Summary of BBQ11955P
Page 2: Www.Calflamebbq.Com
Copyright 2011 lms, inc. All rights re- served. Duplication without written consent is strictly prohibited. Cal flame ® is a registered trademark. Due to continuous improvement programs, all models, operation, and/or specifications are subject to change without prior notice. Ltr50001100, rev. A 4/26...
Page 3: Saf
Saf ety instructions 1 power burner ltr50001100, rev. A www.Calflamebbq.Com placement and location the cal flame power burner is designed for outdoor use only. Never locate this appliance in an enclosed room, under a sealed • overhead structure, or in any type of enclosed area such as a ga- rage, sh...
Page 4: Saf
2 saf ety instructions power burner ltr50001100, rev. A www.Calflamebbq.Com operation do not use the power burner for oth • er than its intended use. Never use the power burner if the drip pan is not in place. The drip • pan should be pushed all the way in under the power burner. Fire or explosion c...
Page 5: Saf
Saf ety instructions 3 power burner ltr50001100, rev. A www.Calflamebbq.Com garments while using your power burner. Fabric may ignite and result in personal injury. When using the power burner, do not touch the grate or immediate • surroundings as these areas become extremely hot and can cause burns...
Page 6: Installation /
4 installation / assemb ly power burner ltr50001100, rev. A www.Calflamebbq.Com most cities and counties require permits for exterior construction. In addition, some communities have codes requiring residential barriers such as fencing and/or self-closing gates on property to prevent unsu- pervised ...
Page 7: Installation /
Installation / assemb ly 5 power burner ltr50001100, rev. A www.Calflamebbq.Com cabinet cut-out dimensions your cal flame power burner is designed for easy installation into a non-combustible enclosure. The supporting deck or counter must be flat and level. Width depth height 18” 20” 9 ¼” width dept...
Page 8: Installation /
6 installation / assemb ly power burner ltr50001100, rev. A www.Calflamebbq.Com lp gas tank requirements for plumbed-in lp installation, use a convertible regulator and set it for lp gas. Maximum line pressure for plumbed-in propane is 14” wc (3.5 kpa). Minimum line pressure for propane is 11” wc. T...
Page 9: Installation /
Installation / assemb ly 7 power burner ltr50001100, rev. A www.Calflamebbq.Com the maximum fuel capacity is 20 lbs. Of propane, or 5 gallons. Full cyl- inder weight should be approximately 38 lbs. (43.7 lbs. Nominal water capacity.) never fill the cylinder beyond 80% full. Place the dust cap on the...
Page 10: Installation /
8 installation / assemb ly power burner ltr50001100, rev. A www.Calflamebbq.Com natural gas requirements always check the rating plate to make sure the gas supply you are hooking up to is the gas type the power burner is manufactured for. Important: never connect the power burner to an unregulated g...
Page 11: Installation /
Installation / assemb ly 9 power burner ltr50001100, rev. A www.Calflamebbq.Com leak testing procedure perform a leak test at least once a year whether the gas supply cylinder has been disconnected or not. In addition, whenever the gas cylinder is connected to the regulator or whenever any part of t...
Page 12: Installation /
10 installation / assemb ly power burner ltr50001100, rev. A www.Calflamebbq.Com placing the power burner in a built-in enclosure you may need a second person to help you to avoid damag- ing the power burner or your enclosure. Before installing the power burner in an enclosure, make sure that the op...
Page 13: Using
Using your grill 11 power burner ltr50001100, rev. A www.Calflamebbq.Com read all instructions before you operate your power burner. We recommend you wash the power burner thoroughly with soap and water prior to lighting it for the first time. Oils are used during the manufacturing process and some ...
Page 14: Using
12 using your grill power burner ltr50001100, rev. A www.Calflamebbq.Com basic operation before lighting, make sure all burner controls are off. Do not at- tempt to light the burners if the smell of gas is present. Check the connection with a soap and water solution after attaching the hose. For lp ...
Page 15: Using
Using your grill 13 power burner ltr50001100, rev. A www.Calflamebbq.Com lighting the power burner electronic ignition lift the cover. 1. Keep your face as far away from the burners as possible. 2. Turn the burner knob counter clockwise past the light position 3. To high. You will hear a loud click ...
Page 16: Using
14 using your grill power burner ltr50001100, rev. A www.Calflamebbq.Com power burner lid we strongly recommend you remove the lid for your power burner before each use. The power burner lid is attached to the unit by two hinges on each side. Each hinge has a detachable spring-loaded hinge pin that ...
Page 17: Using
Using your grill 15 power burner ltr50001100, rev. A www.Calflamebbq.Com using the wok ring if you have a wok, you can use it with the power burner. Remove the grate and set it aside. Inside the burner area, surrounding the brass burners, is a stainless steel ring that will securely hold your wok in...
Page 18: Cleaning and Maintenance
16 cleaning and maintenance power burner ltr50001100, rev. A www.Calflamebbq.Com cleaning and maintenance removing and replacing burners the burner has three pieces plus a wok ring. If you remove the burner for cleaning, make sure to clean each piece and replace them in proper order. Removal disconn...
