 instruction booklet c.T.M. Mobility scooter c.T.M. Mobility scooter c.T.M. Mobility scooter.

  • Page 2

    Instruction booklet hs-898 table of contents introduction important precautions electromagnetic interference and warnings identification of parts charging the batteries disassembling your scooter assembling your scooter care and maintenance operating your scooter troubleshooting technical specificat...

  • Page 3

    Hs-898 instruction booklet if you have any question, you can contact : chien ti enterprise co., ltd. No.13, lane 227, fu ying rd., hsin chuang,taipei, taiwan, tel : +886-2-2903-2987 fax : +886-2-2903-8807 e-mail : sales@chienti.Com.Tw http : //www.Chienti.Com.Tw or your local dealer: introduction 1 ...

  • Page 4

    Hs-898 instruction booklet important precautions 2 •only one person at a time could ride a c.T.M. Mobility scooter. •maximum load is 181 kgs / 399 pounds. •turn key off before getting on or off. •always drive carefully and be aware of others using the same area. •always use pedestrian crossings wher...

  • Page 5

    Hs-898 instruction booklet 2.Medium-range mobile transceivers, such as those used in police cars, fire trucks, ambulances, and taxis. These usually have the antenna mounted on the outside of the vehicle; and 3.Long-range transmitters and transceivers such as commercial broadcast transmitters (radio ...

  • Page 6

    Hs-898 instruction booklet 4 there is no easy way to evaluate their effect on the overall immunity of the motorized scooter. Because em energy rapidly becomes more intense as one moves closer to the transmitting antenna (source), the em fields from hand-held radio wave sources (transceivers) are of ...

  • Page 7

    Hs-898 instruction booklet thumb lever tiller angle adjustment seat sliding slide lever swivel seat with head rest adjustable armrest seat rotation lever 13" front and rear wheels basket head light turn signals figure 1 - hs-898 front view figure 2 - hs-898 control panel figure 3 - hs-898 rear view ...

  • Page 8

    Hs-898 instruction booklet 6 function of parts ： figure 4 figure 4 figure 5 figure 5 do not set the speed at maximum when operating the scooter. Adjust the speed at maximum when inclining a slope, and adjust to minimum speed when declining a slope. Check battery's capacity before driving, and chargi...

  • Page 9

    Hs-898 instruction booklet capacity display operation characteristic usage condition led blocks will only decrease gradually during driving. Operation characteristic warning sound will signal, when battery capacity's lower than 25%, after turn on the power, 2 short "be" sounds will signal 3 times (b...

  • Page 10

    Hs-898 instruction booklet examples reversing warning sound volume adjustment 1.Turn off the power (key off) 2.Pressing left and right turn signal buttons downwards simultaneously. 3.Turn on the power(key on) after 2 seconds, led (d7) flashes (meaning accessed in volume setting mode), release the bu...

  • Page 11

    Hs-898 instruction booklet figure 7 figure 7 figure 8 figure 8 figure 9 figure 9 (g) (f) (a) (h) (i) (e) 9 thumb lever pulling right thumb lever (e) moves scooter forward. Pulling left thumb lever (f) moves the scooter backward. (this can be reversed if required by local dealer.) releasing both, eng...

  • Page 12

    Hs-898 instruction booklet figure 11 figure 11 (l) (m) figure 10 figure 10 (j) (k) armrest width adjustment thumbscrews 1.Loosen the two thumbscrews (k) to adjust arm width tighten again to lock in at desired position. 2.Adjust the attached screw (j)'s height, to control armrest's angle. 10 anti-tip...

  • Page 13

    Hs-898 instruction booklet keep in mind these rules ： •fully charge batteries at least once a month, or more if you use scooter regularly. Charge after each trip exceeding 3 kilometers. •if storing your scooter for some time (1 month or more), make sure that batteries are fully charged, and on retur...

  • Page 14

    Hs-898 instruction booklet (o) (h) (a) (b) (q) (b) (b) (r) (r) (p) be careful when removing batteries, as batteries are heavy. Do not contact battery terminal with any metals to avoid danger. Figure 13 figure 13 figure 14 figure 14 figure 15 figure 15 figure 16 figure 16 12 disassembling your scoote...

  • Page 15

    Hs-898 instruction booklet 13 assembling your scooter to assemble scooter, you can repeat disassembly directions in reverse. Abbreviated directions are given below. Refer to figures on pages 12 to locate parts. 1.Use the tiller adjustment to move tiller up and out of the way. 2.Place front basket. 3...

  • Page 16

    Hs-898 instruction booklet cleaning your scooter ： if your scooter is dirty, use a damp or lightly soapy cloth to wipe it down. Do not use running water to wash or rinse scooter in order to protect electrical parts. Polish with an automotive liquid polish. Maintaining your scooter ： all maintenance ...

  • Page 17

    Hs-898 instruction booklet operating your scooter 15 you could make the following adjustments to increase your comfort when driving. •adjust seat position. •adjust armrest width to comfortable position. •adjust tiller's angle. This scooter has automatic braking system. Release the thumb lever and br...

  • Page 18

    Hs-898 instruction booklet in unlikely event of a panel display error, you need to re-set the display system by cycling the on/off main switch. The display circuitry is independent of the motor control system. A display console error does not affect scooter speed control. 16 keep in mind these rules...

  • Page 19

    Hs-898 instruction booklet troubleshooting here are some suggestions about solving problems you may have with your scooter. There is a self-diagnostic warning light on the control panel. To check the self-diagnostic warning light, turn on the key and count the number of blinks on the warning light. ...

  • Page 20

    Hs-898 instruction booklet 9 other error the controller may have an internal fault. •check all connections and wiring. Other problems low tire pressure: pump up tires to 30-50 lbs. During charging, light on charger does not change to green: contact your authorized dealer. Scooter will not move when ...

  • Page 21

    Hs-898 instruction booklet *subject to change without notice. (issue a) overall length overall width overall height wheels:front wheels:rear weight w/ batteries max. Speed weight capacity ground clearance grade climbable curb climbing turning radius suspension brake seat type seat width motor size b...