1. DL manuals
  2. Cal Spas
  3. Hot Tub
  4. Portable Spas
  5. Owner's Manual

Cal Spas Portable Spas Owner's Manual

Other manuals for Portable Spas: Owner's Manual
Manual is about: Cal Spas All Portable Spa Owner's Manual

Summary of Portable Spas

  • Page 1

    Ltr20091001, rev. A 12/15/08.

  • Page 2

    Read this first! Important safety instructions . . . . . . . . . . . . . . . . . .3 basic spa information . . . . . . . . . . . . . . . . . . . . . . . .3 preparing for your new portable spa planning the best location . . . . . . . . . . . . . . . . . . . .5 preparing a good foundation . . . . . . ....

  • Page 3: Read This First!

    2009 portable spa owner’s manual page 3 ltr20091001, rev. A read this first! Read this first! Important safety instructions when installing and using this electrical equipment, always follow basic safety precautions. Following these instructions will help make your first spa session a pleasurable on...

  • Page 4

    Page 4 2009 portable spa owner’s manual ltr20091001, rev. A read this first! In addition to the water pressure, you can add air into the spa water with air venturi handles located seat-side that increase the intensity of your massage. The filtering of this spa is very important. It will minimize cle...

  • Page 5: Preparing A Good Foundation

    2009 portable spa owner’s manual page 5 ltr20091001, rev. A preparing for your new portable spa preparing for your new portable spa most cities and counties require permits for exterior construction and electrical circuits. In addition, some communities have codes requiring residential barriers such...

  • Page 6

    Page 6 2009 portable spa owner’s manual ltr20091001, rev. A preparing for your new portable spa 230 volt electrical installation all 230v spas must be permanently connected (hardwired) to the power supply. These instructions describe the only acceptable electrical wiring procedure. Spas wired in any...

  • Page 7

    2009 portable spa owner’s manual page 7 ltr20091001, rev. A preparing for your new portable spa electrical installation for 8 .5 kw heater this applies to ultimate fitness spas with the 8.5 kw heater only. Two electrical services are required to heat the swim side of the fitness spa..

  • Page 8: Rcd Wiring Diagram

    Page 8 2009 portable spa owner’s manual ltr20091001, rev. A preparing for your new portable spa rcd wiring diagram rcd device.

  • Page 9: Gas Heater Hook-Up

    2009 portable spa owner’s manual page 9 ltr20091001, rev. A preparing for your new portable spa gas heater hook-up ultimate fitness series spa owners may buy and install a separate gas heater and pump for use with their spa. This option may be purchased separately from your local distributor. Spa ow...

  • Page 10

    Page 10 2009 portable spa owner’s manual ltr20091001, rev. A preparing for your new portable spa.

  • Page 11

    2009 portable spa owner’s manual page 11 ltr20091001, rev. A preparing for your new portable spa filling and powering up your portable spa once the water is at the correct level and air is bled, 7. Turn on the power at the rcd breaker. Note: when the power is turned on to the spa, it will perform a ...

  • Page 12: Operating Your Spa

    Page 12 2009 portable spa owner’s manual ltr20091001, rev. A operating your spa initial start up when first powered up, it will automatically revert to priming mode. A pr on the topside display will indicate this. Priming mode will be active for less than five minutes at which time the heater will b...

  • Page 13

    2009 portable spa owner’s manual page 13 ltr20091001, rev. A operating your spa diagnostic messages message meaning -- spa temperature is unknown. After pump has been running for 2 minutes temperature will be displayed. Hh overheat protection (spa is shutdown) do not enter the water! One sensor has ...

  • Page 14

    Page 14 2009 portable spa owner’s manual ltr20091001, rev. A operating your spa lf this will display on the 5th occurrence of the “hl” message in 24 hours indicating a persistent flow problem. The heater will be shut down but other functions will continue to operate. Follow “hl” message actions then...