Page 19: Cleaning and Maintenance
Cleaning and maintenance 17 power burner ltr50001100, rev. A www.Calflamebbq.Com replacement set the burner body in place, 1. Making sure the stud in prop- erly seated and the burner body is flat and level. Set the burner ring on the 2. Burner body, making sure the pin on the burner ring is seat- ed...
Page 20: Cleaning and Maintenance
18 cleaning and maintenance power burner ltr50001100, rev. A www.Calflamebbq.Com to ensure safe and proper maintenance, we recommend you follow these directions carefully. Clean internal parts of the power burner regularly as determined by the amount of use and foods cooked. The entire power burner ...
Page 21: Cleaning and Maintenance
Cleaning and maintenance 19 power burner ltr50001100, rev. A www.Calflamebbq.Com caution do not use wd-40 or sheila shine near food or on food preparation surfaces as it is a health hazard. This includes the interior of the power burner and the grate. Cleaning products and materials avoid using thes...
Page 22: Cleaning and Maintenance
20 cleaning and maintenance power burner ltr50001100, rev. A www.Calflamebbq.Com clean 1 . Thoroughly clean stains, food, and grime using a sponge or damp cloth with warm water and a mild dish soap. Use fantastik or for- mula 409 to remove heavier soil. Rinse 2 . Thoroughly rinse all surfaces and dr...
Page 23: Cleaning and Maintenance
Cleaning and maintenance 21 power burner ltr50001100, rev. A www.Calflamebbq.Com rust removal it is a common misconception that stainless steel does not rust. It does not stain, corrode, or rust as easily as ordinary steel (it stains less), but it is not stain-proof. If not properly protected and ma...
Page 24: Cleaning and Maintenance
22 cleaning and maintenance power burner ltr50001100, rev. A www.Calflamebbq.Com from the power burner by carefully lifting each burner up and away from the gas valve orifice. Use a wire brush to clean the outer surface of each burner to remove food residue and dirt. Clean any clogged ports with a s...
Page 25: Appendix
Appendix 23 power burner ltr50001100, rev. A www.Calflamebbq.Com troubleshooting problem: smell of gas is present solution: check for loose connections in the gas line. Perform a leak test following the procedure on page 9. Problem: burner does not ignite solution: use the following procedure with t...
Page 26: Appendix
24 appendix power burner ltr50001100, rev. A www.Calflamebbq.Com problem: plugged orifice solution: unplug the orifice as follows: remove grate and grease tray. • remove the burner ring and the outer burner. • carefully lift the center burner up and away from • the gas orifice. Remove the orifice fr...
Page 27: Appendix
Appendix 25 power burner ltr50001100, rev. A www.Calflamebbq.Com problem: misalignment of igniter on burner solution: check for proper position of the electrode tip, which • should be pointing forward towards the front of the burner and free of grease to allow proper sparking. The ignition wire shou...
Page 28: Appendix
26 appendix power burner ltr50001100, rev. A www.Calflamebbq.Com all cal flame gas appliances are manufactured to operate with standard liquid propane (lp and can be converted to burn natural gas (ng). There are two steps required to convert from lp to ng. You must perform both steps. Step 1: switch...
Page 29: Appendix
Appendix 27 power burner ltr50001100, rev. A www.Calflamebbq.Com step 1: switching the regulator the regulator in the image below has been removed to illustrate this pro- cedure. Remove the lp gas line. 1. Remove the cap fitting from the 2. End of the ng gas regulator. Place the cap fitting over the...
Page 30: Appendix
28 appendix power burner ltr50001100, rev. A www.Calflamebbq.Com step 2: changing the burner orifices remove the grate, burner ring, 1. And burner from the power burn- er. Locate the gas orifices. They will 2. Be directly behind the gas valves. Using a 6mm socket or nut driver, 3. Remove the orifice...
Page 31: Appendix
Appendix 29 power burner ltr50001100, rev. A www.Calflamebbq.Com apply a small amount of pipe compound to the orifice threads. 4. Screw in the orifice until it is finger tight. 5. Tighten the orifice with the 6mm wrench. 6. Repeat the above steps for the remaining burners. 7. Replace the burners and...
Page 32: Appendix
30 appendix power burner ltr50001100, rev. A www.Calflamebbq.Com limited warranty lms warrants the power burner and associated hardware from defects in material and workmanship for a period of one year from the original date of purchase. This includes deterioration and corrosion of burners, mounting...
Page 33: Appendix
Appendix 31 power burner ltr50001100, rev. A www.Calflamebbq.Com this warranty is void if the barbecue grill has been subject to negligence, alteration, misuse, repairs, dings, dents, scratches, or incorrect and / or prohibited applications, as specified in the owner’s manual. Gas lines must be inst...
Page 34: Appendix
32 appendix power burner ltr50001100, rev. A www.Calflamebbq.Com legal remedies this limited warranty gives you specific legal rights. You may have other rights, which may vary from state to state. Customer service for customer service, contact the authorized selling dealer immediately. If you need ...
Page 35: Appendix
Appendix 33 power burner ltr50001100, rev. A www.Calflamebbq.Com.
Page 36: Www.Calflamebbq.Com.
Ltr50001100, rev. A 4/26/11 california proposition 65 warning: chemicals known to the state of california to cause cancer, birth defects or other reproductive harm are found in and/or created by the combustion of natural gas, propane, butane and other fuels. Always operate this unit as described in ...