Summary of G3
Page 2: Www.Calspas.Com
Copyright 2008-2009 lms, inc. All rights reserved. Duplication without written consent is strictly prohibited. Cal flame ® is a registered trademark. Due to continuous improvement programs, all models, operation, and/or specifications are subject to change without prior notice. Ltr20091050, rev. A 1...
Page 3: Saf
Saf ety instructions 1 2009 g3, g4, g5 grills ltr20091050, rev. A www.Calspas.Com placement and location cal flame grills are designed for outdoor use only. Never locate this appliance in an enclosed room, under a sealed • overhead structure, or in any type of enclosed area such as a garage, shed, o...
Page 4: Saf
2 saf ety instructions 2009 g3, g4, g5 grills ltr20091050, rev. A www.Calspas.Com before you start cooking, clean the entire grill thoroughly with hot, • soapy water. This is necessary to remove residual solvents, oil and grease used in the manufacturing process. The grates should also be thoroughly...
Page 5: Saf
Saf ety instructions 3 2009 g3, g4, g5 grills ltr20091050, rev. A www.Calspas.Com garments while using your grill. Fabric may ignite and result in personal injury. When using the grill, do not touch the grill rack, burner grate, or • immediate surroundings as these areas become extremely hot and can...
Page 6: Installation /
4 installation / assemb ly 2009 g3, g4, g5 grills ltr20091050, rev. A www.Calspas.Com most cities and counties require permits for exterior construction and electrical circuits. In addition, some communities have codes requiring residential barriers such as fencing and/or self-closing gates on prope...
Page 7: Installation /
Installation / assemb ly 5 2009 g3, g4, g5 grills ltr20091050, rev. A www.Calspas.Com cabinet cut-out dimensions your cal flame grill is designed for easy installation into a non- combustible enclosure. The supporting deck or counter must be flat and level. When determining the final location of you...
Page 8: Installation /
6 installation / assemb ly 2009 g3, g4, g5 grills ltr20091050, rev. A www.Calspas.Com lp gas tank requirements for plumbed-in lp installation, use a convertible regulator and set it for lp gas. Maximum line pressure for plumbed-in propane is 14” wc (3.5 kpa). Minimum line pressure for propane is 11”...
Page 9: Installation /
Installation / assemb ly 7 2009 g3, g4, g5 grills ltr20091050, rev. A www.Calspas.Com the maximum fuel capacity is 20 lbs. Of propane, or 5 gallons. Full cylinder weight should be approximately 38 lbs. (43.7 lbs. Nominal water capacity.) never fill the cylinder beyond 80% full. Place the dust cap on...
Page 10: Installation /
8 installation / assemb ly 2009 g3, g4, g5 grills ltr20091050, rev. A www.Calspas.Com natural gas requirements always check the rating plate to make sure the gas supply you are hooking up to is the gas type the grill is manufactured for. Important: never connect the grill to an unregulated gas suppl...
Page 11: Installation /
Installation / assemb ly 9 2009 g3, g4, g5 grills ltr20091050, rev. A www.Calspas.Com leak testing procedure perform a leak test at least once a year whether the gas supply cylinder has been disconnected or not. In addition, whenever the gas cylinder is connected to the regulator or whenever any par...
Page 12: Installation /
10 installation / assemb ly 2009 g3, g4, g5 grills ltr20091050, rev. A www.Calspas.Com installing the grill in a barbecue island you will need a second person to help you to avoid damaging the grill or your barbecue island. Before installing a grill in any island or cut out, make sure that the openi...
Page 13: Using
Using your grill 11 2009 g3, g4, g5 grills ltr20091050, rev. A www.Calspas.Com read all instructions before you operate your grill. We recommend you wash your entire grill with soap and water prior to lighting it for the first time. Oils are used during the manufacturing process and some residual oi...
Page 14: Using
12 using your grill 2009 g3, g4, g5 grills ltr20091050, rev. A www.Calspas.Com basic grill operation before lighting, make sure all burner controls are off. Do not attempt to light the burners if the smell of gas is present. Check the connection with a soap and water solution after attaching the hos...
