Copyright 2008-2009 lms, inc. All rights re- served. Duplication without written consent is strictly prohibited. Cal flame ® is a registered trademark. Due to continuous improvement programs, all models, operation, and/or specifications are subject to change without prior notice. Ltr20091006, rev. B...
Saf ety instructions 1 2009 fireplaces and firepits ltr20091006, rev. B www.Calspas.Com most cities and counties require permits for exteri- or construction and electrical circuits. In addition, some communities have codes requiring residential barriers such as fencing and/or self-closing gates on p...
2 saf ety instructions 2009 fireplaces and firepits ltr20091006, rev. B www.Calspas.Com do not block the vents located near the base of your firepit or • fireplace as gas may build up in case of leak and cause serious damage. Do not install or operate your fireplace in such a manner that the • cross...
Saf ety instructions 3 2009 fireplaces and firepits ltr20091006, rev. B www.Calspas.Com keep all electrical supply cords away from the heated areas of the • fireplace or firepit. Never use the fireplace or firepit in windy conditions. If used in a • consistently windy area a windbreak will be requir...
4 saf ety instructions 2009 fireplaces and firepits ltr20091006, rev. B www.Calspas.Com more frequent cleaning may be required as necessary. It is impera- • tive the control compartment, burner and circulation air passage- ways of the appliance be kept clean and free. Any guard or other protective d...
Installation / assemb ly 5 2009 fireplaces and firepits ltr20091006, rev. B www.Calspas.Com installation must conform with local building and/or fire codes, or in the absence of local codes: national fuel gas code ansi z223.1 / infpa 54 (for installation in • the united states) csa b149.1 natural ga...
6 installation / assemb ly 2009 fireplaces and firepits ltr20091006, rev. B www.Calspas.Com leak testing procedure perform a leak test at least once a year whether the gas supply cylinder has been disconnected or not. In addition, whenever the gas cylinder is connected to the regulator or whenever a...
Installation / assemb ly 7 2009 fireplaces and firepits ltr20091006, rev. B www.Calspas.Com liquid propane (lp) requirements the 20 lb lp gas supply cylinder used with lp models must be con- structed and marked in accordance with the specifications for lp-gas cylinders as required by the u.S. Depart...
8 installation / assemb ly 2009 fireplaces and firepits ltr20091006, rev. B www.Calspas.Com 2) having at least two ventilation openings at cylinder valve level in the side wall, equally sized, spaced at 180 degrees (3.14 rad), and unobstructed. Make sure each opening has a total free area of not les...
Installation / assemb ly 9 2009 fireplaces and firepits ltr20091006, rev. B www.Calspas.Com connection inspect the hose shipped with the unit for damage. Never attempt to use damaged or plugged equipment. See your local lp gas dealer for repairs. After inspecting the lp hose shipped with the unit, c...
10 installation / assemb ly 2009 fireplaces and firepits ltr20091006, rev. B www.Calspas.Com natural gas the appliance and its individual shut off valve must be disconnected from the gas supply piping system during any pressure testing of the system at test pressures in excess of ½ psig (3.5kpa). Th...
Installation / assemb ly 11 2009 fireplaces and firepits ltr20091006, rev. B www.Calspas.Com fireplace burner installation this procedure describes how to access the gas lines for installation. Gas installation should be performed by a qualified contractor. Slide the hearth base out of 1. The firepl...
12 installation / assemb ly 2009 fireplaces and firepits ltr20091006, rev. B www.Calspas.Com while holding the burner in 4. Place, extend the wire from the burner to the sparker switch located on the right side of the fireplace. Con- nect the wire to the electric sparker. Slide the hearth base back ...
Installation / assemb ly 13 2009 fireplaces and firepits ltr20091006, rev. B www.Calspas.Com fire pit burner installation the log set and crushed lava rock are shipped together on applicable models. Remove the log set and un-pack all components. The logs are fragile -- use care when handling. Turn t...
14 installation / assemb ly 2009 fireplaces and firepits ltr20091006, rev. B www.Calspas.Com set the burner in the center of the pit. Place the rocks on top of and around the burner. Arrange the log set on top..
