Summary of FRP908-3-1
Page 1
Ltr50001006, rev. G 2/1/17.
Page 2: Save These Instructions!
Copyright 2017 lms. All rights reserved. Duplication without written consent is strictly prohibited. Cal flame ® is a registered trademark. Due to continuous improvement programs, all models, operation, and/or specifications are subject to change without prior notice. Ltr50001006, rev. G 2/1/17 250-...
Page 3: Saf
Saf ety instructions 1 fireplace owner’s manual ltr50001006, rev. G www.Calflamebbq.Com safety instructions what to do if you smell gas • shut off gas to the fireplace. • extinguish any open flame. • do not try to light the appliance. • if odor continues, keep away from the appliance and immediately...
Page 4: Saf
2 saf ety instructions fireplace owner’s manual ltr50001006, rev. G www.Calflamebbq.Com operation • do not use charcoal or other solid fuel in a gas burning fireplace. • do not operate the fireplace with the propane tank on, near, or un- der the hearth! This could result in fire, explosion, or sever...
Page 5: Saf
Saf ety instructions 3 fireplace owner’s manual ltr50001006, rev. G www.Calflamebbq.Com maintenance and repair • spiders and other insects can nest in the burners and block the gas and airflow to the burner ports. This creates a dangerous condi- tion that can result in a fire from behind the valve p...
Page 6: Saf
4 saf ety instructions fireplace owner’s manual ltr50001006, rev. G www.Calflamebbq.Com storage • when your fireplace is not in use, turn off the gas at the source. • do not store the propane cylinder in the vicinity of this or any other appliance when it is not being used. • this appliance can be s...
Page 7: Installation /
Installation / assemb ly 5 fireplace owner’s manual ltr50001006, rev. G www.Calflamebbq.Com set-up you are responsible for ensuring that a natural gas line (if required) is installed and safe for use. We recommend that a licensed contrac- tor install your fireplace. Installation must conform to loca...
Page 8: Installation /
6 installation / assemb ly fireplace owner’s manual ltr50001006, rev. G www.Calflamebbq.Com placement and location cal flame fireplaces are designed for outdoor use only . • never locate this appliance in a building, garage, or any other en- closed room or under a sealed overhead structure, or in an...
Page 9: Installation /
Installation / assemb ly 7 fireplace owner’s manual ltr50001006, rev. G www.Calflamebbq.Com leak testing procedure perform a leak test at least once a year whether the gas supply cylinder has been disconnected or not. In addition, whenever the gas cylinder is connected to the regulator or whenever a...
Page 10: Installation /
8 installation / assemb ly fireplace owner’s manual ltr50001006, rev. G www.Calflamebbq.Com liquid propane your cal flame fireplace is not provided with a propane cylinder. If you choose to operate your fireplace with propane, you must supply your own cylinder. Requirements the 20 lb propane gas sup...
Page 11: Installation /
Installation / assemb ly 9 fireplace owner’s manual ltr50001006, rev. G www.Calflamebbq.Com connection check the rating plate to make sure the gas supply you are hooking up to is the gas type the fireplace is manufactured for. Inspect the hose shipped with the unit for damage. Never attempt to use d...
Page 12: Installation /
10 installation / assemb ly fireplace owner’s manual ltr50001006, rev. G www.Calflamebbq.Com propane cylinder enclosure cal flame fireplaces do not have an enclosure for the propane cylinder. If you build an enclosure for a propane gas cylinder, follow these rec- ommended specifications and follow l...
Page 13: Installation /
Installation / assemb ly 11 fireplace owner’s manual ltr50001006, rev. G www.Calflamebbq.Com 2) all sides are completely enclosed. This method requires at least two ventilation openings at cylinder valve level in the side wall, equally sized, spaced at 180 degrees (3.14 rad), and unobstructed. Make ...
Page 14: Installation /
12 installation / assemb ly fireplace owner’s manual ltr50001006, rev. G www.Calflamebbq.Com natural gas ensure that the service supplying the fireplace is fitted with a conve- niently positioned shut off valve with easy access. The shut off valve must not be inside the appliance! Requirements alway...
Page 15: Installation /
Installation / assemb ly 13 fireplace owner’s manual ltr50001006, rev. G www.Calflamebbq.Com fireplace burner installation this procedure describes how to access the gas lines for installation. Gas installation should be performed by a qualified contractor. 2. Remove the right side refractory wall f...
Page 16: Installation /
14 installation / assemb ly fireplace owner’s manual ltr50001006, rev. G www.Calflamebbq.Com 4. Slide the flex line and the black sparker wires into the gap in the hearth base. 6. Connect the black sparker wires to the valve as shown below. 5. Reach through the gap in the open right side and pull th...
