1. DL manuals
  2. California Air Tools
  3. Air Compressor
  4. 250DLT
  5. Owner's Manual

California Air Tools 250DLT Owner's Manual

Manual is about: Air Compressor

Summary of 250DLT

  • Page 1

    Air compressor owner's manual california air tools 263dlh www.Californiaairtools.Com customer support 1-866-409-4581.

  • Page 2

    2 customer support: 1-866-409-4581 air compressor model: 263dlh table of contents introduction __________________________________2 important safety instructions _______________3 locations of important labels _______________6 air compressor components__________________7 pre-operation checklist ______...

  • Page 3: Danger

    3 customer support: 1-866-409-4581 air compressor how to find a local service center: even quality built equipment might need service or repair parts. Contact the california air tools customer service department: phone: 1-866-409-4581 online: www.Californiaairtools.Com please provide the information...

  • Page 4: Warning

    4 customer support: 1-866-409-4581 air compressor dust or dust-like particulates caused by power-sanding, sawing, grinding, drilling or any other construction-like activities can contain contaminants that are harmful to breathe. Always use your air compressor in a well-ventilated and clean area. Nev...

  • Page 5: Warning

    5 customer support: 1-866-409-4581 air compressor improper care could lead to the air tank bursting or exploding. Drain air tank daily or after each use to prevent moisture buildup in the air tank. Rust can weaken the air tank and cause leaks or bursting. If rust is detected, replace tank immediatel...

  • Page 6

    6 customer support: 1-866-409-4581 air compressor locations of important labels read these important labels before operating. These labels provide important safety and maintenance information. These labels should be considered as permanent parts of the air compressor. Should any of these labels beco...

  • Page 7: Model: 263Dlh

    7 customer support: 1-866-409-4581 air compressor model: 263dlh no. Description no. Description no. Description no. Description 1 crankcase 21 bolt 41 rotor 61 regulator 2 crank shaft 22 valve gasket 42 bearing 62 1/4" quick connector 3 gasket 23 valve 43 oil seal gasket 63 2" pressure gauge 4 crank...

  • Page 8: Package Contents

    8 customer support: 1-866-409-4581 air compressor pre-operation checklist package contents model: 263dlh package contents: n air compressor n owner's manual n air filter n bottle of oil n wheel kit inspect for damage before using the air compressor, make sure the air tank is not damaged, inspect all...

  • Page 9: Electrical Power

    9 customer support: 1-866-409-4581 air compressor electrical power electrical power requirements before using the air compressor, refer to the serial label for voltage and amperage requirements. Make sure you have a sufficient electrical supply for supporting the motor's requirements. Use a dedicate...

  • Page 10: Test Run

    10 customer support: 1-866-409-4581 air compressor test run before using the air compressor for the first time, complete a test run as follows: 1. Turn the power switch to the off position. Make sure the drainage valve is in the off position. Plug the power supply cord into a power supply socket. St...

  • Page 11: Draining The Air Tank

    11 customer support: 1-866-409-4581 air compressor maintenance draining the air tank the frequency at which you should drain the air tank depends on the environmental conditions and the amount of operating time logged. The average draining frequency is every 2 to 3 days. 1. Place the air compressor ...

  • Page 12

    12 customer support: 1-866-409-4581 air compressor troubleshooting problem possible cause possible solutions pressure drop in the tank. Air leaks at connections. Let the compressor build pressure in the tank, to the maximum pressure if possible. Brush soapy water on air connections and look carefull...

  • Page 13

    13 customer support: 1-866-409-4581 specifications electrical circuit air passage drawing air compressor motor earth wire (green) red cords for capacitor electric cord for motor solenoid valve electric cord for motor pressure switch overload protector (max temperature 135°c) pressure switch safety v...

  • Page 14: Limited Warranty

    14 customer support: 1-866-409-4581 air compressor california air tools inc. Limited warranty this warranty is limited to air compressors distributed by: california air tools, inc. 8560 siempre viva road, unit 3a san diego, ca 92154 limited warranty california air tools inc. Will repair or replace, ...

  • Page 15: Registration

    15 customer support: 1-866-409-4581 air compressor exclusions in addition to the foregoing disclaimers, limitations and terms, this limited warranty shall not apply to and does not cover accessories, nor does it cover products that are in any way subject to any of the following: 1. Improper setup, i...

  • Page 16

    16 customer support: 1-866-409-4581 air compressor product registration to register your product, please complete the information below and mail to the mailing address at the end of this page. 1. Personal information: full name (include middle initial): ______________________________________________...