Summary of FPT-1100
Page 1
Ltr20081006, rev. A 3/10/08.
Page 2
Contact information for customer service, contact your authorized dealer immediately. If you need additional information and/ or assistance, contact: l.M.S. Customer service department 1462 east ninth street pomona, ca 91766. Toll free: 1-800-cal-spas fax: 1-909-629-3890 warning if the information i...
Page 3: Safety Instructions
2008 fireplace and firepit owner’s manual page 1 ltr20081006, rev. A safety instructions safety instructions warning: improper installation, adjustment, alteration, service or maintenance can cause injury or property damage. Read the installation, operating and maintenance instructions thoroughly be...
Page 4
Page 2 2008 fireplace and firepit owner’s manual ltr20081006, rev. A safety instructions do not use your firepit or fireplace for cooking. In the event that a burner goes out, turn burner knobs to the full off position and let it air out. Do not attempt to use the firepit or fireplace until the gas ...
Page 5: Location
2008 fireplace and firepit owner’s manual page 3 ltr20081006, rev. A installation and assembly do not use the appliance until the leak is corrected. Installation must conform with local building and/or fire codes, or in the absence of local codes: national fuel gas code ansi z223.1 / infpa 54 (for i...
Page 6: Liquid Propane (Lp)
Page 4 2008 fireplace and firepit owner’s manual ltr20081006, rev. A installation and assembly liquid propane (lp) requirements the 20 lb lp gas supply cylinder used with lp models must be constructed and marked in accordance with the specifications for lp-gas cylinders as required by the u.S. Depar...
Page 7
2008 fireplace and firepit owner’s manual page 5 ltr20081006, rev. A installation and assembly check the rating plate to make sure the gas supply you are hooking up to is the gas type the firepit or fireplace is manufactured for. If you do not have an updated filler valve on your existing propane ta...
Page 8: Natural Gas
Page 6 2008 fireplace and firepit owner’s manual ltr20081006, rev. A installation and assembly natural gas the appliance and its individual shut off valve must be disconnected from the gas supply piping system during any pressure testing of the system at test pressures in excess of ½ psig (3.5kpa). ...
Page 9: Fireplace Log Set Placement
2008 fireplace and firepit owner’s manual page 7 ltr20081006, rev. A installation and assembly fireplace log set placement the log set, log grate and crushed lava rock are shipped together on applicable models. Remove the log set and un-pack all components. The logs are fragile -- use care when hand...
Page 10: Fire Pit Burner Installation
Page 8 2008 fireplace and firepit owner’s manual ltr20081006, rev. A installation and assembly fire pit burner installation the log set, log grate and crushed lava rock are shipped together on applicable models. Remove the log set and un-pack all components. The logs are fragile -- use care when han...
Page 11: Natural Gas Conversion
2008 fireplace and firepit owner’s manual page 9 ltr20081006, rev. A installation and assembly natural gas conversion for both fireplaces or fire pits caution: this service is to be completed only by an authorized gas appliance installer. Do not attempt this conversion on your own as there is risk o...
Page 12: Operation
Page 10 2008 fireplace and firepit owner’s manual ltr20081006, rev. A operation warning: do not use solid fuel, such as wood or charcoal, in gas fueled fireplaces or fire pits. Upon completing the gas line connection, a small amount of air will be in the lines. When the first lighting the burner, it...
Page 13
2008 fireplace and firepit owner’s manual page 11 ltr20081006, rev. A operation for this kind of starter: remove protective storage cover and locate the manual gas control valve and igniter button on the fireplace. Make sure fuel supply is properly connected and turned on at the source / tank. Depre...
Page 14: Lighting Instructions For
Page 12 2008 fireplace and firepit owner’s manual ltr20081006, rev. A operation for this kind of fireplace: this appliance has a pilot which must be manually lit. When lighting the pilot, follow these instructions exactly. Open the fireplace screens. Push in the gas control knob slightly and turn it...
Page 15
2008 fireplace and firepit owner’s manual page 13 ltr20081006, rev. A operation have several sizes of wood available. Small pieces will be needed to start the fire, some medium sizes and finally larger logs that will burn for a longer period of time. Make sure all logs are small enough to fit entire...
Page 16: Maintenance
Page 14 2008 fireplace and firepit owner’s manual ltr20081006, rev. A maintenance maintenance inspect the appliance before initial use. Clean the appliance at least annually and have it inspected by a qualified field service person. Periodically remove the logs and examine the burner. If the burner ...
Page 17: Appendix
2008 fireplace and firepit owner’s manual page 15 ltr20081006, rev. A appendix appendix replacement parts call 1-800-cal-spas for any replacement parts not listed below. Be sure to have model name and number available. Fireplace parts bbq04103080 1/40 hp submersible recirculating pump plu21500290 3/...
Page 18: Specifications
Page 16 2008 fireplace and firepit owner’s manual ltr20081006, rev. A appendix fireplace specifications input fireplace model fuel max . Input btu/hr frp-1000, 1500, 2000, 3000, 3100 natural gas orifice size: .125 55,000 frp-1000, 1500, 2000, 3000, 3100 propane orifice size: #43 (0 .089) 55,000 frp-...
Page 19
2008 fireplace and firepit owner’s manual page 17 ltr20081006, rev. A appendix see your cal flame dealer for a copy of the applicable warranty, details and any questions you may have regarding the warranty coverage on your fire pit or fireplace. L.M.S. Warrants the fire pits and fireplaces from defe...
Page 20
Locating the product serial number the serial number of your cal flame fireplace or firepit is located on a metal plate on the back of the unit. You will need this number to properly register your product and activate coverage. Write this information in the space provided below. Fireplace / firepit ...