1. DL manuals
  2. Cal Spas
  3. Plumbing Product
  4. CU-210
  5. Owner's Manual

Cal Spas CU-210 Owner's Manual

Manual is about: Cal Heat Saunas Owner's Manual

Summary of CU-210

  • Page 1

    Ltr20091007, rev. A 12/16/08.

  • Page 2

    Copyright 2009 lms, inc. All rights reserved. Duplication without written consent is strictly prohibited. Cal spas™ and cal heat™ are registered trademarks. Due to continuous improvement programs, all models, operation, and/or specifications are subject to change without prior notice. Ltr20091007, r...

  • Page 3: Saf

    2009 saunas ltr20091007, rev. A saf ety instructions 3 when installing and using this electrical • equipment, basic safety precautions should always be followed. To reduce the risk of injury, do not allow children • to use this equipment unless they are supervised at all times. Do not use this equip...

  • Page 4: Eparing F

    2009 saunas ltr20091007, rev. A pr eparing f or your ne w sauna 4 most cities and counties require permits for exterior construction and electrical circuits. In addition, some communities have codes requiring residential barriers such as fencing and/or self-closing gates on property to prevent unsup...

  • Page 5: Eparing F

    2009 saunas ltr20091007, rev. A pr eparing f or your ne w sauna 5 preparing a good foundation your retailer has a wealth of information and experience about how to get the most out of your sauna. Your sauna retailer also has a full line of accessories that are designed to complement your sauna. Your...

  • Page 6: Eparing F

    2009 saunas ltr20091007, rev. A pr eparing f or your ne w sauna 6 custom sauna dimensions model depth width height cu-210 4’ 6’ 7’ cu-300 6’ 6’ 7’ cu-400 7’ 7’ 7’.

  • Page 7: Eparing F

    2009 saunas ltr20091007, rev. A pr eparing f or your ne w sauna 7 important: when installed in the united states, the electrical wiring of this sauna must meet the requirements of the national electric code (nec) and any applicable state or local codes. The electrical circuit must be installed by an...

  • Page 8: Assemb

    2009 saunas ltr20091007, rev. A assemb ling your sauna 8 cu-210 sauna assembly remove the packaging panel marked “open this end” first to access the contents. Once the panel is removed, unscrew the cross-member support from inside the crate. Remove the contents from the crate and assemble in a place...

  • Page 9: Assemb

    2009 saunas ltr20091007, rev. A assemb ling your sauna 9 figure 1. Bench assembly figure 2. Bench and heater installation.

  • Page 10: Assemb

    2009 saunas ltr20091007, rev. A assemb ling your sauna 10 figure 3. Attaching the rear and side wall.

  • Page 11: Assemb

    2009 saunas ltr20091007, rev. A assemb ling your sauna 11 figure 4. Attaching the front and side wall.

  • Page 12: Assemb

    2009 saunas ltr20091007, rev. A assemb ling your sauna 12 figure 5. Installing the heater guard and roof trim.

  • Page 13: Assemb

    2009 saunas ltr20091007, rev. A assemb ling your sauna 13 figure 6. Attaching the roof and exterior framing.

  • Page 14: Assemb

    2009 saunas ltr20091007, rev. A assemb ling your sauna 14 cu-300 sauna assembly remove the packaging panel marked “open this end” first to access the contents. Once the panel is removed, unscrew the cross-member support from inside the crate. Remove the contents from the crate and assemble in a plac...

  • Page 15: Assemb

    2009 saunas ltr20091007, rev. A assemb ling your sauna 15 figure 2. Bench and heater installation figure 1. Bench assembly.

  • Page 16: Assemb

    2009 saunas ltr20091007, rev. A assemb ling your sauna 16 figure 3. Attaching the rear walls and back support.

  • Page 17: Assemb

    2009 saunas ltr20091007, rev. A assemb ling your sauna 17 figure 4. Attaching the side walls.

  • Page 18: Assemb

    2009 saunas ltr20091007, rev. A assemb ling your sauna 18 figure 5. Attaching the front wall with door.

