Summary of BBQ08872U
Page 1
Ltr20081044, rev. A 4/21/08.
Page 2
Warning if the information in this manual is not fol- lowed exactly, a fire or explosion may re- sult causing property damage, personal injury or loss of life. Do not store or use gasoline or other flam- mable vapors and liquids in the vicinity of this or any other appliance. This appliance is for o...
Page 3: Safety Instructions
Cal flame 2008 owner’s manual page 1 ltr20081044, rev. A safety instructions read all instructions before you operate your grill . Placement and location c • al flame™ grills are designed for outdoor use only . Never locate this appliance in an enclosed room, • under a sealed overhead structure, or ...
Page 4
Page 2 cal flame 2008 owner’s manual ltr20081044, rev. A safety instructions never use the grill or side burner in windy conditions. • if used in a consistently windy area a windbreak will be required. Always adhere to the specified clear- ances listed in this manual. Never line the grill or side bu...
Page 5: Installation / Assembly
Cal flame 2008 owner’s manual page 3 ltr20081044, rev. A installation / assembly installation / assembly most cities and counties require permits for exterior con- struction and electrical circuits. In addition, some com- munities have codes requiring residential barriers such as fencing and/or self...
Page 6: Liquid Propane Gas
Page 4 cal flame 2008 owner’s manual ltr20081044, rev. A installation / assembly as a safety precaution, remember to always leak test your grill outdoors in a well-ventilated area. Never smoke or permit sources of ignition in the area while doing a leak test. Do not use a flame, such as a lighted ma...
Page 7: Installing The Transformer
Cal flame 2008 owner’s manual page 5 ltr20081044, rev. A installation / assembly the grill unit must be used with the gas pressure regula- tor. The regulator will control and maintain a uniform gas pressure in the manifold. The burner orifices have been sized for the gas pressure delivered by the re...
Page 8
Page 6 cal flame 2008 owner’s manual ltr20081044, rev. A installation / assembly remove the transformer and the metal screws from the plastic bag. 1. Place the grill on a sturdy surface and tilt it back to show the underside of the grill. 2. Using the metal screws, attach the transformer to the left...
Page 9: Installing The Rotisserie
Cal flame 2008 owner’s manual page 7 ltr20081044, rev. A installation / assembly installing the rotisserie attach the two brackets to the sides of the grill, one on each side, using two screws as shown below. Slide the rotis motor on one of the brackets as shown be- low. The rotis motor will work on...
Page 10: Installing Side Burners
Page 8 cal flame 2008 owner’s manual ltr20081044, rev. A installation / assembly installing side burners assemble a 9.5 mm pipe nipple to the 9.5 mm pipe tee using teflon tape or pipe sealant. Use only sealant that 1. Is approved for use on lp gas. Install the pipe tee assembly to the grill intake p...
Page 11: Operating Your Barbecue
Cal flame 2008 owner’s manual page 9 ltr20081044, rev. A operating your barbecue light switch grill grill grill grill infrared burner bbq07874cpe - 4 burner grill light switch grill grill grill grill grill infrared burner bbq07875cpe - 5 burner grill infrared burner grill knob operation low off high...
Page 12: Lighting The Grill
Page 10 cal flame 2008 owner’s manual ltr20081044, rev. A operating your barbecue each time you light the grill, check the following: inspect the hose before using the grill. If there is • excessive abrasion or wear, or if the hose is cut, it must be replaced prior to using the grill. If you need a ...
Page 13: Basic Grill Operation
Cal flame 2008 owner’s manual page 11 ltr20081044, rev. A operating your barbecue basic grill operation before lighting, make sure all burner controls are off. Do not attempt to light the burners if the smell of gas is pres- ent. Check the connection with a soap and water solu- tion after attaching ...
Page 14: Light and Fan Switch
Page 12 cal flame 2008 owner’s manual ltr20081044, rev. A operating your barbecue cooking with a convection grill a convection grill has an internal fan that circulates heated air evenly throughout the grilling area when the hood is closed. Cooking in this way distributes heat more efficiently so yo...
Page 15: Cleaning and Maintenance
Cal flame 2008 owner’s manual page 13 ltr20081044, rev. A cleaning and maintenance cleaning and maintenance clean internal parts of the grill regularly as determined by the amount of use and foods cooked. The entire grill should be cleaned at least once a year. In addition, keep the area around your...
Page 16: Light Bulb Replacement
Page 14 cal flame 2008 owner’s manual ltr20081044, rev. A cleaning and maintenance light bulb replacement warning: never attempt to replace a light bulb when the grill is in use. Serious burns will result. Warning: never touch halogen bulbs with your bare fingers. Use a tissue or a small piece of pa...
Page 17: Appendix
Cal flame 2008 owner’s manual page 15 ltr20081044, rev. A appendix appendix troubleshooting problem: smell of gas is present solution: check for loose connections in the gas line. Perform a leak test following the procedure described in this manual. Problem burner does not ignite solution use the fo...
Page 18
Page 16 cal flame 2008 owner’s manual ltr20081044, rev. A appendix problem: plugged orifice solution: unplug the orifice as follows: remove cooking grills, flame tamer and grease tray. • remove burners from the bottom of the firebox by pulling the cotter pin from beneath the burner • peg using a sta...
Page 19: Replacement Covers
Cal flame 2008 owner’s manual page 17 ltr20081044, rev. A appendix disconnect or shut off the gas line connect to the 1. Grill. Wait until the burners cool down. Open the hood and remove the grate and flame 2. Tamer on top of the burner you want to replace. Through the access door underneath the gri...
Page 20: Grill Specifications
Location of serial number plate the serial number of your cal flame grill is located on the back and is visible when the hood is down as shown at right. Grill specifications electrical supply: 220v ac / 50 hz country of destination be, cy, cz, ee, fr, gr, ie, it, lv, lt, lu, pt, ro, sk, es, ch, bg a...