  • Page 15

    2009 portable spa owner’s manual page 15 ltr20091001, rev. A operating your spa when first powered up, the electronic system will perform a self-diagnostic check and then it will automatically heat to and maintain a temperature of 37.5˚c until you change the set temperature as listed in the “tempera...

  • Page 16

    Page 16 2009 portable spa owner’s manual ltr20091001, rev. A operating your spa turns on automatically, it cannot be deactivated from the panel; however, the high speed may be started. Option (optional blower) press the option button to turn the optional equipment on and off. If left on, the equipme...

  • Page 17

    2009 portable spa owner’s manual page 17 ltr20091001, rev. A operating your spa periodic reminder messages press the “mode” button to reset a displayed reminder) message frequency action required rph every 7 days test and adjust chemical levels per manufacturer’s instructions. Rsa every 7 days test ...

  • Page 18

    Page 18 2009 portable spa owner’s manual ltr20091001, rev. A operating your spa lf persistent low flow problems. (displays on the fifth occurrence of the “hfl” message within 24 hours.) heater is shut down, but other spa functions continue to run normally. Follow action required for “hfl” message. H...

  • Page 19: Auxiliary Control Operation

    2009 portable spa owner’s manual page 19 ltr20091001, rev. A operating your spa auxiliary control operation the auxiliary control option is available with the 8005 control only. It is a small panel with four buttons: jets1, jets2, light, and option (see figure at right). It conveniently puts the con...

  • Page 20: Diverter Knobs

    Page 20 2009 portable spa owner’s manual ltr20091001, rev. A operating your spa diverter knobs diverter knobs are the larger knobs located around the top of your spa. They allow you to divert water through jets from one side of the spa to the other, or in most cases from floor jets to wall jets. Thi...

  • Page 21: Multi-Colored Spa Light

    2009 portable spa owner’s manual page 21 ltr20091001, rev. A operating your spa second 15-minute session, the system will run through a cool down cycle for up to two hours. In this cool down mode, the user will only be able to operate the pump (by again pressing the “pump on/off” button). However, t...

  • Page 22: Water Quality Maintenance

    Page 22 2009 portable spa owner’s manual ltr20091001, rev. A water quality maintenance water quality maintenance cal spas clear water plan great spa water is easily achieved when the right chemicals and / or systems are used and the cal spas “clear water plan” is implemented. The key to clean, clear...

  • Page 23: Chemical Safety

    2009 portable spa owner’s manual page 23 ltr20091001, rev. A water quality maintenance chemical safety failure to follow chemical directions may result in • serious injury, sickness, or even death. Read and follow all printed instructions listed on • bottles, packages and in your owner’s manual. Do ...

  • Page 24: Chemical Descriptions

    Page 24 2009 portable spa owner’s manual ltr20091001, rev. A water quality maintenance chemical descriptions the following descriptions and recommendations are intended for use with cal spas chemicals only. Many of these chemicals will be used with alternative sanitation systems as well. For use wit...

  • Page 25

    2009 portable spa owner’s manual page 25 ltr20091001, rev. A water quality maintenance for use with the chlorine “clear water plan” chlorinating granules quick acting sanitizer / disinfectant for spa water. Test strips – chlorine provides accurate spa water testing for bromine, ph, and total alkalin...

  • Page 26: Bromine Clear Water Plan

    Page 26 2009 portable spa owner’s manual ltr20091001, rev. A water quality maintenance traditional chemical start up prior to filling a spa for the first time, or after a routine draining, you will want to follow this start-up plan to extend water life and performance. If you are following either th...

  • Page 27: Chlorine Clear Water Plan

    2009 portable spa owner’s manual page 27 ltr20091001, rev. A water quality maintenance chlorine clear water plan this plan and its chemical dosages are intended for cal spas chemicals only. Most chemical manufacturers use different chemical formulas and strengths. Only cal spas chemicals are special...