Page 17: Installation /
Installation / assemb ly 15 fireplace owner’s manual ltr50001006, rev. G www.Calflamebbq.Com caution! Never place or store the propane tank under the hearth base! 9. Connect the lp or ng gas source gas line to the gas valve as shown below. 10. Replace the right side refrac- tory wall. 11. Unscrew th...
Page 18: Installation /
16 installation / assemb ly fireplace owner’s manual ltr50001006, rev. G www.Calflamebbq.Com fireplace log set placement the log set, log grate and crushed lava rock are shipped together on applicable models. Remove the log set and unpack all components. The logs are fragile -- use care when handlin...
Page 19: Installation /
Installation / assemb ly 17 fireplace owner’s manual ltr50001006, rev. G www.Calflamebbq.Com high elevation installation your fireplace is approved for elevations up to 4,500 feet in the us and canada. When installing this appliance at an elevation above 4,500 feet in the us, it may be necessary to ...
Page 20: Installation /
18 installation / assemb ly fireplace owner’s manual ltr50001006, rev. G www.Calflamebbq.Com burn and as a general rule, the air shutter for propane installation should be completely open, and the air shutter for ng installation should be mostly closed. This can be adjusted later to create a clean a...
Page 21: Operation
Operation 19 fireplace owner’s manual ltr50001006, rev. G www.Calflamebbq.Com warning: do not use solid fuel, such as wood or charcoal, in a gas fueled fireplace. Upon completing the gas line connection, a small amount of air will be in the lines. When the first lighting the burner, it will take a f...
Page 22: Operation
20 operation fireplace owner’s manual ltr50001006, rev. G www.Calflamebbq.Com and replace any part of the control system and any gas control which has been under water. • make sure the ignitor battery has been installed properly. Ignitor will not operate properly without a battery installed. Lightin...
Page 23: Operation
Operation 21 fireplace owner’s manual ltr50001006, rev. G www.Calflamebbq.Com the unit and then turn the valve on the propane tank to the off posi- tion clockwise. Note the propane regulator in this appliance is equipped with a low flow protection device. Unless the propane cylinder valve is opened ...
Page 24: Cleaning and Maintenance
22 cleaning and maintenance fireplace owner’s manual ltr50001006, rev. G www.Calflamebbq.Com inspect the appliance before initial use. Clean the appliance at least annually and have it inspected by a qualified field service person. Periodically remove the logs and examine the burner. If the burner i...
Page 25: Replacement P
Replacement p ar ts 23 fireplace owner’s manual ltr50001006, rev. G www.Calflamebbq.Com replacement parts call 1-800-225-7727 for any replacement parts not listed below. Be sure to have model name and number available. Replacement parts shown below are listed first as complete assemblies with indivi...
Page 26: Specifications
24 specifications fireplace owner’s manual ltr50001006, rev. G www.Calflamebbq.Com propane gas natural gas max . Input btu/ hr 55,000 49,000 orifice size #43 (0.089) 1/8” (.125) manifold pressure 10” water column 7” water column maximum gas supply pressure 11” water column 14” water column maximum i...
Page 27: Limited
Limited w ar ranty 25 fireplace owner’s manual ltr50001006, rev. G www.Calflamebbq.Com all cal flame models are manufactured with the highest quality ap- pliances and are warranted to be free from defects in material and workmanship at time of delivery. Lms warrants fireplaces and associated hardwar...
Page 28: Limited
26 limited w ar ranty fireplace owner’s manual ltr50001006, rev. G www.Calflamebbq.Com warranty limitations and exclusions grate and log set are not covered by this warranty. This warranty is void if the fireplace has been subject to negligence, al- teration, misuse, repairs, dings, dents, scratches...
Page 29: Legal Remedies
Or other custom fixtures or the necessity for crane removal. Any im- plied warranty shall have duration equal of the applicable warranty stated above. Natural stone: rock, travertine, marble, etc. May be characterized by dry seams, pits, chips, cracks, and fossils that are often filled with grout du...
Page 30: Limited
28 limited w ar ranty fireplace owner’s manual ltr50001006, rev. G www.Calflamebbq.Com.
Page 31: Limited
Limited w ar ranty 29 fireplace owner’s manual ltr50001006, rev. G www.Calflamebbq.Com.
Page 32: Www.Calflamebbq.Com
Ltr50001006, rev. G 2/1/17 contact information for customer service, please contact your authorized dealer immediately. If you need additional information and/or assistance, please contact: cal flame customer service department 1462 east ninth street pomona, ca 91766 toll free: 1-800-225-7727 fax: 1...