1. DL manuals
  2. Cal Flame
  3. Grill
  4. Barbeque Grill
  5. Owner's Manual

Cal Flame Barbeque Grill Owner's Manual - Replacement Covers

Manual is about: Barbeque Grill and Carts

Summary of Barbeque Grill

  • Page 1

    Ltr20071038, rev. B 1/4/07.

  • Page 2

    Copyright 2006-2007 california acrylic industries, inc. All rights reserved. Duplication without written consent is strictly prohibited. Cal spas™ and cal flame™ are registered trademarks. Due to continuous improvement programs, all models, operation, and/or specifications are subject to change with...

  • Page 3

    Table of contents 2007 barbecue grill and cart owner’s manual page 1 ltr20071038, rev. B warning if the information in this manual is not followed exactly, a fire or explosion may result causing property damage, personal injury or loss of life. Do not store or use gasoline or other flammable vapors ...

  • Page 4: Safety Instructions

    Page 2 2007 barbecue grill and cart owner’s manual ltr20071038, rev. B safety instructions placement and location cal flame™ grills and carts are designed for outdoor use only . Never locate this appliance in an enclosed room, under a sealed overhead structure, or in any type of enclosed area such a...

  • Page 5

    Safety instructions 2007 barbecue grill and cart owner’s manual page 3 ltr20071038, rev. B blocked. Fresh air must be able to pass though installed vents to safeguard against residual gas accumulation. Failure to allow proper ventilation may cause fire or explosion. When handling lp gas line and con...

  • Page 6: Installation / Assembly

    Page 4 2007 barbecue grill and cart owner’s manual ltr20071038, rev. B installation / assembly installation / assembly most cities and counties require permits for exterior construction and electrical circuits. In addition, some communities have codes requiring residential barriers such as fencing a...

  • Page 7

    Installation / assembly 2007 barbecue grill and cart owner’s manual page 5 ltr20071038, rev. B model number description width depth height cut-out for drop in accessories bbq07852p drop in standard side burner 11 ½” 17 ¾” 2 ¾” bbq07845p drop in sink 14 ½” 14 ½” bbq07953p standard side by side burner...

  • Page 8

    Page 6 2007 barbecue grill and cart owner’s manual ltr20071038, rev. B installation / assembly model number description width depth height cut-out for refrigerators, cocktail centers and access doors bbq07863p 3 pull out drawer, ss refr. 25” 22 7/8” 32 ¼” bbq07857p propane tank compartment 14 ¾” 16 ...

  • Page 9: Leak Testing Procedure

    Installation / assembly 2007 barbecue grill and cart owner’s manual page 7 ltr20071038, rev. B gas requirements and connection important: cal flame™ grills are manufactured to operate on either liquid propane (lp) or natural gas (ng) and cannot be converted. To verify the grill’s operating fuel, che...

  • Page 10: Lp Gas

    Page 8 2007 barbecue grill and cart owner’s manual ltr20071038, rev. B installation / assembly one side of the enclosure shall be completely open. Enclosures that have four sides, complete with a top and bottom: at least two ventilation openings at cylinder valve level shall be provided in the sidew...

  • Page 11: Natural Gas

    Installation / assembly 2007 barbecue grill and cart owner’s manual page 9 ltr20071038, rev. B natural gas requirements always check the rating plate to make sure the gas supply you are hooking up to is the gas type the grill is manufactured for. Important: never connect the grill to an unregulated ...

  • Page 12: Installing and Replacing

    Page 10 2007 barbecue grill and cart owner’s manual ltr20071038, rev. B installation / assembly installing and replacing infrared burners disconnect or shut off the liquid propane or natural gas line connect to the grill. Wait until the burners cool down. Open the hood and remove the grate and flame...

  • Page 13: Installing The Transformer

    Installation / assembly 2007 barbecue grill and cart owner’s manual page 11 ltr20071038, rev. B installing the transformer all grills with electrical components such as lights or a convection fan will require the transformer to be installed and plugged in before you can use it. This needs to be done...

  • Page 14: Islands

    Page 12 2007 barbecue grill and cart owner’s manual ltr20071038, rev. B installation / assembly installing grills in modular carts you will need a second person to help you to avoid damaging the grill, the transformer, or your barbecue island . Keep fingers away from where the grill will be supporte...

  • Page 15: Installing Barbecue Cart End

    Installation / assembly 2007 barbecue grill and cart owner’s manual page 13 ltr20071038, rev. B installing barbecue cart end shelves prepare the installation of handle: 2 hex screws, 2 washers use finger to thread the hex screws and washers into the threads on both ends of the handle. Use ratchet to...

  • Page 16: Installing Side Burners

    Page 14 2007 barbecue grill and cart owner’s manual ltr20071038, rev. B installation / assembly installing side burners assemble a 3/8” pipe nipple to the 3/8” pipe tee using teflon tape or pipe sealant. Use only sealant that is approved for use on lp gas. Install the pipe tee assembly to the grill ...

