Summary of 2006
Page 1
Ltr20061006, rev. A 10/28/05.
Page 2: Contact Information
Contact information for customer service, please contact your authorized dealer immediately. If you need additional information and/or assistance, please contact: c.A.I. Customer service department 1462 east ninth street pomona, ca 91766 toll free: 1-800-cal-spas fax: 1-909-629-3890 www.Calspas.Com ...
Page 3
Read this first! Precautions regarding children . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .2 other common sense precautions . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .2 what to do if you smell gas . . . . . . . . . . . . . . . . . . . . . . ....
Page 4
This page intentionally left blank..
Page 5: Read This First!
Fireplaces and firepits owner’s manual www.Calspas.Com read this first! Read this before installing or operating your new cal flame firepit or fireplace. You are responsible for ensuring that a natural gas line is installed and safe to use. We highly recommend that you have a licensed techni- cian r...
Page 6
Fireplaces and firepits owner’s manual read this first! Www.Calspas.Com precautions regarding children • never leave children unattended when the firepit or fireplace is being used. • do not store items of interest to children around or below the firepit or fireplace. • never allow children to sit o...
Page 7: Location
Fireplaces and firepits owner’s manual www.Calspas.Com planning for your firepit or fireplace safe and satisfactory operation of your new firepit or fireplace depends upon its proper installation. Instal- lation, adjustments and service must be performed by c.A.I. Qualified installers and service te...
Page 8: Lp Gas Manifold Pressure
Fireplaces and firepits owner’s manual planning for your firepit or fireplace www.Calspas.Com a. At least two ventilation openings at cylinder valve level shall be provided in the sidewall, equally sized, spaced at 180˚ (3.14 rad), and unobstructed. Each opening shall have a total free area of not l...
Page 9: Natural Gas Requirements
Fireplaces and firepits owner’s manual www.Calspas.Com transporting the lp gas supply cylinder only one cylinder should be transported at a time. Transport cylinder in an upright and secure manner with control valve turned off and the dust cap in place. Natural gas requirements always check the rati...
Page 10
Fireplaces and firepits owner’s manual planning for your firepit or fireplace www.Calspas.Com 5. Blowing bubbles in the soap solution indicates that a leak is present. 6. Stop a leak by tightening the loose joint or by replacing the faulty part with a replacement part recommended by the manufacturer...
Page 11: Safety Information
Fireplaces and firepits owner’s manual www.Calspas.Com using your firepit or fireplace always keep the appliance area clear and free from combustible materials, gasoline and any other flam- mable vapors and liquids. For fireplaces with a waterfall, make sure that there is no debris in the filler pan...
Page 12: To Turn Off The Appliance
Fireplaces and firepits owner’s manual using your firepit or fireplace www.Calspas.Com the appliance. For lp appliances, turn the valve on the lp tank counterclockwise all the way and then turn “on” the on/off valve slowly at the appliance. 3. If the burner does not light before the match goes out, ...
Page 13: Manual Thermostat
Fireplaces and firepits owner’s manual www.Calspas.Com manual thermostat operation of the thermostat is based on the position of the control lever. While turning the lever to the on position, note the position the main burner ignites. Leaving the lever at this position would cause the burner to oper...
Page 14: Maintenance and Care
Fireplaces and firepits owner’s manual using your firepit or fireplace www.Calspas.Com maintenance and care maintaining your firepit or fireplace inspect the appliance before initial use. Clean the appliance at least annually and have it inspected by a qualified field service person. Tampering with ...
Page 15: Appendix
Fireplaces and firepits owner’s manual www.Calspas.Com appendix replacement parts description part number quantity firepit parts repair kit #1 bbq04210001 1 repair kit #2 bbq04210002 1 burner assembly (firepit) bbq04100656 1 firepit log base bbq04000655 1 fireplace parts 1/40 hp submersible recircul...
Page 16: Warranty Information
Fireplaces and firepits owner’s manual appendix www.Calspas.Com warranty information see your cal flame dealer for a copy of the applicable warranty, details and any questions you may have regarding the warranty coverage on your firepit or fireplace. Warranty limitations the limited warranty is void...
Page 17
Fireplaces and firepits owner’s manual www.Calspas.Com page 13 appendix ltr20061006, rev. A.
Page 18: Www.Calspas.Com
C.A.I. Customer service department 1462 east ninth street pomona, ca 91766 toll free: 1-800-cal-spas fax: 1-909-629-3890 www.Calspas.Com please make a record of the following. It will be valuable if service is required. Locating the product serial number: the serial number of your cal flame firepit ...