Summary of BBQ08852P
Page 2: Installation / Assembly
Copyright 2009-2010 lms, inc. All rights re- served. Duplication without written consent is strictly prohibited. Cal flame ® is a registered trademark. Due to continuous improvement programs, all models, operation, and/or specifications are subject to change without prior notice. Ltr50001082, rev. B...
Page 3: Saf
Saf ety instructions 1 cal flame side burners ltr50001082, rev. B www.Calspas.Com safety instructions warning: improper installation, adjustment, altera- tion, service or maintenance can cause injury or property damage. Read the installation, operating and maintenance instructions thoroughly before ...
Page 4: Saf
2 saf ety instructions cal flame side burners ltr50001082, rev. B www.Calspas.Com operation do not use side burner for oth • er than intended use. In the event that a burner goes out, turn burner knobs to the • full off position and let it air out. Do not attempt to use the side burner until the gas...
Page 5: Saf
Saf ety instructions 3 cal flame side burners ltr50001082, rev. B www.Calspas.Com garments while using your side burner. Fabric may ignite and result in personal injury. Only use dry pot holders and do not use a towel or other bulky • cloth in place of pot holders. Moist or damp pot holders used on ...
Page 6: Installation /
4 installation / assemb ly cal flame side burners ltr50001082, rev. B www.Calspas.Com installation / assembly most cities and counties require permits for exterior construction and electrical circuits. In addition, some communities have codes requiring residential barriers such as fencing and/or sel...
Page 7: Installation /
Installation / assemb ly 5 cal flame side burners ltr50001082, rev. B www.Calspas.Com width depth the drawing at right shows the different types of cabinet cut-out dimensions for drop-in side burn- ers. Gas requirements and connection gas requirements and connection important: the cal flame side bur...
Page 8: Installation /
6 installation / assemb ly cal flame side burners ltr50001082, rev. B www.Calspas.Com leak testing procedure perform a leak test at least once a year whether the gas supply cyl- inder has been disconnected or not. In addition, whenever the gas cylinder is connected to the side burner or whenever any...
Page 9: Installation /
Installation / assemb ly 7 cal flame side burners ltr50001082, rev. B www.Calspas.Com lp gas tank requirements for plumbed-in lp installation, use a convertible regulator and set it for lp gas. Maximum line pressure for plumbed-in propane is 14” wc (3.5 kpa). Minimum line pressure for propane is 11”...
Page 10: Installation /
8 installation / assemb ly cal flame side burners ltr50001082, rev. B www.Calspas.Com place the dust cap on the cylinder valve outlet whenever the cylinder is not in use. Only install the type of dust cap on the cylinder valve outlet that is provided with the cylinder valve. Other types of caps or p...
Page 11: Installation /
Installation / assemb ly 9 cal flame side burners ltr50001082, rev. B www.Calspas.Com natural gas requirements the installation of this appliance must conform with local codes or, in the absence of local codes, to the national fuel gas code, ansi z223.1a-1998. Installation in canada must be in accor...
Page 12: Installation /
10 installation / assemb ly cal flame side burners ltr50001082, rev. B www.Calspas.Com installing side burner with a grill if you are installing a side burner in conjunction with a gas grill, install it in the following manner. Assemble a 3/8” pipe nipple to the 3/8” pipe tee using teflon tape 1. Or...
Page 13: Installation /
Installation / assemb ly 11 cal flame side burners ltr50001082, rev. B www.Calspas.Com c b a b c a connect the last open line to the side burner (use gas rated tape seal on all connections) then take other end of "t" adapter with hose attached and connect to end of male located underneath and at the...
Page 14: Using
12 using your side burner cal flame side burners ltr50001082, rev. B www.Calspas.Com using your side burner read all instructions before you operate your side burner . We recommend you wash your side burner with soap and water prior to lighting it for the first time. Oils are used during the manufac...
Page 15: Using
Using your side burner 13 cal flame side burners ltr50001082, rev. B www.Calspas.Com if connected to a propane cylinder, carefully inspect • the rubber hose attached to the regulator before each use . Ensure the propane cylinder, regulator, and rubber • hose are installed in a location not subject t...
