1. DL manuals
  2. Cal Spas
  3. Hot Tub
  4. LTR20101001
  5. Owner's Manual

Cal Spas LTR20101001 Owner's Manual

Manual is about: All portable Spas

Summary of LTR20101001

  • Page 1

    Ltr20101001, rev. B 5/7/10

  • Page 2

    Important safety instructions basic spa information . . . . . . . . . . . . . . . . . . 3 preparing for your new portable spa planning the best location . . . . . . . . . . . . . . 5 preparing a good foundation . . . . . . . . . . . . 5 230 volt electrical installation . . . . . . . . . . . 6 rcd wi...

  • Page 3: Read

    2010 portable spa ltr20101001, rev. B read this first! Www.Calspas.Com 3 when installing and using this electrical equipment, always follow basic safety precautions. Following these instructions will help make your first spa session a pleasurable one. Read and follow all instructions a licensed elec...

  • Page 4: Read

    2010 portable spa ltr20101001, rev. B read this first! Www.Calspas.Com 4 handles located seat-side that increase the intensity of your massage. The filtering of this spa is very important. It will minimize cleaning time and the amount of chemicals needed to keep your spa water balanced. The two dail...

  • Page 5: Eparing F

    2010 portable spa ltr20101001, rev. B pr eparing f or your ne w p or tab le spa www.Calspas.Com 5 most cities and counties require permits for exterior construction and electrical circuits. In addition, some communities have codes requiring residential barriers such as fencing and/or self-closing ga...

  • Page 6: Eparing F

    2010 portable spa ltr20101001, rev. B pr eparing f or your ne w p or tab le spa www.Calspas.Com 6 230 volt electrical installation all 230v spas must be permanently connected (hardwired) to the power supply. These instructions describe the only acceptable electrical wiring procedure. Spas wired in a...

  • Page 7: Eparing F

    2010 portable spa ltr20101001, rev. B pr eparing f or your ne w p or tab le spa www.Calspas.Com 7 electrical installation for 8 .5 kw heater this applies to ultimate fitness spas with the 8.5 kw heater only. Two electrical services are required to heat the swim side of the fitness spa..

  • Page 8: Eparing F

    2010 portable spa ltr20101001, rev. B pr eparing f or your ne w p or tab le spa www.Calspas.Com 8 rcd wiring diagram rcd device.

  • Page 9: Eparing F

    2010 portable spa ltr20101001, rev. B pr eparing f or your ne w p or tab le spa www.Calspas.Com 9 gas heater hook-up ultimate fitness series spa owners may buy and install a separate gas heater and pump for use with their spa. This option may be purchased separately from your local distributor. Spa ...

  • Page 10: Eparing F

    2010 portable spa ltr20101001, rev. B pr eparing f or your ne w p or tab le spa www.Calspas.Com 10

  • Page 11: Eparing F

    2010 portable spa ltr20101001, rev. B pr eparing f or your ne w p or tab le spa www.Calspas.Com 11 filling and powering up your portable spa open the air relief valve (located next to the two 6. Filters, if equipped) after the air bubbles stop coming out of it. Close the valve hand-tight. Once the w...

  • Page 12: Operating

    2010 portable spa ltr20101001, rev. B operating your spa www.Calspas.Com 12 initial start up when first powered up, it will automatically revert to priming mode. A pr on the topside display will indicate this. Priming mode will be active for less than five minutes at which time the heater will be ac...

  • Page 13: Operating

    2010 portable spa ltr20101001, rev. B operating your spa www.Calspas.Com 13 light press the light button to turn on the light. Press it once again to turn the light off. All optional lighting such as the control panel light and cabinet perimeter lighting is controlled by the light button and will tu...

  • Page 14: Operating

    2010 portable spa ltr20101001, rev. B operating your spa www.Calspas.Com 14 diagnostic messages message meaning -- spa temperature is unknown. After pump has been running for 2 minutes temperature will be displayed. Hh overheat protection (spa is shutdown) do not enter the water! One sensor has dete...

  • Page 15: Operating

    2010 portable spa ltr20101001, rev. B operating your spa www.Calspas.Com 15 when first powered up, the electronic system will perform a self-diagnostic check and then it will automatically heat to and maintain a temperature of 37.5˚c until you change the set temperature as listed in the “temperature...

  • Page 16: Operating

    2010 portable spa ltr20101001, rev. B operating your spa www.Calspas.Com 16 option (optional blower) press the option button to turn the optional equipment on and off. If left on, the equipment will automatically turn off after 15 minutes. Light press the light button to turn the spa light on and of...

  • Page 17: Operating

    2010 portable spa ltr20101001, rev. B operating your spa www.Calspas.Com 17 periodic reminder messages press the “mode” button to reset a displayed reminder) message frequency action required rph every 7 days test and adjust chemical levels per manufacturer’s instructions. Rsa every 7 days test and ...