Page 15: Using
Using your grill 13 2009 g3, g4, g5 grills ltr20091050, rev. A www.Calspas.Com electronically lighting the grill open the hood. 1. Keep your face as far away from the burners as possible. 2. Rapidly rotate the burner knob counter clockwise past the light 3. Position to high. You will hear a loud cli...
Page 16: Using
14 using your grill 2009 g3, g4, g5 grills ltr20091050, rev. A www.Calspas.Com manually lighting the grill warning: do not use standard matches or cigarette lighters to perform match lighting procedures. Serious burns can occur and lighters can explode. Open the hood. 1. If you have just attempted t...
Page 17: Cleaning and Maintenance
Cleaning and maintenance 15 2009 g3, g4, g5 grills ltr20091050, rev. A www.Calspas.Com clean internal parts of the grill regularly as determined by the amount of use and foods cooked. The entire grill should be cleaned at least once a year. In addition, keep the area around your grill clear and free...
Page 18: Cleaning and Maintenance
16 cleaning and maintenance 2009 g3, g4, g5 grills ltr20091050, rev. A www.Calspas.Com stainless steel do not use wire wool pads, scrappers, harsh abrasive, scoring materials, bleaches, or harsh cleaners on your grill, or allow salt and vinegar mixtures to remain in contact for a long period of time...
Page 19: Appendix
Appendix 17 2009 g3, g4, g5 grills ltr20091050, rev. A www.Calspas.Com troubleshooting problem: smell of gas is present solution: check for loose connections in the gas line. Perform a leak test following the procedure described in this manual. Problem: burner does not ignite solution: use the follo...
Page 20: Appendix
18 appendix 2009 g3, g4, g5 grills ltr20091050, rev. A www.Calspas.Com problem: plugged orifice solution: unplug the orifice as follows: remove cooking grills, flame tamer and grease • tray. Remove burners from the bottom of the firebox by • pulling the cotter pin from beneath the burner peg using a...
Page 21: Appendix
Appendix 19 2009 g3, g4, g5 grills ltr20091050, rev. A www.Calspas.Com problem: yellow flame solution: once the entire burner is operating, check the flame color to be sure that it is mostly blue. Some yellow at the tips may be present due to impurities in the fuel. If the flame is golden or yellow ...
Page 22: Appendix
20 appendix 2009 g3, g4, g5 grills ltr20091050, rev. A www.Calspas.Com replacement covers cvrblt001 cover, grill, medium, 3 burner cvrblt003 cover, grill, medium, 4 burner cvrblt007 cover, grill, medium, 3 burner removing and replacing burners disconnect or shut off the gas line connect to the grill...
Page 23: Appendix
Appendix 21 2009 g3, g4, g5 grills ltr20091050, rev. A www.Calspas.Com 2009 warranty lms warrants the g3, g4, and g5 grill and associated hardware from defects in material and workmanship for a period of one year from the original date of purchase. One year equipment and component warranty lms warra...
Page 24: Appendix
22 appendix 2009 g3, g4, g5 grills ltr20091050, rev. A www.Calspas.Com to the original purchase price. Warranty repair and / or replacement is the sole discretion of lms and this warranty does not cover costs therein, including but not limited to: freight, removal, re-installation, etc. This warrant...
Page 25: Appendix
Appendix 23 2009 g3, g4, g5 grills ltr20091050, rev. A www.Calspas.Com disclaimers lms shall not be liable for loss of use of the barbecue grills or related hardware or other incidental or consequential costs, expense or damages, which may include, but are not limited to, removal of permanent deck o...
Page 26: Appendix
24 appendix 2009 g3, g4, g5 grills ltr20091050, rev. A www.Calspas.Com.
Page 27: Appendix
Appendix 25 2009 g3, g4, g5 grills ltr20091050, rev. A www.Calspas.Com.
Page 28: Www.Calspas.Com
Ltr20091050, rev. A 12/11/08 lms customer service department 1462 east ninth street pomona, ca 91766 toll free: 1-800-cal-spas fax: 1-909-629-3890 www.Calspas.Com.