Summary of LTR20091039
Page 2: Www.Calspas.Com
Copyright 2008-2009 lms, inc. All rights re- served. Duplication without written consent is strictly prohibited. Cal flame ® is a registered trademark. Due to continuous improvement programs, all models, operation, and/or specifications are subject to change without prior notice. Ltr20091039, rev. A...
Page 3: Saf
Saf ety instructions 1 2009 pizza cart ltr20091039, rev. A www.Calspas.Com placement and location the c • al flame pizza oven is designed for outdoor use only. Never locate this appliance in an enclosed room, under a sealed • overhead structure, or in any type of enclosed area such as a ga- rage, sh...
Page 4: Saf
2 saf ety instructions 2009 pizza cart ltr20091039, rev. A www.Calspas.Com in the event that the burner goes out, turn the burner knob to the • full off position, fully open the oven door and let it air out. Do not attempt to use the pizza oven until the gas has had time to dissipate. Never use the ...
Page 5: Saf
Saf ety instructions 3 2009 pizza cart ltr20091039, rev. A www.Calspas.Com never put combustible material such as paper, cloth, or flammable • liquids inside or on your pizza oven at any time. Do not use the pizza oven to store flammable materials. Never allow temperature to ex • ceed 500° f. Mainte...
Page 6: Installation /
4 installation / assemb ly 2009 pizza cart ltr20091039, rev. A www.Calspas.Com most cities and counties require permits for exterior construction and electrical circuits. In addition, some communities have codes requiring residential barriers such as fencing and/or self-closing gates on prop- erty t...
Page 7: Installation /
Installation / assemb ly 5 2009 pizza cart ltr20091039, rev. A www.Calspas.Com leak testing procedure perform a leak test at least once a year whether the gas supply cyl- inder has been disconnected or not. In addition, whenever the gas cylinder is connected to the regulator or whenever any part of ...
Page 8: Installation /
6 installation / assemb ly 2009 pizza cart ltr20091039, rev. A www.Calspas.Com gas requirements and connection important: cal flame™ pizza ovens are manufactured to operate on liquid propane (lp) but can be converted to natural gas (ng). To verify the oven’s operating fuel, check the serial number l...
Page 9: Installation /
Installation / assemb ly 7 2009 pizza cart ltr20091039, rev. A www.Calspas.Com lp gas hook up vent the enclosure for an lp gas cylindar with openings at the level of the cylinder valve and at the floor level. Ensure one side of the enclosure is completely open. For enclosures that have four sides, c...
Page 10: Installation /
8 installation / assemb ly 2009 pizza cart ltr20091039, rev. A www.Calspas.Com natural gas warning: all pizza ovens use lp unless they are converted to natural gas. Do not connect natural gas to an unconverted pizza oven! Requirements always check the rating plate to make sure the gas supply you are...
Page 11: Installation /
Installation / assemb ly 9 2009 pizza cart ltr20091039, rev. A www.Calspas.Com installing the transformer all grills with electrical components such as lights or a convection fan will require the transformer to be installed and plugged in before you can use it. This needs to be done before the grill...
Page 12: Installation /
10 installation / assemb ly 2009 pizza cart ltr20091039, rev. A www.Calspas.Com installing the bricks and rack the pizza oven uses three white bricks for diffusing heat from the burners. After you have removed the pizza oven from the box and removed all packing materials, place the three racks lengt...
Page 13: Operating
Operating your pizza ov en 11 2009 pizza cart ltr20091039, rev. A www.Calspas.Com read all instructions before use. We recommend you wash your entire pizza oven with soap and water prior to lighting it for the first time. Oils are used during the manufac- turing process and some residual oil may sti...
Page 14: Operating
12 operating your pizza ov en 2009 pizza cart ltr20091039, rev. A www.Calspas.Com manually lighting the oven use the match extender that comes with the pizza oven for manu- ally lighting. Do not use standard matches or cigarette lighters to perform match lighting procedures. Serious burns can occur ...
Page 15: Operating
Operating your pizza ov en 13 2009 pizza cart ltr20091039, rev. A www.Calspas.Com turning on and off the lights and fan the on / off switch controlling your halogen light is located at the control panel on the front lower left side. Certain models of the cal flame grill are equipped with either one ...
Page 16: Operating
14 operating your pizza ov en 2009 pizza cart ltr20091039, rev. A www.Calspas.Com safety considerations each time you light the pizza oven, check the following: inspect the hose before using the pizza oven. If there is exces- • sive abrasion or wear, or if the hose is cut, it must be replaced prior ...
Page 17: Cleaning and Maintenance
Cleaning and maintenance 15 2009 pizza cart ltr20091039, rev. A www.Calspas.Com to ensure safe and proper maintenance, we recommend you follow these directions carefully. Clean internal parts regularly as determined by the amount of use and foods cooked. The entire pizza oven should be cleaned at le...
Page 18: Cleaning and Maintenance
16 cleaning and maintenance 2009 pizza cart ltr20091039, rev. A www.Calspas.Com burner spiders and small insects occasionally inhabit or make nests in the burner tubes, obstructing the gas flow. Sometimes this results in a type of fire in and around the gas tubes called flashback. To reduce the risk...
Page 19: Appendix
Appendix 17 2009 pizza cart ltr20091039, rev. A www.Calspas.Com appendix troubleshooting problem: smell of gas is present solution: check for loose connections in the gas line. Perform a leak test following the procedure described in this man- ual. Problem: burner does not ignite solution: use the f...
Page 20: Appendix
18 appendix 2009 pizza cart ltr20091039, rev. A www.Calspas.Com problem: pluggedorifice solution: unplug the orifice as follows: remove cooking grills, flame tamer and grease • tray. Remove burners from the bottom of the firebox by • pulling the cotter pin from beneath the burner peg using a standar...
Page 21: Appendix
Appendix 19 2009 pizza cart ltr20091039, rev. A www.Calspas.Com problem: misalignment of igniter on burner solution: check for proper position of the electrode tip, which • should be pointing forward towards the front of the burner and free of grease to allow proper sparking. The ignition wire shoul...
Page 22: Appendix
20 appendix 2009 pizza cart ltr20091039, rev. A www.Calspas.Com warranty lms offers the following limited warranty against defects in material and workmanship on cal flame pizza carts. All cal flame pizza carts are manufactured with the highest quality appli- ances and are warranted to be free from ...
Page 23: Appendix
Appendix 21 2009 pizza cart ltr20091039, rev. A www.Calspas.Com warranty limitations this warranty is void if the pizza cart has been subject to negligence, al- teration, misuse, repairs, dings, dents, scratches, or incorrect and / or pro- hibited applications, as specified in the owner’s manual. Ga...
Page 24: Www.Calspas.Com
Ltr20091039, rev. A 3/16/09 lms customer service department 1462 east ninth street pomona, ca 91766 toll free: 1-800-cal-spas fax: 1-909-629-3890 www.Calspas.Com.