  • Page 28

    Page 28 2009 portable spa owner’s manual ltr20091001, rev. A water quality maintenance bromine generator clear water plan this plan and its chemical dosages are intended for spas equipped with the optional cal clarity automatic bromine generator. The chemical references are designed for cal spas che...

  • Page 29: Maintenance Schedule

    2009 portable spa owner’s manual page 29 ltr20091001, rev. A water quality maintenance use sodium bromide test strips (not bromine) and 12. Adjust sodium bromide level to 7.4 to 8.2 (equates to 1700 to 2500 ppm tds / conductivity level). Add 2 oz. Of cal spas “oxidizer shock” to help burn 13. Out im...

  • Page 30: Cleaning and Maintenance

    Page 30 2009 portable spa owner’s manual ltr20091001, rev. A cleaning and maintenance cleaning and maintenance removing and reseating the pillows you can remove the pillows for cleaning and maintenance quickly and easily. This method works for all types of pillows. Grab the lower edge of the pillow ...

  • Page 31: Draining Your Portable Spa

    2009 portable spa owner’s manual page 31 ltr20091001, rev. A cleaning and maintenance draining your portable spa your spa should be drained every four to six months, and refilled with fresh tap water. The following is the recommended method for draining your spa. Turn off the power at the breaker. 1...

  • Page 32: Pillows

    Page 32 2009 portable spa owner’s manual ltr20091001, rev. A cleaning and maintenance warning: do not use automotive vinyl protectants on spa covers or pillows. These products are generally oil- based and will cause severe water clarity issues that are difficult to correct. All-purpose cleaner (spa ...

  • Page 33: Cleaning and Replacing The

    2009 portable spa owner’s manual page 33 ltr20091001, rev. A cleaning and maintenance can accumulate dirt, oil, and calcium, causing a rough feel and unsightly scum lines. Cal spas™ fast sheen is a non-oil based wax that is specifically formulated to protect the spa’s finish from the chemicals and m...

  • Page 34: Operating The Cd Player

    Page 34 2009 portable spa owner’s manual ltr20091001, rev. A using the entertainment system some spas may be equipped with audio/visual entertainment options. Several options are available and include marine grade cd players, dvd players, and an ipod ® docking station. Two different tv monitors are ...

  • Page 35: Using The Universal Remote

    2009 portable spa owner’s manual page 35 ltr20091001, rev. A using the entertainment system use the remote control to navigate the dvd menu 4. Using the fast forward and fast reverse buttons located at the lower part of the universal remote. To remove the disk, press the open button on the dvd 5. Pl...

  • Page 36: Programming The Universal

    Page 36 2009 portable spa owner’s manual ltr20091001, rev. A using the entertainment system programming the universal remote control the cal spas universal remote has been pre- programmed to function with the entertainment system the spa has been configured with. However, in case you need to reprogr...

  • Page 37: Appendix

    2009 portable spa owner’s manual page 37 ltr20091001, rev. A appendix appendix replacement parts jet type description standard gray face stainless steel face cxlw 6.5” power storm jet directional plu21703421 plu21703622 cxw 5.5”. Power storm jet, directional plu21703425 plu21703624 e / ew / ep / epw...

  • Page 38

    Page 38 2009 portable spa owner’s manual ltr20091001, rev. A appendix mjlw 6.5”, power storm jet, directional plu21703422 plu21703625 mjw 5.5”, power storm jet, directional plu21703423 plu21703600 mnw 2.5”, neck jet, quad blaster plu21703427 plu21703628 msrw / mfs 3”, storm jet, micro swirl w/drk ey...

  • Page 39

    2009 portable spa owner’s manual page 39 ltr20091001, rev. A appendix sxw 5.5”, power storm jet, swirley plu21703424 plu21703623 tw 4.75”, power swim jet tornado plu21703428 plu21703629 w whirlpool plu21703122 ozone injector jet plu21700818 directional jet euro plu21703643 air injector cap fix125000...

