Summary of BBQ00841P-20
Page 1
Ltr20101038, rev. A 4/30/10
Page 2
Warning if the information in this manual is not followed exactly, a fire or explosion may result causing property damage, personal injury or loss of life. Do not store or use gasoline or other flammable vapors and liquids in the vicinity of this or any other appliance. Do not store an lp cylinder n...
Page 3: Saf
2010 barbecue grills ltr20101038, rev. A saf ety instructions www.Calflamebbq.Com 1 placement and location c • al flame™ grills are designed for outdoor use only . Never locate this appliance in an enclosed room, • under a sealed overhead structure, or in any type of enclosed area such as a garage, ...
Page 4: Saf
2010 barbecue grills ltr20101038, rev. A saf ety instructions www.Calflamebbq.Com 2 never line the grill or side burners with aluminum • foil. When the unit is not in use, be sure to turn off the • gas at the lp tank. Do not install or operate your grill unit in such a • manner that the cross ventil...
Page 5: Installation /
2010 barbecue grills ltr20101038, rev. A installation / assemb ly www.Calflamebbq.Com 3 most cities and counties require permits for exterior construction and electrical circuits. In addition, some communities have codes requiring residential barriers such as fencing and/or self-closing gates on pro...
Page 6: Installation /
2010 barbecue grills ltr20101038, rev. A installation / assemb ly www.Calflamebbq.Com 4 model number description width depth height cut-out for drawers and doors bbq07868p 2 drawer storage 10 ¼” 17 ¾” 20” width height depth bbq07862p griddle and griddle storage 13 ½” 19 5/8” 2 ¾” bbq07891p cutting b...
Page 7: Installation /
2010 barbecue grills ltr20101038, rev. A installation / assemb ly www.Calflamebbq.Com 5 gas requirements and connection gas requirements and connection important: the cal flame grill is manufactured to operate on liquid propane (lp). However, it can be converted to operate on natural gas (ng) by an ...
Page 8: Installation /
2010 barbecue grills ltr20101038, rev. A installation / assemb ly www.Calflamebbq.Com 6 one side of the enclosure shall be completely 1. Open. Enclosures that have four sides, complete with a 2. Top and bottom: at least two ventilation openings at cylinder a. Valve level shall be provided in the sid...
Page 9: Installation /
2010 barbecue grills ltr20101038, rev. A installation / assemb ly www.Calflamebbq.Com 7 natural gas connection slide the grill forward to gain access to the 1. Regulator and gas connection point in the rear. Remove the rear panel from the barbecue to 2. Gain access to the regulator and gas connectio...
Page 10: Installation /
2010 barbecue grills ltr20101038, rev. A installation / assemb ly www.Calflamebbq.Com 8 installing the transformer all grills with electrical components such as lights or a convection fan will require the transformer to be installed and plugged in before you can use it. This needs to be done before ...
Page 11: Installation /
2010 barbecue grills ltr20101038, rev. A installation / assemb ly www.Calflamebbq.Com 9 installing grills in barbecue islands you will need a second person to help you to avoid damaging the grill, the transformer, or your barbecue island . Before installing a grill or side burner in any island or cu...
Page 12: Installation /
2010 barbecue grills ltr20101038, rev. A installation / assemb ly www.Calflamebbq.Com 10 installing side burners assemble a 3/8” pipe nipple to the 3/8” pipe 1. Tee using teflon tape or pipe sealant. Use only sealant that is approved for use on lp gas. Install the pipe tee assembly to the grill inta...
Page 13: Using
2010 barbecue grills ltr20101038, rev. A using your grill www.Calflamebbq.Com 11 light switch grill grill grill infrared burner three burner grill and cart light switch grill grill grill grill infrared burner four burner grill and cart light switch grill grill grill grill grill infrared burner five ...
Page 14: Using
2010 barbecue grills ltr20101038, rev. A using your grill www.Calflamebbq.Com 12 inspect the hose before using the grill. If there • is excessive abrasion or wear, or if the hose is cut, it must be replaced prior to using the grill. If you need a replacement hose, contact your cal flame dealer. Ensu...
Page 15: Using
2010 barbecue grills ltr20101038, rev. A using your grill www.Calflamebbq.Com 13 basic grill operation before lighting, make sure all burner controls are off. Do not attempt to light the burners if the smell of gas is present. Check the connection with a soap and water solution after attaching the h...
Page 16: Using
2010 barbecue grills ltr20101038, rev. A using your grill www.Calflamebbq.Com 14 cooking with a convection grill a convection grill has an internal fan that circulates heated air evenly throughout the grilling area when the hood is closed. Cooking in this way distributes heat more efficiently so you...