Page 16: Using
14 using your side burner cal flame side burners ltr50001082, rev. B www.Calspas.Com manually lighting the side burners warning: do not use standard matches or cigarette lighters to per- form match lighting procedures. Serious burns can occur and lighters can explode. Open the hood. 1. If you have j...
Page 17: Cleaning and Maintenance
Cleaning and maintenance 15 cal flame side burners ltr50001082, rev. B www.Calspas.Com cleaning and maintenance to ensure safe and proper maintenance, we recommend you follow these directions carefully. Clean the side burner regularly as determined by the amount of use and foods cooked. In addition,...
Page 18: Cleaning and Maintenance
16 cleaning and maintenance cal flame side burners ltr50001082, rev. B www.Calspas.Com cleaning products and materials avoid using these common cleaning products and materials – they will damage the surface of your stainless steel. Clr • lime-away • oven cleaner • cleansers such as ajax or comet • a...
Page 19: Cleaning and Maintenance
Cleaning and maintenance 17 cal flame side burners ltr50001082, rev. B www.Calspas.Com clean 1 . Thoroughly clean stains, food, and grime using a sponge or damp cloth with warm water and a mild dish soap. Use fantastik or for- mula 409 to remove heavier soil. Rinse 2 . Thoroughly rinse all surfaces ...
Page 20: Cleaning and Maintenance
18 cleaning and maintenance cal flame side burners ltr50001082, rev. B www.Calspas.Com rust removal it is a common misconception that stainless steel does not rust. It does not stain, corrode, or rust as easily as ordinary steel (it stains less), but it is not stain-proof. If not properly protected ...
Page 21: Appendix
Appendix 19 cal flame side burners ltr50001082, rev. B www.Calspas.Com troubleshooting problem: smell of gas is present solution: check for loose connections in the gas line. Perform a leak test following the procedure described in this man- ual. Problem: burner does not ignite solution: check the p...
Page 22: Appendix
20 appendix cal flame side burners ltr50001082, rev. B www.Calspas.Com problem: pluggedorifice solution: unplug the orifice as follows: remove burner rack and brass burner. • using a 7mm socket or socket wrench, remove the • brass orifice. Gently clear any obstruction with a fine wire. • reinstall t...
Page 23: Appendix
Appendix 21 cal flame side burners ltr50001082, rev. B www.Calspas.Com warning! You must have an authorized service technician perform this procedure . If these instructions are not followed exactly,afireorexplosionmayresultcausingpropertydam- age, personal injury or loss of life . Lloyd’s material ...
Page 24: Appendix
22 appendix cal flame side burners ltr50001082, rev. B www.Calspas.Com replacement covers side burner model cover part number cover size bbq08852p standard single flat side burner cvrsbr050-g 11” x 17 ¼” x 5 ½” bbq08953p standard side by side burner cvrsbr052-g 24 ¼” x 19 ½” x 6 ¼” bbq08899p deluxe ...
Page 25: Appendix
Appendix 23 cal flame side burners ltr50001082, rev. B www.Calspas.Com limited warranty all cal flame models are manufactured with the highest quality ap- pliances and are warranted to be free from defects in material and workmanship at time of delivery. Lms warrants side burners and associated hard...
Page 26: Appendix
24 appendix cal flame side burners ltr50001082, rev. B www.Calspas.Com this warranty is void if the side burner has been subject to negligence, alteration, misuse, repairs, dings, dents, scratches, or incorrect and / or prohibited applications, as specified in the owner’s manual. Gas lines must be i...
Page 27: Appendix
Appendix 25 cal flame side burners ltr50001082, rev. B www.Calspas.Com legal remedies this limited warranty gives you specific legal rights. You may have other rights, which may vary from state to state. Customer service for customer service, contact the authorized selling dealer immedi- ately. If y...
Page 28: Www.Calflamebbq.Com
Ltr50001082, rev. B 5/26/11 contact information for customer service, please contact your authorized dealer immediately. If you need additional information and/or assistance, please contact: customer service department 1462 east ninth street pomona, ca 91766 toll free: 1-800-cal-spas fax: 1-909-629-...