  • Page 40

    Page 40 2009 portable spa owner’s manual ltr20091001, rev. A appendix valves plu21300052 diverter valve 1” (2 way) silver, teardrop handle (2 tone) plu21300062 diverter valve 2” (2 way) silver, teardrop handle (2 tone) plu21700378 vent, 1” air control silver, teardrop (2 tone) plu21700637 aromathera...

  • Page 41

    2009 portable spa owner’s manual page 41 ltr20091001, rev. A appendix filters fil11100190 filter cartridge, 50 sq ft. Anti-bacterial red fil11100191 filter cartridge, 75 sq ft. Anti-bacterial white fil11100193 filter cartridge, 35 sq ft. Anti-bacterial white fil11100125 filter cartridge cal 75 sq ft...

  • Page 42

    Page 42 2009 portable spa owner’s manual ltr20091001, rev. A appendix covers avalon series a515/a526/a534 - 84 x 64 standard rust acc01200460 standard gray acc01200461 standard slate acc01200464 standard palomino acc01200466 deluxe rust acu02200500 deluxe gray acu02200501 deluxe slate acu02200502 de...

  • Page 43

    2009 portable spa owner’s manual page 43 ltr20091001, rev. A appendix classic/legacy newporter - 93 x 130 standard rust acc01200450 standard gray acc01200451 standard slate acc01200452 standard palomino acc01200454 deluxe rust acu02200290 deluxe gray acu02200291 deluxe slate acu02200295 deluxe palom...

  • Page 44

    Page 44 2009 portable spa owner’s manual ltr20091001, rev. A appendix dij-404 - 93 x 130 deluxe rust acu02200339 deluxe gray acu02200343 deluxe slate acu02200344 deluxe palomino acu02200338 deluxe teal acu02200345 deluxe navy acc02200346 deluxe hunter acc02200347 dij-405 - 93 x 130 deluxe rust acu02...

  • Page 45

    2009 portable spa owner’s manual page 45 ltr20091001, rev. A appendix fii530 - 84 x 64 standard rust acc01200460 standard gray acc01200461 standard slate acc01200464 standard palomino acc01200466 deluxe rust acu02200500 deluxe gray acu02200501 deluxe slate acu02200502 deluxe palomino acu02200499 del...

  • Page 46

    Page 46 2009 portable spa owner’s manual ltr20091001, rev. A appendix vx834b/l, vx848b/l, vx860b/l - 93 x 93 standard rust acc01200420 standard gray acc01200421 standard slate acc01200422 standard palomino acc01200423 deluxe rust acu02200260 deluxe gray acu02200261 deluxe slate acu02200266 deluxe pa...

  • Page 47

    2009 portable spa owner’s manual page 47 ltr20091001, rev. A appendix keeping fit with your cal spa important: always consult your physician before starting any exercise activity or program. The fitness series spas feature rubber exercise bands. When stretched, these bands create a high tension cond...

  • Page 48

    Page 48 2009 portable spa owner’s manual ltr20091001, rev. A appendix connecting the exercise equipment the drawings below show different ways the exercise kit can be connected depending on the exercises you wish to do..

  • Page 49: Cal Spas™ Chemicals

    2009 portable spa owner’s manual page 49 ltr20091001, rev. A appendix cal spas™ chemicals.

  • Page 50: 2009 Warranty

    Page 50 2009 portable spa owner’s manual ltr20091001, rev. A appendix 2009 warranty international portable spas all cal spas portable spas are warranted to be free from defects in material and workmanship at the time of delivery. This warranty becomes valid at time of purchase and ends either by spe...

  • Page 51

    2009 portable spa owner’s manual page 51 ltr20091001, rev. A appendix proration of warranty units determined by the company to be non-repairable will be replaced on a prorated basis with the same or a comparable unit. The user will be charged one percent of the current retail cost for each full mont...

  • Page 52

    Locating the product serial number the serial number of your cal spa is located on a metal plate attached to the lower right front panel of the spa.You will need this number to properly register your spa and activate coverage. Write this information in the space provided below. Cal spa model: ______...