Installation / assemb ly 15 2009 fireplaces and firepits ltr20091006, rev. B www.Calspas.Com fireplace log set placement the log set, log grate and crushed lava rock are shipped together on applicable models. Remove the log set and un-pack all components. The logs are fragile -- use care when handli...
16 installation / assemb ly 2009 fireplaces and firepits ltr20091006, rev. B www.Calspas.Com “fire on ice” glass placement some fire pit owners have the “fire on ice” option which uses decora- tive glass chips instead of lava rocks and a log set. (this option is avail- able to all fire pit owners an...
Installation / assemb ly 17 2009 fireplaces and firepits ltr20091006, rev. B www.Calspas.Com high elevation installation your fireplace or fire pit is approved for elevations up to 4500 feet in the us and canada. When installing this appliance at an elevation above 4500 feet in the us, it may be nec...
18 installation / assemb ly 2009 fireplaces and firepits ltr20091006, rev. B www.Calspas.Com low a controlled amount of air flow through the screen and into the fuel supply tube. Flame should have good retention. For a proper burn and as a general rule, the air shutter for propane installation shoul...
Using your grill 19 2009 fireplaces and firepits ltr20091006, rev. B www.Calspas.Com warning: do not use solid fuel, such as wood or charcoal, in gas fueled fireplaces or fire pits. Upon completing the gas line connection, a small amount of air will be in the lines. When the first lighting the burne...
20 using your grill 2009 fireplaces and firepits ltr20091006, rev. B www.Calspas.Com do not use this appliance if any part has been under water. Imme- • diately call a qualified service technician to inspect the appliance and replace any part of the control system and any gas control which has been ...
Using your grill 21 2009 fireplaces and firepits ltr20091006, rev. B www.Calspas.Com to turn off gas turn the on/off valve to the off position at the unit for natural gas unit. For lp unit, turn the on/off valve to the off position at the unit and then turn the valve on the lp tank to the off positi...
22 using your grill 2009 fireplaces and firepits ltr20091006, rev. B www.Calspas.Com lighting your wood burning fireplace your wood burning fireplace is designed to use a grate to hold the wood to be burned approximately 2”-3” off the base. This allows air to get to the bottom of the wood and gives ...
Cleaning and maintenance 23 2009 fireplaces and firepits ltr20091006, rev. B www.Calspas.Com inspect the appliance before initial use. Clean the appliance at least annually and have it inspected by a qualified field service person. Periodically remove the logs and examine the burner. If the burner i...
24 appendix 2009 fireplaces and firepits ltr20091006, rev. B www.Calspas.Com replacement parts call 1-800-cal-spas for any replacement parts not listed below. Be sure to have model name and number available. Fireplace parts 18” log set bbq08000610 24” log set bbq08000620 18” grate bbq08210650 square...
Appendix 25 2009 fireplaces and firepits ltr20091006, rev. B www.Calspas.Com firepit parts ng orifice .125 bbq04100077 propane orifice #43 bbq04100078 replacement crushed lava rock kit fp0100 replacement fire pit electronic igniter fp0102 replacement fire pit gas control knob fp0103 replacement fire...
26 appendix 2009 fireplaces and firepits ltr20091006, rev. B www.Calspas.Com specifications fireplace specifications lp gas natural gas max . Input btu/ hr 51,037 55,000 orifice size #42 (0.0860) #26 (0.147) manifold pressure 10” water column 7” water column maximum gas supply pressure 11” water col...
Appendix 27 2009 fireplaces and firepits ltr20091006, rev. B www.Calspas.Com see your cal flame dealer for a copy of the applicable warranty, details and any questions you may have regarding the warranty coverage on your fire pit or fireplace. L.M.S. Warrants the fire pits and fireplaces from defect...
28 appendix 2009 fireplaces and firepits ltr20091006, rev. B www.Calspas.Com neglect • the use of components not supplied with the appliance • the use of fuel other than those specified • weather, including freezing damage, long periods of dampness, or • condensation damaging chemical or cleaners • ...
Appendix 29 2009 fireplaces and firepits ltr20091006, rev. B www.Calspas.Com.
Ltr20091006, rev. B 3/30/09 contact information for customer service, please contact your authorized dealer immediately. If you need additional information and/or assistance, please contact: customer service department 1462 east ninth street pomona, ca 91766 toll free: 1-800-cal-spas fax: 1-909-629-...