Page 17: Using
2010 barbecue grills ltr20101038, rev. A using your grill www.Calflamebbq.Com 15 cooking with hot oil over an open flame can be dangerous. To make your experience with the deep fryer helper an enjoyable one, you need to take these precautions and follow the directions below . Deep frying fill the de...
Page 18: Using
2010 barbecue grills ltr20101038, rev. A using your grill www.Calflamebbq.Com 16 never attempt to remove the deep fryer helper from the grill when hot. Allow it to cool completely before moving or cleaning. About 30 minutes. Wait until the thermometer shows the oil at the optimum frying temperature,...
Page 19: Cleaning and Maintenance
2010 barbecue grills ltr20101038, rev. A cleaning and maintenance www.Calflamebbq.Com 17 cleaning products and materials do not use these common cleaning products and materials – they will damage the surface of your stainless steel. Clr • lime-away • oven cleaner • cleansers such as ajax or comet • ...
Page 20: Cleaning and Maintenance
2010 barbecue grills ltr20101038, rev. A cleaning and maintenance www.Calflamebbq.Com 18 paper towel, polish the appliance by rubbing with the grain until excess liquid is removed and the surface shines. It should not be oily to the touch, however some residue is acceptable. Furniture polish, such a...
Page 21: Cleaning and Maintenance
2010 barbecue grills ltr20101038, rev. A cleaning and maintenance www.Calflamebbq.Com 19 the burners can be removed by removing the locking pins and lifting them out. The locking pins are located under the grill toward the back. They are used to keep the burners in place during shipping and are not ...
Page 22: Cleaning and Maintenance
2010 barbecue grills ltr20101038, rev. A cleaning and maintenance www.Calflamebbq.Com 20 seasonal cleaning if you haven’t used your grill in a few months, we recommend that you clean the burners and the interior of your grill. Cleaning the burners periodically will keep them burning evenly and clean...
Page 23: Cleaning and Maintenance
2010 barbecue grills ltr20101038, rev. A cleaning and maintenance www.Calflamebbq.Com 21 replace the burners 6 . Before you replace the burners, inspect the gas valve orifices for cleanliness and condition and the location of the igniters. Set the flame tamers in place before you replace the burners...
Page 24: Cleaning and Maintenance
2010 barbecue grills ltr20101038, rev. A cleaning and maintenance www.Calflamebbq.Com 22 light bulb replacement warning: never attempt to replace a light bulb when the grill is in use. Serious burns will result. Warning: never touch halogen bulbs with your bare fingers. Use a tissue or a small piece...
Page 25: Appendix
2010 barbecue grills ltr20101038, rev. A appendix www.Calflamebbq.Com 23 appendix troubleshooting problem: smell of gas is present solution: check for loose connections in the gas line. Perform a leak test following the procedure described in this manual. Problem: burner does not ignite solution: no...
Page 26: Appendix
2010 barbecue grills ltr20101038, rev. A appendix www.Calflamebbq.Com 24 problem: yellow flame solution: once the entire burner is operating, check the flame color to be sure that it is mostly blue. Some yellow at the tips may be present due to impurities in the fuel. If the flame is golden or yello...
Page 27: Appendix
2010 barbecue grills ltr20101038, rev. A appendix www.Calflamebbq.Com 25 all cal flame grills are manufactured as standard liquid propane (lp) grills and can be converted to burn natural gas (ng). There are two steps required to convert a grill from lp to ng. You must perform both steps. Step 1: swi...
Page 28: Appendix
2010 barbecue grills ltr20101038, rev. A appendix www.Calflamebbq.Com 26 step 2: changing the burner orifices replace the infrared burner orifices 1 . Remove the back cover from the grill. A. Using a wrench, remove the orifice for the infrared burner. B. Apply pipe compound to the fitting threads wh...
Page 29: Appendix
2010 barbecue grills ltr20101038, rev. A appendix www.Calflamebbq.Com 27 disconnect or shut off the liquid propane or 1. Natural gas line connect to the grill. Wait until the burners cool down. Open the hood and remove the grate and flame 2. Tamer on top of the burner you want to replace. Through th...
Page 30: Appendix
2010 barbecue grills ltr20101038, rev. A appendix www.Calflamebbq.Com 28 limited warranty all cal flame models are manufactured with the highest quality appliances and are warranted to be free from defects in material and workmanship at time of delivery. Lms warrants barbecue grills and associated h...
Page 31: Appendix
2010 barbecue grills ltr20101038, rev. A appendix www.Calflamebbq.Com 29 purposes and specifically excludes rental or commercial applications. Disclaimers lms shall not be liable for loss of use of the barbecue grills, related hardware or other incidental or consequential costs, expense or damages, ...
Page 32
Locating the product serial number the serial number of your cal flame grill is located on the back and is visible when the hood is down. You will need this number to properly register your grill and activate coverage. Write this information in the space provided below. Grill model: ________________...