  • Page 19: Assemb

    2009 saunas ltr20091007, rev. A assemb ling your sauna 19 figure 6. Attaching the roof and exterior framing.

  • Page 20: Assemb

    2009 saunas ltr20091007, rev. A assemb ling your sauna 20 figure 7. Attaching roof trim and heater protector.

  • Page 21: Assemb

    2009 saunas ltr20091007, rev. A assemb ling your sauna 21 cu-400 sauna assembly remove the packaging panel marked “open this end” first to access the contents. Once the panel is removed, unscrew the cross-member support from inside the crate. Remove the contents from the crate and assemble in a plac...

  • Page 22: Assemb

    2009 saunas ltr20091007, rev. A assemb ling your sauna 22 figure 1. Bench assembly.

  • Page 23: Assemb

    2009 saunas ltr20091007, rev. A assemb ling your sauna 23 figure 2. Bench and floor attachment.

  • Page 24: Assemb

    2009 saunas ltr20091007, rev. A assemb ling your sauna 24 figure 3. Attaching the rear walls and back support.

  • Page 25: Assemb

    2009 saunas ltr20091007, rev. A assemb ling your sauna 25 figure 4. Attaching side walls.

  • Page 26: Assemb

    2009 saunas ltr20091007, rev. A assemb ling your sauna 26 figure 5. Attaching the front wall with door.

  • Page 27: Assemb

    2009 saunas ltr20091007, rev. A assemb ling your sauna 27 figure 6. Attaching the roof and heater protector.

  • Page 28: Assemb

    2009 saunas ltr20091007, rev. A assemb ling your sauna 28 the assembly of this sauna will require at least three people. The panels, roof top and roof assembly are heavy and difficult to lift by only one person. Assemble the bench. Screw the legs into the underside cross-support of the bench. After ...

  • Page 29: Assemb

    2009 saunas ltr20091007, rev. A assemb ling your sauna 29 place roof top panel onto the wall panel assembly. Place the 1” x 2” roof supports, inside the sauna, up 4. Against the roof top. Place the outside trim piece(s) flush with top of the roof. 5. Place the heater bracket around the heater and se...

  • Page 30: Assemb

    2009 saunas ltr20091007, rev. A assemb ling your sauna 30 warning: it will take two or more people to install the roof top. Do not attempt to lift it by yourself. Take each roof section and place side-by-side. Make sure the cross-beams are exposed and facing each 7. Other. There are pre-drilled hole...

  • Page 31: Assemb

    2009 saunas ltr20091007, rev. A assemb ling your sauna 31 od-200 assembly remove the packaging panel marked “open this end” first to access the contents. Once the panel is removed, unscrew the cross-member support from inside the crate. Remove the contents from the crate and assemble in a place with...

  • Page 32: Assemb

    2009 saunas ltr20091007, rev. A assemb ling your sauna 32 place roof top panel onto the wall panel assembly. Place the 1” x 2” roof supports, inside the sauna, up 4. Against the roof top. Place the outside trim piece(s) flush with top of the roof. 5. Place the heater bracket around the heater and se...

  • Page 33: Assemb

    2009 saunas ltr20091007, rev. A assemb ling your sauna 33 warning: it will take two or more people to install the roof top. Do not attempt to lift it by yourself. Take each roof section and place side-by-side. Make sure the cross-beams are exposed and facing each 7. Other. There are pre-drilled hole...

  • Page 34: Assemb

    2009 saunas ltr20091007, rev. A assemb ling your sauna 34 light installation (inside and outside) note: it is advised that all electrical connections be made by a licensed electrician. Use the decorative light for the outside. Attach the black wires to each other and attach the white wires to each o...

  • Page 35: Assemb

    2009 saunas ltr20091007, rev. A assemb ling your sauna 35 heater electrical installation the electrical heater is ul approved for permanent installations and electrical connections. Built with splash proof construction, the conducting parts are protected against water. All wiring must be performed i...