  • Page 17: Operating Your Barbecue

    Operating your barbecue 2007 barbecue grill and cart owner’s manual page 15 ltr20071038, rev. B light switch grill grill grill infrared burner bbq07873 - 3 burner grill cr3000 - 3 burner cart light switch grill grill grill grill infrared burner bbq07874 - 4 burner grill cr4000 - 4 burner cart cr4000...

  • Page 18: Lighting The Grill

    Page 16 2007 barbecue grill and cart owner’s manual ltr20071038, rev. B operating your barbecue each time you light the grill, check the following: inspect the hose before using the grill. If there is excessive abrasion or wear, or if the hose is cut, it must be replaced prior to using the grill. If...

  • Page 19: Basic Grill Operation

    Operating your barbecue 2007 barbecue grill and cart owner’s manual page 17 ltr20071038, rev. B basic grill operation before lighting, make sure all burner controls are off. Do not attempt to light the burners if the smell of gas is present. Check the connection with a soap and water solution after ...

  • Page 20

    Page 18 2007 barbecue grill and cart owner’s manual ltr20071038, rev. B operating your barbecue cooking with a convection grill a convection grill has an internal fan that circulates heated air evenly throughout the grilling area when the hood is closed. Cooking in this way distributes heat more eff...

  • Page 21: Charcoal Grill

    Operating your barbecue 2007 barbecue grill and cart owner’s manual page 19 ltr20071038, rev. B charcoal grill lighting instructions never use flammable materials and fluids such as gasoline, kerosene, butane or propane, diesel fuel, or alcohol to light or re-light fires. Keep the grill away from su...

  • Page 22: Griddle

    Page 20 2007 barbecue grill and cart owner’s manual ltr20071038, rev. B operating your barbecue griddle when sliding the griddle out of the enclosure, always do it slowly as the heavy weight may cause you to suddenly drop the griddle. Lift the griddle out of the enclosure instead of sliding it all t...

  • Page 23

    Operating your barbecue 2007 barbecue grill and cart owner’s manual page 21 ltr20071038, rev. B high 210ºf – 230ºf medium 190ºf – 210ºf low 175ºf – 190ºf if you use the tray, preheat it while preheating the warming drawer. Preheat any empty serving dishes to be used while preheating the drawer. Add ...

  • Page 24: Cleaning and Maintenance

    Page 22 2007 barbecue grill and cart owner’s manual ltr20071038, rev. B cleaning and maintenance cleaning and maintenance to ensure safe and proper maintenance, we recommend you follow these directions carefully. Clean internal parts of the grill regularly as determined by the amount of use and food...

  • Page 25: Island Cabinets

    Cleaning and maintenance 2007 barbecue grill and cart owner’s manual page 23 ltr20071038, rev. B island cabinets be sure to unplug the electrical supply before cleaning any part of your cal flame barbecue. Spray cabinet area with a soap and water solution. Rinse with a gentle stream of fresh water. ...

  • Page 26: Light Bulb Replacement

    Page 24 2007 barbecue grill and cart owner’s manual ltr20071038, rev. B cleaning and maintenance use only clean sponges, soft cloths, paper towels, plastic or non-metal soap pads for cleaning or scouring, as recommended in this section. Be sure to rinse thoroughly and to wipe dry to avoid watermarks...

  • Page 27: Appendix

    Appendix 2007 barbecue grill and cart owner’s manual page 25 ltr20071038, rev. B appendix troubleshooting problem: smell of gas is present solution: check for loose connections in the gas line. Perform a leak test following the procedure described in this manual. Problem burner does not ignite solut...

  • Page 28

    Page 26 2007 barbecue grill and cart owner’s manual ltr20071038, rev. B appendix problem: plugged orifice solution: unplug the orifice as follows: remove cooking grills, flame tamer and grease tray. Remove burners from the bottom of the firebox by pulling the cotter pin from beneath the burner peg u...

  • Page 29: Replacement Covers

    Appendix 2007 barbecue grill and cart owner’s manual page 27 ltr20071038, rev. B replacement covers cal flame drop-ins bbq010 cover, grill, small, 3 burner bbq011 cover, grill, medium, 4 burner bbq012 cover, grill, large, 5 burner bbq013 cover, side burner, single & double cal flame carts bbq835cr4 ...

  • Page 30

    Page 28 2007 barbecue grill and cart owner’s manual ltr20071038, rev. B.

  • Page 32: Warranty Information

    Locating the product serial number the serial number of your cal flame grill is located on the back and is visible when the hood is down (see page 24). You will need this number to properly register your grill or cart and activate coverage. Write this information in the space provided below. Grill o...