  • Page 18: Operating

    2010 portable spa ltr20101001, rev. B operating your spa www.Calspas.Com 18 lf persistent low flow problems. (displays on the fifth occurrence of the “hfl” message within 24 hours.) heater is shut down, but other spa functions continue to run normally. Follow action required for “hfl” message. Heati...

  • Page 19: Operating

    2010 portable spa ltr20101001, rev. B operating your spa www.Calspas.Com 19 auxiliary control operation the auxiliary control option is available with the 8005 control only. It is a small panel with four buttons: jets1, jets2, light, and option (see figure at right). It conveniently puts the control...

  • Page 20: Operating

    2010 portable spa ltr20101001, rev. B operating your spa www.Calspas.Com 20 diverter knobs diverter knobs are the larger knobs located around the top of your spa. They allow you to divert water through jets from one side of the spa to the other, or in most cases from floor jets to wall jets. This is...

  • Page 21: Operating

    2010 portable spa ltr20101001, rev. B operating your spa www.Calspas.Com 21 automatically and the green led light on the panel will continue to blink for one minute then shut off automatically. After the second 15-minute session, the system will run through a cool down cycle for up to two hours. In ...

  • Page 22: Ater Quality Maintenance

    2010 portable spa ltr20101001, rev. B w ater quality maintenance www.Calspas.Com 22 cal spas clear water plan great spa water is easily achieved when the right chemicals and / or systems are used and the cal spas “clear water plan” is implemented. The key to clean, clear, and safe water is to fully ...

  • Page 23: Ater Quality Maintenance

    2010 portable spa ltr20101001, rev. B w ater quality maintenance www.Calspas.Com 23 never mix chemicals together. • never change chemical brands or types without • completely draining, flushing and thoroughly cleaning the spa and cover first. Always protect your eyes while introducing • chemicals in...

  • Page 24: Ater Quality Maintenance

    2010 portable spa ltr20101001, rev. B w ater quality maintenance www.Calspas.Com 24 chemical descriptions the following descriptions and recommendations are intended for use with cal spas chemicals only. Many of these chemicals will be used with alternative sanitation systems as well. For use with a...

  • Page 25: Ater Quality Maintenance

    2010 portable spa ltr20101001, rev. B w ater quality maintenance www.Calspas.Com 25 for use with the chlorine “clear water plan” chlorinating granules quick acting sanitizer / disinfectant for spa water. Test strips – chlorine provides accurate spa water testing for bromine, ph, and total alkalinity...

  • Page 26: Ater Quality Maintenance

    2010 portable spa ltr20101001, rev. B w ater quality maintenance www.Calspas.Com 26 traditional chemical start up prior to filling a spa for the first time, or after a routine draining, you will want to follow this start-up plan to extend water life and performance. If you are following either the b...

  • Page 27: Ater Quality Maintenance

    2010 portable spa ltr20101001, rev. B w ater quality maintenance www.Calspas.Com 27 chlorine clear water plan this plan and its chemical dosages are intended for cal spas chemicals only. Most chemical manufacturers use different chemical formulas and strengths. Only cal spas chemicals are specially ...

  • Page 28: Ater Quality Maintenance

    2010 portable spa ltr20101001, rev. B w ater quality maintenance www.Calspas.Com 28 bromine generator clear water plan this plan and its chemical dosages are intended for spas equipped with the optional cal clarity automatic bromine generator. The chemical references are designed for cal spas chemic...

  • Page 29: Ater Quality Maintenance

    2010 portable spa ltr20101001, rev. B w ater quality maintenance www.Calspas.Com 29 use sodium bromide test strips (not bromine) and 12. Adjust sodium bromide level to 7.4 to 8.2 (equates to 1700 to 2500 ppm tds / conductivity level). Add 2 oz. Of cal spas “oxidizer shock” to help 13. Burn out impur...

  • Page 30: Cleaning and Maintenance

    2010 portable spa ltr20101001, rev. B cleaning and maintenance www.Calspas.Com 30 removing and reseating the pillows you can remove the pillows for cleaning and maintenance quickly and easily. This method works for all types of pillows. Grab the lower edge of the pillow with both hands firmly and pu...

  • Page 31: Cleaning and Maintenance

    2010 portable spa ltr20101001, rev. B cleaning and maintenance www.Calspas.Com 31 draining your portable spa your spa should be drained every four to six months, and refilled with fresh tap water. The following is the recommended method for draining your spa. Turn off the power at the breaker. 1. Re...

  • Page 32: Cleaning and Maintenance

    2010 portable spa ltr20101001, rev. B cleaning and maintenance www.Calspas.Com 32 wipe pillows dry. 3. Allow pillows to dry completely. 4. Warning: do not use automotive vinyl protectants on spa covers or pillows. These products are generally oil-based and will cause severe water clarity issues that...

  • Page 33: Cleaning and Maintenance

    2010 portable spa ltr20101001, rev. B cleaning and maintenance www.Calspas.Com 33 fast sheen (spa finish protecting wax) cal spas™ fast sheen is an essential part of maintaining your spa’s finish. Through normal use, the spa’s finish can accumulate dirt, oil, and calcium, causing a rough feel and un...