  • Page 36: Operating

    2009 saunas ltr20091007, rev. A operating your sauna 36 safety precautions review all the health and safety instructions. If in doubt as to the advisability of using your sauna, consult your physician. If you feel light-headed or heat-exhausted during a session, exit the sauna immediately. Select th...

  • Page 37: Operating

    2009 saunas ltr20091007, rev. A operating your sauna 37 how to take a sauna when taking a sauna, allow for time to relax. • remove clothing and jewelry. If required, wear • a towel loosely. After 10 minutes or when perspiration begins, • leave the sauna and relaxe in the dressing area. Follow with a...

  • Page 38: Ster

    2009 saunas ltr20091007, rev. A ster eo system 38 spas equipped with the marine grade audio system use the aquatic stereo receiver, amplifier and cd player. Each sauna equipped with this audio system is delivered with the manufacturer’s operating instructions. We strongly recommend that you read the...

  • Page 39: Ster

    2009 saunas ltr20091007, rev. A ster eo system 39 mounting the speaker and speaker box to mount the speaker box, place the l-bracket on the underside of the main bench and attach the 1. L-bracket using the provided screws. Slide the speaker box up between the l-brackets and attach them with four scr...

  • Page 40: Appendix

    2009 saunas ltr20091007, rev. A appendix 40 cleaning and maintenance a sauna requires little care and virtually no maintenance at all. When finished using the sauna, propping the door open will allow good air flow to dry out all of the wood surfaces. Deckboards can be lifted up to dry. A double laye...

  • Page 41: Appendix

    2009 saunas ltr20091007, rev. A appendix 41 troubleshooting guide problem: solution: there is no power. Make sure that both ends of the power cord are securely plugged in to their respective power 1. Outlets. Make sure that the circuit breaker has not been tripped. 2. Problem: solution: house breake...

  • Page 42: Appendix

    2009 saunas ltr20091007, rev. A appendix 42 accessories the following is a list of all the accessories that you can use with your cal sauna. If you wish to order an accessory, feel free to contact your dealer with the desired part name and part number, or visit www.Calspas. Com. If you choose to hav...

  • Page 43: Appendix

    2009 saunas ltr20091007, rev. A appendix 43 cu300 cu400 standard electrical rating two power source: one for heater and one for light optional options electrical ratings service 1 heater ratings cd player ratings phase 1 phase 1 voltage 240 vac voltage 120 vac amperage 33.3 amps amperage 3 amps wire...

  • Page 44: Appendix

    2009 saunas ltr20091007, rev. A appendix 44 replacement parts the following section contains the part numbers that will be needed for your reference in the event that parts need to be ordered. Cu-300 description part number quantity cu-300 side panel woo27306518 2 cu-300 front panel woo27306519 1 cu...

  • Page 45: Appendix

    2009 saunas ltr20091007, rev. A appendix 45 od-100 description part number quantity front panel, 69”x83”, aspen w0027100201 1 sauna light (purchased complete) lit16000020 1 door panel, 69”x83”, aspen w0027100204 1 sauna door handle woo27100885 1 back panel, 69”x83”, aspen w0027100202 1 side panel, 4...

  • Page 46: Appendix

    2009 saunas ltr20091007, rev. A appendix 46 5 year structural (outdoor saunas) lms warrants its outdoor saunas exterior siding against defects in materials and workmanship for a period of five years from the original date of purchase. All other outdoor sauna components are warranted against defects ...

  • Page 47: Appendix

    2009 saunas ltr20091007, rev. A appendix 47 warranty exclusions the limited warranty is void if the sauna has been subject to negligence, alteration, misuse, abuse, repairs by non-lms authorized representatives, incorrect electrical installation, acts of god and any other cases beyond the control of...

  • Page 48

    Locating the product serial number the serial number of your cal heat sauna is located on a metal plate attached to the lower side of the sauna.You will need this number to properly register your sauna and activate coverage. Write this information in the space provided below. Sauna model: __________...