  • Page 34: Using The Enter

    2010 portable spa ltr20101001, rev. B using the enter tainment system www.Calspas.Com 34 some spas may be equipped with audio entertain- ment options. Several options are available and in- clude marine grade cd players and an ipod ® docking station. Each spa equipped with an audio system is delivere...

  • Page 35: Appendix

    2010 portable spa ltr20101001, rev. B appendix www.Calspas.Com 35 replacement parts jets crw 5 .5” power storm stainless steel: plu21703677 cobalt blue: plu21703677-blu ed 2 .25” euro directional stainless steel: plu21703674 cobalt blue: plu21703662-blu ele 2 .25” euro less eyeball stainless steel: ...

  • Page 36: Appendix

    2010 portable spa ltr20101001, rev. B appendix www.Calspas.Com 36 jets sfw 5 .5” sure flow stainless steel: plu21703626 cobalt blue: plu21703626-blu sw swim plu21700565 sxw 5 .5” storm, 2 hole stainless steel: plu21703623 cobalt blue: plu21703623-blu t 5 .25” tornado stainless steel: plu21703629 cob...

  • Page 37: Appendix

    2010 portable spa ltr20101001, rev. B appendix www.Calspas.Com 37 pillows quad acc01400931 neck blaster acc01401010 cascade (logo) acc01401030 infinity acc01400950 neck acc01401040 drains main drain, super hi flo suction 2 1/2” silver plu21400137 bottom drain star suction cover plu21400197 bottom dr...

  • Page 38: Appendix

    2010 portable spa ltr20101001, rev. B appendix www.Calspas.Com 38 lights light assembly complete lit16000150 light mini 2” diameter lit16000151 walfitting, clear lens cap, jumbo spa light, 5” lit16100153 red lens insert, jumbo spa light lit16100155 blue lens insert, jumbo spa light lit16100156 ozone...

  • Page 39: Appendix

    2010 portable spa ltr20101001, rev. B appendix www.Calspas.Com 39 covers avalon series a515/a526/a534 84” x 64” standard rust acc01200460 standard gray acc01200461 standard slate acc01200464 standard palomino acc01200466 deluxe rust acu02200500 deluxe gray acu02200501 deluxe slate acu02200502 deluxe...

  • Page 40: Appendix

    2010 portable spa ltr20101001, rev. B appendix www.Calspas.Com 40 d950n / d965n / d963s / d950s 93” x 130” standard rust acc01200450 standard gray acc01200451 standard slate acc01200452 standard palomino acc01200454 deluxe rust acu02200290 deluxe gray acu02200291 deluxe slate acu02200295 deluxe palo...

  • Page 41: Appendix

    2010 portable spa ltr20101001, rev. B appendix www.Calspas.Com 41 family ii series fii515b 78” round standard rust standard gray standard slate standard palomino deluxe rust deluxe gray deluxe slate deluxe palomino deluxe teal deluxe navy deluxe hunter fii518b 43” x 83” standard rust standard gray s...

  • Page 42: Appendix

    2010 portable spa ltr20101001, rev. B appendix www.Calspas.Com 42 victory xtreme series vx901 72” x 72” standard rust acc01200566 standard gray acc01200567 standard slate acc01200568 standard palomino acc01200559 fx624b 76” x 84” standard rust acc01200406 standard gray acc01200407 standard slate acc...

  • Page 43: Appendix

    2010 portable spa ltr20101001, rev. B appendix www.Calspas.Com 43 keeping fit with your cal spa important: always consult your physician before starting any exercise activity or program. The fitness series spas feature rubber exercise bands. When stretched, these bands create a high tension conditio...

  • Page 44: Appendix

    2010 portable spa ltr20101001, rev. B appendix www.Calspas.Com 44 connecting the exercise equipment the drawings below show different ways the exercise kit can be connected depending on the exercises you wish to do..

  • Page 45: Appendix

    2010 portable spa ltr20101001, rev. B appendix www.Calspas.Com 45 cal spas™ chemicals.

  • Page 46: Appendix

    2010 portable spa ltr20101001, rev. B appendix www.Calspas.Com 46 2010 warranty international portable spas all cal spas portable spas are warranted to be free from defects in material and workmanship at the time of delivery. This warranty becomes valid at time of purchase and ends either by specifi...

  • Page 47: Appendix

    2010 portable spa ltr20101001, rev. B appendix www.Calspas.Com 47 proration of warranty units determined by the company to be non-repairable will be replaced on a prorated basis with the same or a comparable unit. The user will be charged one percent of the current retail cost for each full month of...

  • Page 48

    Locating the product serial number the serial number of your cal spa is located on a metal plate attached to the lower right front panel of the spa.You will need this number to properly register your spa and activate coverage. Write this information in the space provided below. Cal spa model: ______...